An actively mixed mini-bioreactor for protein production from suspended animal cells.

Abstract:

:Biopharmaceutical production would benefit from rapid methods to optimize production of therapeutic proteins by screening host cell line/vector combination, culture media, and operational parameters such as timing of induction. Miniaturized bioreactors are an emerging research area aiming at improving the development speed. In this work, a 3 mm thick mini-bioreactor including two 12 mm wide culture chambers connected by a 5 mm wide channel is described. Active mixing is achieved by pressure shuttling between the two chambers. Gas-liquid phase exchange for oxygen and carbon dioxide is realized by molecular diffusion through 50 microm thick polymethylpentene membranes. With this unique design, a velocity difference between the middle area and the side areas at the interfaces of the culture chambers and the connecting channel is created, which enhances the mixing efficiency. The observed mixing time is on the order of 100 s. The combination of high permeability toward oxygen of polymethylpentene membranes and fluid movement during active pressure shuttling enables higher volumetric oxygen transfer coefficients, 5.7 +/- 0.4-14.8 +/- 0.6 h(-1), to be obtained in the mini-bioreactors than the values found in traditional 50 mL spinner flasks, 2.0-2.5 h(-1). Meanwhile, the calculated volume averaged shear stress, in the range of 10(-2)-10(-1) N/m(2), is within the typical tolerable range of animal cells. To demonstrate the applicability of this mini-bioreactor to culture suspended animal cells, the insect cell, Spodoptera frugiperda, is cultured in mini-bioreactors operated under a K(L)a value of 14.8 +/- 0.6 h(-1) and compared to the same cells cultured in 50 mL spinner flasks operated under a K(L)a value of 2.2 h(-1). Sf-21 cells cultured in the mini-bioreactors present comparable length of lag phases and growth rates to their counterparts cultured in 50 mL spinner flasks, but achieve a higher maximum cell density of 5.3 +/- 0.9 x 10(6) cell/mL than the value of 3.4 +/- 0.4 x 10(6) cell/mL obtained by cells cultured in 50 mL spinner flasks. Sf-21 cells infected with SEAP-baculovirus produce a maximum SEAP concentration of 11.3 +/- 0.7 U/mL when cultured in the mini-bioreactor. In contrast, infected Sf-21 cells cultured in 50 mL spinner flasks produce a maximum SEAP concentration of 7.4 +/- 0.9 U/mL and onset of production is delayed from 18 h in minibioreactor to 40 h in spinner flasks.

journal_name

Biotechnol Bioeng

authors

Diao J,Young L,Zhou P,Shuler ML

doi

10.1002/bit.21751

subject

Has Abstract

pub_date

2008-05-01 00:00:00

pages

72-81

issue

1

eissn

0006-3592

issn

1097-0290

journal_volume

100

pub_type

杂志文章
  • Determination of kinetic parameters of fermentation processes by a continuous unsteady-state method: application to the alcoholic fermentation of D-xylose by Pichia stipitis.

    abstract::A quick technique for determination of kinetic parameters of fermentation processes is proposed and applied to the transformation of D-xylose into ethanol by Pichia stipitis. The commonly used method to evaluate these parameters is based on achieving several steady states. In the proposed procedure, micro(m) and K(s) ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260411117

    authors: Domínguez H,Núñez MN,Chamy R,Lema JM

    更新日期:1993-05-01 00:00:00

  • Application of an electric DNA-chip for the expression analysis of bioprocess-relevant marker genes of Bacillus subtilis.

    abstract::The knowledge of critical process-relevant genes can be used for an improved control of bioprocesses. So far bioprocess-relevant marker genes can be analyzed by established expression analysis methods only off-line. In this study, an alternative approach for a potential at-line monitoring of gene expression during bio...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.20578

    authors: Jürgen B,Barken KB,Tobisch S,Pioch D,Wümpelmann M,Hecker M,Schweder T

    更新日期:2005-11-05 00:00:00

  • Effect of matrices on affinity purification of protein C.

    abstract::One of the critical problems in scale-up of affinity chromatography is the mechanical strength of the support matrix against pressure. Because the costs of both the gel matrix and the ligand for the affinity chromatography are very high, the reusability of gel matrices is directly related to the total production cost....

