Metabolic engineering of isopropyl alcohol-producing Escherichia coli strains with 13 C-metabolic flux analysis.

Abstract:

:Metabolic engineering of isopropyl alcohol (IPA)-producing Escherichia coli strains was conducted along with 13 C-metabolic flux analysis (MFA). A metabolically engineered E. coli strain expressing the adc gene derived from Clostridium acetobutylicum and the IPADH gene from C. beijerinckii did not produce IPA during its exponential growth phase in the aerobic batch culture. 13 C-MFA was carried out, and revealed a deficiency in NADPH regeneration for IPA production in growth phase. Based on these findings, we used nitrogen-starved culture conditions to reduce NADPH consumption for biomass synthesis. As a result, IPA yield was increased to 20% mol/mol glucose. 13 C-MFA revealed that the relative flux levels through the oxidative pentose phosphate (PP) pathway and the TCA cycle were elevated in nitrogen-starved condition relative to glucose uptake rate. To prevent CO2 release in the 6-phosphogluconate dehydrogenase (6PGDH) reaction, metabolism of this E. coli strain was further engineered to redirect glycolytic flux to the glucose 6-phosphate dehydrogenase (G6PDH) and Entner-Doudoroff (ED) pathway. IPA yield of 55% mol/mol glucose was achieved by combining the nitrogen-starved culture condition with the metabolic redirection. The 13 C-MFA data and intracellular NADPH levels obtained under these IPA production conditions revealed linear correlations between the specific IPA production rate and NADPH concentration, as well as between IPA yield and the pyruvate dehydrogenase (PDH) flux. Our results showed that 13 C-MFA is a helpful tool for metabolic engineering studies, and that further improvement in IPA production by E. coli may be achieved by fine-tuning the cofactor ratio and concentrations, as well as optimizing the metabolic pathways and culture conditions.

journal_name

Biotechnol Bioeng

authors

Okahashi N,Matsuda F,Yoshikawa K,Shirai T,Matsumoto Y,Wada M,Shimizu H

doi

10.1002/bit.26390

subject

Has Abstract

pub_date

2017-12-01 00:00:00

pages

2782-2793

issue

12

eissn

0006-3592

issn

1097-0290

journal_volume

114

pub_type

杂志文章
  • Impact of cell culture media additives on IgG glycosylation produced in Chinese hamster ovary cells.

    abstract::Glycosylation is a key critical quality attribute for monoclonal antibodies and other recombinant proteins because of its impact on effector mechanisms and half-life. In this study, a variety of compounds were evaluated for their ability to modulate glycosylation profiles of recombinant monoclonal antibodies produced ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.26904

    authors: Ehret J,Zimmermann M,Eichhorn T,Zimmer A

    更新日期:2019-04-01 00:00:00

  • Coping with inadvertent lysis of Escherichia coli cultures: Strains resistant to lysogeny and infection by the stealthy lysogenic phage Φ80.

    abstract::Phage Φ80 can infect Escherichia coli in a stealthy manner and persist by forming lysogens. Such Φ80 lysogens are fairly common and often go undetected unless the host is grown at temperatures below 37°C. Since low growth temperatures are required for growing temperature-sensitive mutants and often preferred for large...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.26971

    authors: Srinivas S,Cronan JE

    更新日期:2019-07-01 00:00:00

  • Engineering CHO cells to overexpress a secreted reporter protein upon induction from mouse mammary tumor virus promoter.

    abstract::The mouse mammary tumor virus (MMTV) promoter is induced by the addition of a glucocorticoid hormone or analog such as dexamethasone. The hormone binds to its specific transcription factor, glucocorticoid receptor (GR), and the activated complex then binds to the glucocorticoid response elements (GREs) in the enhancer...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:

    authors: James RI,Elton JP,Todd P,Kompala DS

    更新日期:2000-01-20 00:00:00

  • Photosynthetic performance of a helical tubular photobioreactor incorporating the cyanobacterium spirulina platensis.

    abstract::The photosynthetic performance of a helical tubular photobioreactor ("Biocoil"), incorporating the filamentous cyanobacterium Spirulina platensis, was investigated. The photobioreactor was constructed in a cylindrical shape (0.9 m high) with a 0.25-m(2)basal area and a photostage comprising 60 m of transparent PVC tub...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260470218

    authors: Watanabe Y,de la Noüe J,Hall DO

    更新日期:1995-07-20 00:00:00

  • Fluorescent detection of cyanobacterial DNA using bacterial magnetic particles on a MAG-microarray.

