Abstract:
:The direct microbial conversion (DMC) process for the production of ethanol from lignocellulosic biomass is limited by low volumetric ethanol production rates due to the low cell densities of Clostridium thermosaccharolyticum which is a key organism for ethanol production in this process. Hence, this study focuses on the use of a continuous- culture cell recycle system to improve the volumetric ethanol productivity and yield of the fermentation of xylose by C. thermosaccharolyticum. Early experiments with the continuous-culture cell recycle system showed a two-fold improvement in volumetric ethanol productivity. However, the ethanol yield at the higher dilution rates suffered because of the large amount of lactate produced. The manipulation of two environmental parameters--iron concentration in the nutrient medium and the N(2) purge rate of the fermentor headspace--allowed a dramatic reduction in the lactate production and a simultaneous improvement in the ethanol titer and yield. Under the improved conditions of increased iron concentration (12.5 mg/L FeSO(4) x 7H(2)O) and decreased N(2) purge rate (0.1 L/min), a continuous culture of C. thermosaccharolyticum operating at a dilution rate of 0.24 h(-1) and 50% cell recycle produced 8.6 g/L ethanol and less than 1 g/L each of acetate and lactate. The volumetric ethanol productivity was 2.2 g/L/h, which is 8 times larger than obtained for a continuous culture operated with no cell recycle and the same specific growth rate.
journal_name
Biotechnol Bioengjournal_title
Biotechnology and bioengineeringauthors
Mistry FR,Cooney CLdoi
10.1002/bit.260341008subject
Has Abstractpub_date
1989-12-05 00:00:00pages
1295-304issue
10eissn
0006-3592issn
1097-0290journal_volume
34pub_type
杂志文章abstract::This study examines protein adsorption behavior and the effects of mobile phase modifiers in multimodal chromatographic systems. Chromatography results with a diverse protein library indicate that multimodal and ion exchange resins have markedly different protein binding behavior and selectivity. NMR results corrobora...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.23318
更新日期:2012-01-01 00:00:00
abstract::Two instruments were developed to mechanize the handling of anaerobic microorganisms for microbial mutant isolation. The instruments automatically dispense liquid or agar medium to large and small 96-well platesand petridishes. Protocols were developed for inoculating different microorganisms, and calibration curves o...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260280905
更新日期:1986-09-01 00:00:00
abstract::In this report, alpha-Amylase originating from Bacillus subtilis (liquefying type) was immobilized on partially imidoesterized polyacrylonitrile (PAN) by covalent bonding. For the preparation of immobilized alpha-amylase, which has a high activity and high stability to repeated use, the optimum conditions for the prep...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260251212
更新日期:1983-12-01 00:00:00
abstract::Previous studies suggest that secretion of cloned proteins synthesized by recombinant Chinese hamster ovary (CHO) cells can be adenosine triphosphate (ATP) limited. Other research indicates that the presence of cloned Vitreoscilla hemoglobin (VHb) enhances ATP production in oxygen-limited Escherichia coli. To evaluate...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260441114
更新日期:1994-12-01 00:00:00
abstract::Expanded bed adsorption is a new downstream processing technique forcapture of proteins directly from unclarified feedstocks. Expanded bed adsorption reduces the number of operations in purification processes by combining clarification, concentration, and capture into one operation. It is based on stable fluidization ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260440808
更新日期:1994-10-01 00:00:00
abstract::The suitability of using annually grown, carrot-sized buffalo gourd (Cucurbita foetidissima) roots as a feedstock for alcoholic fermentation was explored. Roots grown in 1982 and 1983 were slurried, dextrinized and saccharified using Takathermtrade mark and Diazymetrade mark (commercial enzymes manufactured by Miles L...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260290406
更新日期:1987-03-01 00:00:00
abstract::The characteristics of horseradish peroxidase (HRP) immobilized onto Sepharose by a photochemical-initiated graft copolymerization are presented. Active copolymers were synthesized using different amounts of glycidylmethacrylate (GMA), bisacryloylpiperazine (BAP), or 1,3,5-hexhydrotriacryloyl-(s)-triazine (HTsT) as fu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260250310
更新日期:1983-03-01 00:00:00