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260391104

    authors: Kang K,Ryu D,Drohan WN,Orthner CL

    更新日期:1992-05-01 00:00:00

  • Cellulase production from immobilized growing cell composites prepared by radiation polymerization.

    abstract::The cellulase production from immobilized Trichoderma reesei composites prepared by radiation polymerization at low temperature was studied. The production of cellulase from the cells irradiated by radiation was slightly retarded at the initial stage of the culture, but was immediately recovered. The production of cel...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260260105

    authors: Kumakura M,Kaetsu I,Nisizawa K

    更新日期:1984-01-01 00:00:00

  • A new bioproduction route for a novel antimicrobial peptide.

    abstract::Beta defensins are antimicrobial peptides (AMPs) with a broad spectrum antimicrobial behavior against pathogens while having minimal tendency to incur pathogen resistance. Human β-defensin 28 (hBD28) is a strongly cationic AMP and hence hypothesized to be highly effective in permeabilizing negatively-charged pathogen ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.22970

    authors: Tay DK,Rajagopalan G,Li X,Chen Y,Lua LH,Leong SS

    更新日期:2011-03-01 00:00:00

  • Development of a robust nitrilase by fragment swapping and semi-rational design for efficient biosynthesis of pregabalin precursor.

    abstract::Protein engineering is a powerful tool for improving the properties of enzymes. However, large changes in enzyme properties are still challenging for traditional evolution strategies because they usually require multiple amino acid substitutions. In this study, a feasible evolution approach by a combination of fragmen...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.27203

    authors: Zhang Q,Lu XF,Zhang Y,Tang XL,Zheng RC,Zheng YG

    更新日期:2020-02-01 00:00:00

  • Periodic operation of a continuous culture of Baker's yeast.

    abstract::The possibility of enhancing the biomass productivity of a continuous culture of Saccharomyces cerevisiae growing on a glucose-limited medium is addressed. An unstructured Monod-type model is first identified using steady-state data. The culture is subjected to step changes in dilution rate, and it is seen that the Mo...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260340603

    authors: Abulesz EM,Lyberatos G

    更新日期:1989-09-01 00:00:00

  • Cellulase immobilization on Fe3O4 and characterization.

    abstract::A successful procedure for attaching cellulase to 45 microm iron oxide particles with a high-molecular-weight (1000) ligand has been developed. Mass and activity balances were calculated for immobilized enzymes with different loadings. The highest specific activity of the immobilized enzyme was 5.9 mmol glucose/g boun...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260330311

    authors: Garcia A 3rd,Oh S,Engler CR

    更新日期:1989-01-15 00:00:00

  • Production of Bacillus thuringiensis spores in total cell retention culture and two-stage continuous culture using an internal ceramic filter system.

    abstract::The production of Bacillus thuringiensis spores was investigated in a bioreactor incorporating a ceramic membrane filter to improve spore concentration and volumetric productivity. Two cultivation methods were used in this study: a total cell retention culture (TCRC), and a two-stage continuous culture with partial ce...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260420913

    authors: Kang BC,Lee SY,Chang HN

    更新日期:1993-11-05 00:00:00

  • In vitro degradation of natural insoluble lignin in aqueous media by the extracellular peroxidases of Phanerochaete chrysosporium.

    abstract::The lignin peroxidases (LIP) and manganese peroxidases (MNP) of Phanerochaete chrysosporium catalyze a wide range of lignin depolymerization reactions with lignin models and synthetic lignins in solution. However, their ability to degrade insoluble natural lignin in aqueous media has not been demonstrated. Insoluble i...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(sici)1097-0290(19980320)57:6<704::aid-bit

    authors: Thompson DN,Hames BR,Reddy CA,Grethlein HE

    更新日期:1998-03-20 00:00:00

  • Mutant Escherichia coli penicillin acylase with enhanced stability at alkaline pH.

    abstract::Increased stability at alkaline pH should be a valuable attribute for the utilization of penicillin acylase in bioreactors employed to convert penicillins into 6-aminopenicillanic acid, a precursor of semisynthetic penicillins. In these systems, base is added for pH control, which results in local alkaline conditions ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260480208

    authors: Del Río G,Rodríguez ME,Munguía ME,López-Munguí A,Soberón X

    更新日期:1995-10-20 00:00:00

  • Optimization of batch processes involving simultaneous enzymatic and microbial reactions.

    abstract::Two general models for batch simultaneous enzymatic and microbial reaction (SEMR) processes are presented, the second derived from and simpler than the first and accounting for enzyme denaturation. Using the second model and parameter values from the literature, simulation was used to examine a range of enzyme additio...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260371114

    authors: Asenjo JA,Sun WH,Spencer JL

    更新日期:1991-05-01 00:00:00

  • Soluble microbial products (SMP) in anaerobic chemostats.

    abstract::The production of soluble microbial products (SMP) in anaerobic systems was evaluated using chemostat reactors. Results from steady-state and tracer experiments with (14)C-glucose and (14)C-acetate showed that significant amounts of SMP were produced during the acidogenesis of glucose, but that SMP did not accumulate ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260440904

    authors: Noguera DR,Araki N,Rittmann BE

    更新日期:1994-11-05 00:00:00

  • Serial flux mapping of Corynebacterium glutamicum during fed-batch L-lysine production using the sensor reactor approach.

