Abstract:
:Using our recently developed sensor reactor approach, lysine-producing, nongrowing Corynebacterium glutamicum MH20-22B cells were subjected to serial (13)C-labeling experiments for flux analysis during the leucine-limited fed-batch production phase in a 300-L bioreactor. Based on two-dimensional (2D) nuclear magnetic resonance (NMR) measurements of (13)C-labeling patterns of cytoplasmic free metabolites, metabolic flux distributions in the central metabolism were successfully determined. Focusing on the highly concentrated metabolite L-glutamate, the working hypothesis was validated that the equilibration of labeling patterns in intracellular pools was much faster (up to 9.45 min) than the labeling period (3 h) used in the experiments. Analysis of anaplerotic reactions revealed that highly selective lysine production was accompanied by a significant reduction of decarboxylating reactions from 10 mol% to only 2 mol%, whereas PEP/pyruvate-carboxylating fluxes remained constant at about 40 mol% of consumed glucose. These results support the conclusion that an optimized C. glutamicum L-lysine producer should possess increased PEP carboxylase and/or pyruvate carboxylase activity combined with downregulated, decarboxylating fluxes consuming oxaloacetate/malate. The findings also illustrate the usefulness of the sensor reactor approach in the study of industrial fermentations.
journal_name
Biotechnol Bioengjournal_title
Biotechnology and bioengineeringauthors
Drysch A,El Massaoudi M,Wiechert W,de Graaf AA,Takors Rdoi
10.1002/bit.10915subject
Has Abstractpub_date
2004-03-05 00:00:00pages
497-505issue
5eissn
0006-3592issn
1097-0290journal_volume
85pub_type
杂志文章abstract::Two kinds of disposable bioreactors, air-lift disposable bioreactors (ADB) and wave disposable bioreactors (WDB) were compared with stirred-tank reactors (5-L STR). These bioreactors were successfully applied to transgenic rice cell cultures for the production of recombinant human cytotoxic T-lymphocyte antigen 4-immu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.24916
更新日期:2013-09-01 00:00:00
abstract::Currently in America the biofuel ethanol is primarily being produced by the dry grind technique to obtain the starch contained in the corn grains and subsequently subjected to fermentation. This so-called 1st generation technology has two setbacks; first the lingering debate whether its life cycle contributes to a red...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21881
更新日期:2008-09-01 00:00:00
abstract::Spinner-flask bioreactors have been used for the production of articular cartilage in vitro. The dynamic environment within bioreactors is known to significantly affect the growth and development of the tissue. The present research focuses on the experimental and numerical characterization of the flow field within a s...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10788
更新日期:2004-01-05 00:00:00
abstract::Glycosylation is a key critical quality attribute for monoclonal antibodies and other recombinant proteins because of its impact on effector mechanisms and half-life. In this study, a variety of compounds were evaluated for their ability to modulate glycosylation profiles of recombinant monoclonal antibodies produced ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26904
更新日期:2019-04-01 00:00:00
abstract::The feasibility of NO3- removal by the synergistic action of a prevailing denitrifying anoxic methane oxidising (DAMO), and nitrate-reducing and sulfide-oxidising bacterial (NR-SOB) consortium, using CH4 and H2 S from biogas as electron donors in a biotrickling filter was investigated. The influence of NO3- concentrat...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26092
更新日期:2017-03-01 00:00:00
abstract::Gluconobacter melanogenus IFO 3293 cells capable of converting L-sorbose to L-sorbosone were immobilized in polyacrylamide gel. The preferred polymer composition for high activity and stability was determined to contain a total monomer concentration of 7.2% and 16.6% crosslinking agent. No significant differences in o...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260180208
更新日期:1976-02-01 00:00:00
abstract::The potential of bacteriophage lambda as an expression vector for a large scale production of cloned-gene proteins was evaluated in batch and continuous bioreactors using a temperature-sensitive mutant in the cl gene, which allows a simple manipulation of temperature as a means to control the phage in the lysogenic or...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260370402
更新日期:1991-02-20 00:00:00