abstract::Although sophorolipids (SLs) produced by S. bombicola are a real showcase for the industrialization of microbial biosurfactants, some important drawbacks are associated with this efficient biological process, e.g., the simultaneous production of acidic and lactonic SLs. Depending on the application, there is a require...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.25815
更新日期:2016-03-01 00:00:00
abstract::Whole cell pyruvate decarboxylase (PDC) from Candida utilis enhanced the enzymatic production of (R)-phenylacetylcarbinol (PAC) in an aqueous/octanol biotransformation compared to the partially purified PDC especially for a lower range of initial activities (0.3-2.5 U/mL). With an initial activity of 1.1 U/mL and at a...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20959
更新日期:2006-08-20 00:00:00
abstract::The knowledge of critical process-relevant genes can be used for an improved control of bioprocesses. So far bioprocess-relevant marker genes can be analyzed by established expression analysis methods only off-line. In this study, an alternative approach for a potential at-line monitoring of gene expression during bio...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20578
更新日期:2005-11-05 00:00:00
abstract::Frozen bagged seed inoculum was prepared, thawed and tested for seven cultures. Thawing techniques were developed and other key influences on thawing rate were quantified; seed bag thawing without a water bath rarely required more than 4 to 5 h and was as short as 0.5 to 1 h for lower fill volume bags. Testing include...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10323
更新日期:2002-09-20 00:00:00
abstract::Based on the recently constructed Escherichia coli itaconic acid production strain ita23, we aimed to improve the productivity by applying a two-stage process strategy with decoupled production of biomass and itaconic acid. We constructed a strain ita32 (MG1655 ΔaceA Δpta ΔpykF ΔpykA pCadCs), which, in contrast to ita...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26446
更新日期:2018-01-01 00:00:00
abstract::Three-dimensional cell culture models, such as spheroids, can be used in the process of the development of new anticancer agents because they are able to closely mimic the main features of human solid tumors, namely their structural organization, cellular layered assembling, hypoxia, and nutrient gradients. These prop...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章,评审
doi:10.1002/bit.26845
更新日期:2019-01-01 00:00:00
abstract::Immunotherapy with ex vivo cultured T cells depends on a large supply of biologically active cells. Understanding the effects of culture parameters is essential for improving the proliferation and efficacy of the expanded cells. Low oxygen tension (5% pO(2)) was previously reported to improve T-cell expansion and alte...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20166
更新日期:2004-08-20 00:00:00
abstract::Phage Φ80 can infect Escherichia coli in a stealthy manner and persist by forming lysogens. Such Φ80 lysogens are fairly common and often go undetected unless the host is grown at temperatures below 37°C. Since low growth temperatures are required for growing temperature-sensitive mutants and often preferred for large...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26971
更新日期:2019-07-01 00:00:00
abstract::Nitrous oxide (N2 O), a potent greenhouse gas, is reduced to N2 gas by N2 O-reducing bacteria (N2 ORB), a process which represents an N2 O sink in natural and engineered ecosystems. The N2 O sink activity by N2 ORB depends on temperature and O2 exposure, yet the specifics are not yet understood. This study explores th...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27654
更新日期:2020-12-11 00:00:00
abstract::In order to eliminate organic pollutants in waste gases, a biological filter bed technique has been developed, with a high self-regenerating capacity and a low pressure drop. The bed consists of an appropriate filling material (mainly peat compost), in order to let the microorganisms grow on the solid surface and to s...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260251222
更新日期:1983-12-01 00:00:00
abstract::Buddleja davidii is a unique biomass that has many attractive agroenergy features, especially its wide range of growth habitat. The anatomical characteristics of B. davidii were investigated before and after ethanol organosolv pretreatment (one of the leading pretreatment technologies) in order to further understand t...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22884
更新日期:2010-12-01 00:00:00
abstract::Metabolic engineering of isopropyl alcohol (IPA)-producing Escherichia coli strains was conducted along with 13 C-metabolic flux analysis (MFA). A metabolically engineered E. coli strain expressing the adc gene derived from Clostridium acetobutylicum and the IPADH gene from C. beijerinckii did not produce IPA during i...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26390