    abstract::Using our recently developed sensor reactor approach, lysine-producing, nongrowing Corynebacterium glutamicum MH20-22B cells were subjected to serial (13)C-labeling experiments for flux analysis during the leucine-limited fed-batch production phase in a 300-L bioreactor. Based on two-dimensional (2D) nuclear magnetic ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10915

    authors: Drysch A,El Massaoudi M,Wiechert W,de Graaf AA,Takors R

    更新日期:2004-03-05 00:00:00

  • Immobilization of yeast cells containing beta-galactosidase.

    abstract::Cultural conditions optimum for beta-galactosidase production by Saccharomyces anamensis are pH 4.5, temperature 26 +/- 2 degrees C, and 30 h of incubation period. Addition of lactose at 24 h fermentation greatly increase the level of enzyme. Optimum pHl, temperature, pH stability, and thermostability of yeast beta-ga...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260240810

    authors: Banerjee M,Chakrabarty A,Majumdar SK

    更新日期:1982-08-01 00:00:00

  • Trichloroethene and cis-1,2-dichloroethene concentration-dependent toxicity model simulates anaerobic dechlorination at high concentrations. II: continuous flow and attached growth reactors.

    abstract::A model that was used to describe toxicity from high concentrations of chlorinated aliphatic hydrocarbons (CAHs) on reductively dechlorinating cultures in batch reactors (Sabalowsky and Semprini (in press)) was extended here to simulate observations in continuous flow suspended and attached growth reactors. The reduct...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.22822

    authors: Sabalowsky AR,Semprini L

    更新日期:2010-10-15 00:00:00

  • Resting cells of recombinant E. coli show high epoxidation yields on energy source and high sensitivity to product inhibition.

    abstract::Metabolically active resting (i.e., nongrowing) bacterial cells have a high potential in cofactor-dependent redox biotransformations. Where growing cells require carbon and energy for biomass production, resting cells can potentially exploit their metabolism more efficiently for redox biocatalysis allowing higher spec...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.24404

    authors: Julsing MK,Kuhn D,Schmid A,Bühler B

    更新日期:2012-05-01 00:00:00

  • Fractional precipitation of plasmid DNA from lysate by CTAB.

    abstract::Preparative-scale purification of plasmid DNA has been attempted by diverse methods, including precipitation with solvents, salts, and detergents and chromatography with ion-exchange, reversed-phase, and size-exclusion columns. Chromatographic methods such as hydrophobic interaction chromatography (HIC), reversed phas...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10335

    authors: Lander RJ,Winters MA,Meacle FJ,Buckland BC,Lee AL

    更新日期:2002-09-30 00:00:00

  • Adsorption of BSA on strongly basic chitosan: Equilibria.

    abstract::Equilibrium isotherms for adsorption of bovine serum albumin (BSA) on a new adsorbent, a strongly basic crosslinked chitosan (Chitopearl 2503), which is hard and is not compressed by pressure in a column, have been presented and compared with diethylaminoethyl (DEAE) Sepharose Fast Flow (hard gel). In Chitopearl 2503,...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260431112

    authors: Yoshida H,Nishihara H,Kataoka T

    更新日期:1994-05-01 00:00:00

  • Atypical kinetics of immobilized firefly luciferase.

    abstract::The kinetic properties of collagen-bound firefly luciferase have been investigated. Under definite hydrodynamic conditions with low agitation in the reaction medium, the observed behavior is modified compared to the enzyme free in solution: reducing the stirring rate decreases the observed enzymatic activity. But diff...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260280804

    authors: Blum LJ,Coulet PR

    更新日期:1986-08-01 00:00:00

  • Evaluation of heart tissue viability under redox-magnetohydrodynamics conditions: toward fine-tuning flow in biological microfluidics applications.

    abstract::A microfluidic system containing a chamber for heart tissue biopsies, perfused with Krebs-Henseleit buffer containing glucose and antibiotic (KHGB) using peristaltic pumps and continuously stimulated, was used to evaluate tissue viability under redox-magnetohydrodynamics (redox-MHD) conditions. Redox-MHD possesses uni...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.24426

    authors: Cheah LT,Fritsch I,Haswell SJ,Greenman J

    更新日期:2012-07-01 00:00:00

  • Maintaining rapid growth in moderate-density Escherichia coli fermentations.