    abstract::Bacterial magnetic particles (BMPs) were used for the identification of cyanobacterial DNA. Genus-specific oligonucleotide probes for the detection of Anabaena spp., Microcystis spp., Nostoc spp., Oscillatoria spp., and Synechococcus spp. were designed from the variable region of the cyanobacterial 16S rDNA of 148 str...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.1073

    authors: Matsunaga T,Nakayama H,Okochi M,Takeyama H

    更新日期:2001-06-05 00:00:00

  • Enzymatic coupling of phenol vapors onto chitosan.

    abstract::Phenols are important industrial chemicals, and because they can be volatile, also appear as air pollutants. We examined the potential of tyrosinase to react with the volatile phenol p-cresol. Three lines of evidence support the conclusion that volatile phenols react with tyrosinase and are coupled (i.e., chemisorbed)...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10099

    authors: Wu LQ,Chen T,Wallace KK,Vazquez-Duhalt R,Payne GF

    更新日期:2001-12-01 00:00:00

  • Improved performance with multiple fermentors for repeated batch cultivation for non-growth-associated products.

    abstract::Based on batch cultivation data for the production of L-glutamic acid from glucose, a comparative evaluation was made for repeated batch cultivations using one and more fermentors. The problem was formulated as maximizing the productivity of metabolic product with the specified conversion with respect to the cell age ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260270524

    authors: Shimizu K,Kobayashi T,Nagara A,Matsubara M

    更新日期:1985-05-01 00:00:00

  • Alginate microparticles as novel carrier for oral insulin delivery.

    abstract::Alginate microparticles produced by emulsification/internal gelation were investigated as a promising carrier for insulin delivery. The procedure involves the dispersion of alginate solution containing insulin protein, into a water immiscible phase. Gelation is triggered in situ by instantaneous release of ionic calci...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.21164

    authors: Reis CP,Ribeiro AJ,Neufeld RJ,Veiga F

    更新日期:2007-04-01 00:00:00

  • Hollow fiber bioartificial liver utilizing collagen-entrapped porcine hepatocyte spheroids.

    abstract::A xenogeneic hollow fiber bioreactor utilizing collagen-entrapped dispersed hepatocytes has been developed as an extracorporeal bioartificial liver (BAL) for potential treatment of acute human fulminant hepatitis. Prolonged viability, enhanced liver-specific functions, and differentiated state have been observed in pr...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(SICI)1097-0290(19961005)52:1<34::AID-BIT4

    authors: Wu FJ,Friend JR,Lazar A,Mann HJ,Remmel RP,Cerra FB,Hu WS

    更新日期:1996-10-05 00:00:00

  • Metabolic engineering of Pichia pastoris for malic acid production from methanol.

    abstract::The application of rational design in reallocating metabolic flux to accumulate desired chemicals is always restricted by the native regulatory network. In this study, recombinant Pichia pastoris was constructed for malic acid production from sole methanol through rational redistribution of metabolic flux. Different m...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.27575

    authors: Guo F,Dai Z,Peng W,Zhang S,Zhou J,Ma J,Dong W,Xin F,Zhang W,Jiang M

    更新日期:2021-01-01 00:00:00

  • Biomass/adsorbent electrostatic interactions in expanded bed adsorption: a zeta potential study.

    abstract::Expanded bed adsorption is an integrated technology that allows the introduction of particle-containing feedstock without the risk of blocking the bed. The biomass particles contained in the feedstock have to be treated as an integral part of the process and potential interactions between suspended biomass and the ads...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10654

    authors: Lin DQ,Brixius PJ,Hubbuch JJ,Thömmes J,Kula MR

    更新日期:2003-07-20 00:00:00

  • Performance and microbial analysis of defined and non-defined inocula for the removal of dimethyl sulfide in a biotrickling filter.

    abstract::The performance and microbial communities of three differently inoculated biotrickling filters removing dimethyl sulfide (DMS) were compared. The biotrickling filters were inoculated with Thiobacillus thioparus TK-m (THIO), sludge (HANDS) and sludge + T. thioparus TK-m + Hyphomicrobium VS (HANDS++), respectively. The ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.21059

    authors: Sercu B,Boon N,Beken SV,Verstraete W,Van Langenhove H

    更新日期:2007-03-01 00:00:00

  • Multivariable control of alcohol concentrations in the production of polyhydroxyalkanoates (PHAs) by Paracoccus denitrificans.