abstract::Preparative-scale purification of plasmid DNA has been attempted by diverse methods, including precipitation with solvents, salts, and detergents and chromatography with ion-exchange, reversed-phase, and size-exclusion columns. Chromatographic methods such as hydrophobic interaction chromatography (HIC), reversed phas...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10335
更新日期:2002-09-30 00:00:00
abstract::We have produced Bioglass coatings for Orthopedic implants by using a novel coating technique, CoBlast. The two resultant surfaces, designated BG and hydroxyapatite (HA)/BG, were compared with their HA counterpart, OsteoZip in terms of osteoblastic cell attachment, adhesion, proliferation, differentiation, and growth ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22955
更新日期:2011-02-01 00:00:00
abstract::Capitalizing on components evolved to metabolize ethanol in Aspergillus nidulans, we previously designed the first molecular gas-gene expression interface using gaseous acetaldehyde as the major inducer. This fungus-derived acetaldehyde-inducible gene regulation (AIR) system operated perfectly and enabled precise and ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20482
更新日期:2005-06-30 00:00:00
abstract::A mutant of Saccharomyces cerevisiae, which forms large, multicellular flocs in liquid culture, rapidly fermented media containing high concentrations of glucose (100-180 g/L) in a continuous nonaerated tower fermentor at 30 degrees C. The fermentor operated continuously for seven months. Batch and tower fermentor dat...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260260717
更新日期:1984-07-01 00:00:00
abstract::The major objectives for preparative protein chromatography are maximal loading and increased flow rate while maintaining defined resolution. Conventionally a series of chromatographic experiments are performed and the optimal conditions are selected according to the separation criteria. Computer-aided process design ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19961020)52:2<223::AID-BIT
更新日期:1996-10-20 00:00:00
abstract::An integrated solvent (ABE) fermentation and product removal process was investigated. A stable solvent productivity of 3.5 g/L h was achieved by using cells of Clostridium acetobutylicum immobilized onto a packed bed of bonechar, coupled with continuous product removal by pervaporation. Using a concentrated feed solu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260380510
更新日期:1991-08-20 00:00:00
abstract::Bioprocesses operated in batch mode can induce adverse effects like overflow metabolism, substrate inhibition, osmotic inhibition, oxygen limitation, and catabolite repression. To avoid these adverse effects, fed-batch is the predominant operation mode in industrial production. Nevertheless, screening for optimal prod...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27077
更新日期:2019-09-01 00:00:00
abstract::Shake flask and stirred tank bioleaching experiments showed that the dissolution of chalcopyrite is inhibited by ferric ion concentrations as low as 200 mg L(-1) and redox potentials >420 mV (vs. Ag/AgCl). Chemical leaching of chalcopyrite (4% suspension, surface area 2.3 m2 g(-1)) was enhanced fourfold in the presenc...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10184
更新日期:2002-05-20 00:00:00
abstract::Catalytic membranes, obtained by immobilizing thermophilic beta-glycosidase onto nylon supports, were used in a nonisothermal bioreactor to study the effect of temperature gradients on the rate of enzyme reaction. Two experimental approaches were carried out to explain the molecular mechanisms by which the temperature...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:
更新日期:1998-07-05 00:00:00
abstract::An option for fertility preservation for women facing a cancer diagnosis involves the cryopreservation of ovarian tissue for later re-transplantation or in vitro culture, with in vitro culture preferred to avoid reintroduction of the cancer. Small, immature follicles survive the freeze-thaw process, and can be matured...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22250
更新日期:2009-06-01 00:00:00
abstract::By feeding ethanol at various high rates to low cell density cultures of Saccharomyces cerevisiae it was shown that the sharp fall in viability when ethanol is produced during rapid fermentations is in part a direct consequence of the high rate of change of extracellular ethanol concentration. Nevertheless, the fall i...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260350202
更新日期:1990-01-20 00:00:00
abstract::The aim of the present study is to demonstrate the use of controlled bioreactors for toxicological studies. As a model system the effect of linoleic acid on hybridoma cells is studied in two well-controlled continuously operated bioreactors placed in series. In the first reactor the effect on rapid proliferating cells...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20897