更新日期:2017-12-01 00:00:00
abstract::The sensitivity of a conceptual model of a foam emulsion bioreactor (FEBR) used for the control of toluene vapors in air was examined. Model parametric sensitivity studies showed which parameters affect the removal of toluene (as model pollutant) in the FEBR the most significantly, and enabled definition of the limits...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22122
更新日期:2009-02-15 00:00:00
abstract::Effective and efficient breakdown of lignocellulosic biomass remains a primary barrier for its use as a feedstock for renewable transportation fuels. A more detailed understanding of the material properties of biomass slurries during conversion is needed to design cost-effective conversion processes. A series of enzym...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22381
更新日期:2009-10-01 00:00:00
abstract::A comparative study of antimicrobial activity is done using three different electrospun nanofibers namely-CA, PAN, and PVC used as control and with various amounts of AgNO(3) being treated with UV-irradiation leading to the enhancement of silver nanoparticles. DMF is used as the common solvent which helps to undergo s...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21351
更新日期:2007-08-15 00:00:00
abstract::The photosynthetic performance of a helical tubular photobioreactor ("Biocoil"), incorporating the filamentous cyanobacterium Spirulina platensis, was investigated. The photobioreactor was constructed in a cylindrical shape (0.9 m high) with a 0.25-m(2)basal area and a photostage comprising 60 m of transparent PVC tub...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260470218
更新日期:1995-07-20 00:00:00
abstract::This paper describes construction of a nanosensory device for amplified detection of biologically important amines as chemical signals. The device was inspired by a biological signal transduction system, and was fabricated on an artificial cell membrane through self-organization of the molecular components, such as a ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22521
更新日期:2010-01-01 00:00:00
abstract::A mathematical model of glycolysis in Saccharomyces cerevisiae is presented. The model is based on rate equations for the individual reactions and aims to predict changes in the levels of intra- and extracellular metabolites after a glucose pulse, as described in part I of this study. Kinetic analysis focuses on a tim...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19970820)55:4<592::AID-BIT
更新日期:1997-08-20 00:00:00
abstract::The reporter bacterium, Pseudomonas fluorescens HK44 (HK44), was characterized in an immobilized state to investigate utility for deployment as a remote sensor in the subsurface. A packed-bed reactor with alginate-immobilized HK44 simulated hydrodynamic conditions such as might be found in a subsurface environment. Th...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19970605)54:5<491::AID-BIT
更新日期:1997-06-05 00:00:00
abstract::The kinetics of the cellulase-catalyzed conversion of soluble cellulose into glucose have been studied over a range of substrate concentrations and temperatures, and at pH values ranging from 4.75 to 7.0. Lineweaver-Burk plots were linear and led to V = 6.2muM/s and K(m) = 13.1 mM at pH 5.8 and 25.0 degrees C. The pK ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260251011
更新日期:1983-10-01 00:00:00
abstract::An integrated solvent (ABE) fermentation and product removal process was investigated. A stable solvent productivity of 3.5 g/L h was achieved by using cells of Clostridium acetobutylicum immobilized onto a packed bed of bonechar, coupled with continuous product removal by pervaporation. Using a concentrated feed solu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260380510
更新日期:1991-08-20 00:00:00
abstract::The glycosylation patterns of recombinant therapeutic glycoproteins can be engineered by overexpression of glycosyltransferases in the host cells used for glycoprotein production. Most prior glycosylation engineering experiments have involved constitutive expression of cloned glycosyltransferases. Here we use tetracyc...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:
更新日期:1999-12-05 00:00:00
abstract::Rhodococcus rhodochrous IGTS8 was previously isolated because of its ability to use coal as its sole source of sulfur for growth. Subsequent growth studies have revealed that IGTS8 is capable of using a variety of organosulfur compounds as sources of sulfur but not carbon. In this article, the ability of IGTS8 to sele...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260400915
更新日期:1992-11-01 00:00:00