    abstract::A novel multivariable control strategy is developed for alcohol (ethanol and n-pentanol) concentrations in the production of poly(3-hydroxybutyrate-co-3-hydroxyvalerate), P(HB-co-HV), a biodegradable polymer by Paracoccus denitrificans ATCC 1774. This controller, which is developed to control the mole fraction of P(HB...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.1101

    authors: Chanprateep S,Abe N,Shimizu H,Yamane T,Shioya S

    更新日期:2001-07-20 00:00:00

  • A process for microbial hydrocarbon synthesis: Overproduction of fatty acids in Escherichia coli and catalytic conversion to alkanes.

    abstract::The development of renewable alternatives to diesel and jet fuels is highly desirable for the heavy transportation sector, and would offer benefits over the production and use of short-chain alcohols for personal transportation. Here, we report the development of a metabolically engineered strain of Escherichia coli t...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.22660

    authors: Lennen RM,Braden DJ,West RA,Dumesic JA,Pfleger BF

    更新日期:2010-06-01 00:00:00

  • High-level heterologous production of propionate in engineered Escherichia coli.

    abstract::A propanologenic (i.e., 1-propanol-producing) bacterium Escherichia coli strain was previously derived by activating the genomic sleeping beauty mutase (Sbm) operon. The activated Sbm pathway branches out of the tricarboxylic acid (TCA) cycle at the succinyl-CoA node to form propionyl-CoA and its derived metabolites o...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.27276

    authors: Miscevic D,Mao JY,Moo-Young M,Chou CP

    更新日期:2020-05-01 00:00:00

  • Correlations for the partition behavior of proteins in aqueous two-phase systems: effect of overall protein concentration.

    abstract::The effect of protein concentration in partitioning in PEG/salt aqueous two-phase systems has been investigated. PEG 4000/phosphate systems in the presence of 0% w/w and 8.8% w/w NaCl have been evaluated using amyloglucosidase, subtilisin, and trypsin inhibitor. Also, a PEG 4000/phosphate system with 3% w/w NaCl was u...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(SICI)1097-0290(19960620)50:6<617::AID-BIT

    authors: Schmidt AS,Andrews BA,Asenjo JA

    更新日期:1996-06-20 00:00:00

  • Mechanistic modeling of enzymatic hydrolysis of cellulose integrating substrate morphology and cocktail composition.

    abstract::A mechanistic model of enzymatic hydrolysis taking into account the morphology of the cellulosic particles and its evolution with time was developed. The individual behavior of the main enzymes involved in the reaction (cellobiohydrolases, endoglucanases, and β-glucosidases), as well as synergy effects, were also incl...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.25873

    authors: Huron M,Hudebine D,Lopes Ferreira N,Lachenal D

    更新日期:2016-05-01 00:00:00

  • Plasmid DNA production for pharmaceutical use: role of specific growth rate and impact on process design.

    abstract::Application of plasmid DNA as pharmaceutical to be used in gene therapy and vaccination has been investigated intensively in recent years. To be able to provide sufficient material that is in accordance with quality of pharmaceutical grade it is mandatory to gain comprehensive process knowledge which is even requested...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.23138

    authors: Bohle K,Ross A

    更新日期:2011-09-01 00:00:00

  • Oxygen transfer in animal cell culture medium.

    abstract::Both k(L)a and k(L) measurements were carried out by an unsteady state technique at impeller speeds ranging from 1.6 to 5.8 s(-1) in a mechanically agitated animal cell culture vessel of working volume 1.5 L. Checks were made that the time constant of the oxygen electrode was negligible compared to the time for aerati...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260300307

    authors: Lavery M,Nienow AW

    更新日期:1987-08-20 00:00:00

  • Increased metal tolerance and bioaccumulation of zinc and cadmium in Chlamydomonas reinhardtii expressing a AtHMA4 C-terminal domain protein.

    abstract::The use of microalgal biomass for metal pollutant bioremediation might be improved by genetic engineering to modify the selectivity or capacity of metal biosorption. A plant cadmium (Cd) and zinc (Zn) transporter (AtHMA4) was used as a transgene to increase the ability of Chlamydomonas reinhardtii to tolerate 0.2 mM C...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.27476

    authors: Ibuot A,Webster RE,Williams LE,Pittman JK

    更新日期:2020-10-01 00:00:00

  • Identification of key residues modulating the stereoselectivity of nitrile hydratase toward rac-mandelonitrile by semi-rational engineering.

    abstract::Optically pure compounds are important in the synthesis of fine chemicals. Using directed evolution of enzymes to obtain biocatalysts that can selectively produce high-value chiral chemicals is often time-, money-, and resource-intensive; traditional semi-rational designs based on structural data and docking experimen...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.26484

    authors: Cheng Z,Peplowski L,Cui W,Xia Y,Liu Z,Zhang J,Kobayashi M,Zhou Z

    更新日期:2018-03-01 00:00:00

  • Efficient production of poly γ-d-glutamic acid from the bloom-forming green macroalgae, Ulva sp., by Bacillus sp. SJ-10.