更新日期:2006-10-20 00:00:00
abstract::The high hydrophobicity of polycyclic aromatic hydrocarbons (PAHs) strongly reduces their bioavailability in aged contaminated soils, thus limiting their bioremediation. The biodegradation of PAHs in soils can be enhanced by employing surface-active agents. However, chemical surfactants are often recalcitrant and exer...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20225
更新日期:2004-10-20 00:00:00
abstract::Esters were prepared by acylation of hydroxypropyl cellulose with fatty acid catalyzed by immobilized lipase from Candida antarctica in tert-butanol. The nature of the substrates used, the initial water activity of the system, and the molecular weight of the hydroxypropyl cellulose were investigated. Moreover, Fourier...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/1097-0290(20010220)72:4<495::aid-bit1012>3
更新日期:2001-02-20 00:00:00
abstract::Numerous high-value proteins are secreted into the Escherichia coli periplasm by the General Secretory (Sec) pathway, but Sec-based production chassis cannot handle many potential target proteins. The Tat pathway offers a promising alternative because it transports fully folded proteins; however, yields have been too ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26434
更新日期:2017-12-01 00:00:00
abstract::This paper describes batch and semicontinuous acetic acid fermentations for wine vinegar production carried out with Acetobacter pasteurianus, and an industrial strain using a noncommercial 100-L bubble column reactor equipped with a novel type of gas-liquid dynamic sparger. Results showed acetification rates with thi...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19990420)63:2<141::aid-bit
更新日期:1999-04-20 00:00:00
abstract::By investigating the effects of four operating variables-volume (V), Ultrafiltration flux (J), enzyme concentration (E), and substrate concentration (S)-on capacity (K) and conversion rate (epsilon) of a hollow fiber CSTR, the performances of the CSTR and the kinetic constants of the reaction were determined. A model ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260310704
更新日期:1988-05-01 00:00:00
abstract::Phosphite dehydrogenase represents a new enzymatic system for regenerating reduced nicotinamide cofactors for industrial biocatalysis. We previously engineered a variant of phosphite dehydrogenase with relaxed cofactor specificity and significantly increased activity and stability. Here we performed one round of rando...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21546
更新日期:2008-02-01 00:00:00
abstract::The utilization and conversion of D-xylose, D-xylulose, L-arabinose, and xylitol by yeast strains have been investigated with the following results: (1) The majority of yeasts tested utilize D-xylose and produce polyols, ethanol, and organic acids. The type and amount of products formed varies with the yeast strains u...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260250108
更新日期:1983-01-01 00:00:00
abstract::The results of an initial study of enzymatic catalysis in metastable supersaturated solutions of carbohydrates are presented. It has been shown that such solutions, formed in the presence of small amounts of water and alcohol as plasticizers, are sufficiently stable under ambient conditions to enable enzymatic transfo...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:
更新日期:1998-10-20 00:00:00
abstract::A kinetic resolution process for the production of chiral amines was developed using an enzyme-membrane reactor (EMR) and a hollow-fiber membrane contactor with (S)-specific omega-transaminases (omega-TA) from Vibrio fluvialis JS17 and Bacillus thuringiensis JS64. The substrate solution containing racemic amine and py...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.1050
更新日期:2001-05-05 00:00:00
abstract::A sucrose utilization pathway was established in Ralstonia eutropha NCIMB11599 and R. eutropha 437-540 by introducing the Mannheimia succiniciproducens MBEL55E sacC gene that encodes β-fructofuranosidase. These engineered strains were examined for the production of poly(3-hydroxybutyrate) [P(3HB)] and poly(3-hydroxybu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.25469
更新日期:2015-03-01 00:00:00
abstract::Miniaturized bioreactors for suspension cultures of animal cells, such as Chinese Hamster Ovary (CHO) cells, could improve bioprocess development through the ability to cheaply explore a wide range of bioprocess operating conditions. A miniaturized pressure-cycled bioreactor for animal cell cultures, described previou...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.23289
更新日期:2012-01-01 00:00:00