    abstract::A novel feeding strategy that prolongs rapid growth rates for Escherichia coli fermentations to moderately high cell density is presented. High-density fermentations are a common and successful means of producing biological products. However, acetate accumulation can be a substantial problem in these procedures. To av...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.20369

    authors: Zawada J,Swartz J

    更新日期:2005-02-20 00:00:00

  • Prediction of the profiles of the elution bands of proteins in preparative liquid chromatography.

    abstract::A semiequilibrium model of chromatography has been developed to account for the elution profile of high concentration bands. The use of this model requires the prior determination of the equilibrium isotherms of the studied compounds in the chromatographic phase system. The model is applied here to a study of the isoc...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260360311

    authors: Katti A,Huang JX,Guiochon G

    更新日期:1990-07-01 00:00:00

  • Microfluorimetric analysis of spatial and temporal patterns of immobilized cell growth.

    abstract::Pronounced spatial nonuniformities in cell density, physiology, and activity frequently arise within densely packed immobilized cell supports. For a more fundamental understanding of immobilized cell phenomena, we have developed high-resolution microfluorimetric procedures to analyze local variations in both immobiliz...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260380404

    authors: Kuhn RH,Peretti SW,Ollis DF

    更新日期:1991-08-05 00:00:00

  • Comment on mathematical models which describe transcription and calculate the relationship between mRNA and protein expression ratio.

    abstract::Mathematical models to describe transcription (Arnold et al. (2001); Biotech Bioeng 72:548-561) and translation (Mehra et al. (2003); Biotech Bioeng 84:822-841) in bacteria are modified in order to improve reaction kinetics and to include the number of polymerase molecules that are active on the DNA, as well as to inc...

    journal_title:Biotechnology and bioengineering

    pub_type: 评论,信件

    doi:10.1002/bit.21065

    authors: Kremling A

    更新日期:2007-03-01 00:00:00

  • Enhancing ligand-protein binding in affinity thermoprecipitation: elucidation of spacer effects

    abstract::Copolymers of N-isopropylacrylamide and N-acryloyl amino acid spacers of varying chain length were synthesized. p-Aminobenzamidine (PABA) was chemically linked to the pendant carboxyl groups of these polymers to obtain thermoprecipitating affinity polymers. The inhibition constant (Ki) of these polymers for trypsin de...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(sici)1097-0290(19990820)64:4<418::aid-bit

    authors: Vaidya AA,Lele BS,Kulkarni MG,Mashelkar RA

    更新日期:1999-08-20 00:00:00

  • Kinetic effects of simultaneous inhibition by substrate and product.

    abstract::The starting point for the present investigations was the finding that increasing influent concentrations from 10 to 380 mmol/L glucose decreased the attainable growth rate of an acidogenic population in continuous culture from 0.52 to 0.05 h(-1) To account for this phenomenon, a new kinetic model is developed that co...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260310714

    authors: Van Den Heuvel JC,Beeftink HH

    更新日期:1988-05-01 00:00:00

  • Transient production of recombinant proteins by Chinese hamster ovary cells using polyethyleneimine/DNA complexes in combination with microtubule disrupting anti-mitotic agents.

    abstract::We have developed a simple and robust transient expression system utilizing the 25 kDa branched cationic polymer polyethylenimine (PEI) as a vehicle to deliver plasmid DNA into suspension-adapted Chinese hamster ovary cells synchronized in G2/M phase of the cell cycle by anti-mitotic microtubule disrupting agents. The...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.20265

    authors: Tait AS,Brown CJ,Galbraith DJ,Hines MJ,Hoare M,Birch JR,James DC

    更新日期:2004-12-20 00:00:00

  • Comparative metabolic profiling revealed limitations in xylose-fermenting yeast during co-fermentation of glucose and xylose in the presence of inhibitors.

    abstract::During lignocellulosic ethanol fermentation, yeasts are exposed to various lignocellulose-derived inhibitors, which disrupt the efficiency of hexose and pentose co-fermentation. To understand the metabolic response of fermentation microbes to these inhibitors, a comparative metabolomic investigation was performed on a...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.24992

    authors: Wang X,Jin M,Balan V,Jones AD,Li X,Li BZ,Dale BE,Yuan YJ

    更新日期:2014-01-01 00:00:00

  • New reaction system for hydrocarbon oxidation by chloroperoxidase.

    abstract::A novel reaction system was developed to maximize the catalytic efficiency of chloroperoxidase (CPO, from Caldariomyces fumago) toward the oxidation of hydrocarbons. The reaction system consisted of an organic/aqueous emulsion comprising pure substrate and aqueous buffer supplemented with the surfactant dioctyl sulfos...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.20769

    authors: Park JB,Clark DS

    更新日期:2006-05-05 00:00:00