    abstract::Numerous studies on poly γ-d-glutamicacid (γ-PGA) production have investigated terrestrial renewable sources for reducing production costs, but there are no studies using waste marine resources so far. We aimed to develop a cost-effective production method of γ-d-PGA by Bacillus sp. SJ-10 using green macroalgae (Ulva ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.26966

    authors: Kim JH,Lee JM,Jang WJ,Park HD,Kim YO,Kim CH,Kong IS

    更新日期:2019-07-01 00:00:00

  • A study of D-lactate and extracellular methylglyoxal production in lactate re-utilizing CHO cultures.

    abstract::In large-scale mammalian cell culture, the key toxic by-products assessed and monitored are lactate and ammonia. Often no distinction between the two isoforms of lactate is made. Here, we present profiles of both D- and L-lactate. D-Lactate is the end molecule of the methylglyoxal pathway. D-Lactate unlike L-lactate i...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.22757

    authors: Paoli T,Faulkner J,O'kennedy R,Keshavarz-Moore E

    更新日期:2010-09-01 00:00:00

  • A microfluidic system for investigation of extravascular transport and cellular uptake of drugs in tumors.

    abstract::Three-dimensional (3D) tumor models have been established in various microfluidic systems for drug delivery and resistance studies in vitro. However, one of the main drawbacks of these models is non-uniform distribution of cells, leaving regions with very low cell density within the 3D structures. As a result, molecul...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.24397

    authors: Elliott NT,Yuan F

    更新日期:2012-05-01 00:00:00

  • Immobilization of thermolysin to polyamide nonwoven materials.

    abstract::In the last few years, an increasing number of biotechnological techniques have been applied to the restoration and conservation of works of art, paintings, old maps, and papers or books. Enzymes can solve problems that give restorers difficulties, although for many applications it is not possible to use soluble enzym...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10565

    authors: Moeschel K,Nouaimi M,Steinbrenner C,Bisswanger H

    更新日期:2003-04-20 00:00:00

  • Optimization of recombinant protein expression level in Escherichia coli by flow cytometry and cell sorting.

    abstract::Overexpression of recombinant proteins in Escherichia coli often leads to a severe growth retardation of the host cells. The phage T7 promoter phi10 in a pET vector was utilized to express human superoxide dismutase. Induction with IPTG lead to an increase in protein content and cell size and a termination of cell div...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10353

    authors: Soriano E,Borth N,Katinger H,Mattanovich D

    更新日期:2002-10-05 00:00:00

  • Enzymatic protein switches built from paralogous input domains.

    abstract::Protein switches have a variety of potential applications in biotechnology and medicine that motivate efforts to accelerate their development. Switches can be built by the proper fusion of two proteins with the prerequisite input and output functions. However, the exact fusion geometry for switch creation, which typic...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.25852

    authors: Tullman J,Nicholes N,Dumont MR,Ribeiro LF,Ostermeier M

    更新日期:2016-04-01 00:00:00

  • Increased heterologous protein production by Saccharomyces cerevisiae growing on ethanol as sole carbon source.

    abstract::Saccharomyces cerevisiae is a widely used host organism for the production of heterologous proteins, often cultivated in glucose-based fed-batch processes. This production system however has many factors limiting the productivity, mainly towards the end of the fermentation. For the optimised production of a Camelid an...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.21150

    authors: van de Laar T,Visser C,Holster M,López CG,Kreuning D,Sierkstra L,Lindner N,Verrips T

    更新日期:2007-02-15 00:00:00

  • Fractional factorial design to investigate stromal cell regulation of macrophage plasticity.

    abstract::Understanding the regulatory networks which control specific macrophage phenotypes is essential in identifying novel targets to correct macrophage mediated clinical disorders, often accompanied by inflammatory events. Since mesenchymal stromal cells (MSCs) have been shown to play key roles in regulating immune functio...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.25282

    authors: Barminko JA,Nativ NI,Schloss R,Yarmush ML

    更新日期:2014-11-01 00:00:00

  • Prediction of the profiles of the elution bands of proteins in preparative liquid chromatography.

    abstract::A semiequilibrium model of chromatography has been developed to account for the elution profile of high concentration bands. The use of this model requires the prior determination of the equilibrium isotherms of the studied compounds in the chromatographic phase system. The model is applied here to a study of the isoc...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260360311

    authors: Katti A,Huang JX,Guiochon G

    更新日期:1990-07-01 00:00:00