Abstract:
:Multiparameter flow cytometric techniques developed in our laboratories have been used for the "at-line" study of fed-batch bacterial fermentations. These fermentations were done at two scales, production (20 m(3)) and bench (5 x 10(-3) m(3)). In addition, at the bench scale, experiments were undertaken where the difficulty of achieving good mixing (broth homogeneity), similar to that found at the production scale, was simulated by using a two-compartment model. Flow cytometric analysis of cells in broth samples, based on a dual-staining protocol, has revealed, for the first time, that a progressive change in cell physiological state generally occurs throughout the course of such fermentations. The technique has demonstrated that a changing microenvironment with respect to substrate concentration (glucose and dissolved oxygen tension [DOT]) has a profound effect on cell physiology and hence on viable biomass yield. The relatively poorly mixed conditions in the large-scale fermentor were found to lead to a low biomass yield, but, surprisingly, were associated with a high cell viability (with respect to cytoplasmic membrane permeability) throughout the fermentation. The small-scale fermentation that most clearly mimicked the large-scale heterogeneity (i.e., a region of high glucose concentration and low DOT analogous to a feed zone) gave similar results. On the other hand, the small-scale well-mixed fermentation gave the highest biomass yield, but again, surprisingly, the lowest cell viability. The scaled-down simulations with high DOT throughout and locally low or high glucose gave biomass and viabilities between. Reasons for these results are examined in terms of environmental stress associated with an ever-increasing glucose limitation in the well-mixed case. On the other hand, at the large scale, and to differing degrees in scale-down simulations, cells periodically encounter regions of relatively higher glucose concentration.
journal_name
Biotechnol Bioengjournal_title
Biotechnology and bioengineeringauthors
Hewitt CJ,Nebe-Von Caron G,Axelsson B,McFarlane CM,Nienow AWsubject
Has Abstractpub_date
2000-11-20 00:00:00pages
381-90issue
4eissn
0006-3592issn
1097-0290pii
10.1002/1097-0290(20001120)70:4<381::AID-BIT3>3.0.journal_volume
70pub_type
杂志文章abstract::A new biomass productivity model was parameterized for Chlorella vulgaris using short-term (<30 min) oxygen productivities from algal microcosms exposed to 6 light intensities (20-420 W/m(2)) and 6 temperatures (5-42 °C). The model was then validated against experimental biomass productivities recorded in bench-scale ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.25517
更新日期:2015-05-01 00:00:00
abstract::The effects of growing Clostridium acetobutylicum NCIB 8052 in a chemostat under conditions of glucose, NH(4) (+), PO(4) (3-), Mg(2+), and Fe(2+) limitation were examined. It was noted that limitation of any major nutrient resulted in the same fermentation pattern. Conditions where minor nutrient levels were reduced a...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260290315
更新日期:1987-02-01 00:00:00
abstract::The relationship between oxygen concentration and growth rate in the yeast Trichosporon cutaneum was studied. In order to establish the conditions for purely oxygen-limited growth, the cells were first grown in a carbon-limited chemostat, and kinetic parameters determined. The cells were then grown in an oxygen-limite...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260241115
更新日期:1982-11-01 00:00:00
abstract::Fibrous proteins, such as silk, elastin and collagen are finding broad impact in biomaterial systems for a range of biomedical and industrial applications. Some of the key advantages of biosynthetic fibrous proteins compared to synthetic polymers include the tailorability of sequence, protein size, degradation pattern...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章,评审
doi:10.1002/bit.25820
更新日期:2016-05-01 00:00:00
abstract::We investigated the role of green sulfur bacteria inlight-responsive electricity generation in microbial electrochemical cells (MXCs). We operated MXCs containing either monocultures or defined cocultures of previously enriched phototrophic Chlorobium and anode-respiring Geobacter under anaerobic conditions in the abs...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.25011
更新日期:2014-02-01 00:00:00
abstract::We developed a self-assembling polymer based on polyallylamine (PAH) for use in DNA chips. Thioctic acid (TA) was covalently attached to PAH in sidechains to immobilize the polymer on a gold surface by self-assembly. N-hydroxysuccinimide-ester terminated probe single-stranded (ss) DNA is easily covalently immobilized ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20407
更新日期:2005-03-30 00:00:00
abstract::Growth decoupling can be used to optimize the production of biochemicals and proteins in cell factories. Inhibition of excess biomass formation allows for carbon to be utilized efficiently for product formation instead of growth, resulting in increased product yields and titers. Here, we used CRISPR interference to in...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27536
更新日期:2020-08-18 00:00:00
abstract::Enzymatic hydrolysis of arabinoxylan is an important prerequisite for the utilization of hemicellulose for ethanol fermentation or for making the low calorie sweetener xylitol by catalytic hydrogenation of the generated xylose. This study focus on cloning and characterization of two industrial relevant beta-xylosidase...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20908
更新日期:2006-08-05 00:00:00
abstract::An immobilized enzyme reactor has been developed to remove heparin, the anticoagulant that is required in all extracorporeal devices for patients undergoing open-heart surgery or kidney dialysis. The device uses the enzyme heparinase (EC 4.2.2.7), which is covalently linked to agarose with cyanogen bromide. A critical...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260300209
更新日期:1987-08-05 00:00:00
abstract::The conditions for the introduction of active carbonate groups into supports containing hydroxyl groups by reaction with 5-norbornene-2.3-dicarboximido carbonochloridate are described. Up to 1.5 mmol carbonate groups/g dry Sepharose 4B could be bound. In the case of glycine the reaction of the activated supports with ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260330105
更新日期:1989-01-05 00:00:00
abstract::Polypeptides containing between 4 and 32 repeats of a resilin-inspired sequence AQTPSSYGAP, derived from the mosquito Anopheles gambiae, have been used as tags on recombinant fusion proteins. These repeating polypeptides were inspired by the repeating structures that are found in resilins and sequence-related proteins...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.24565
更新日期:2012-12-01 00:00:00
abstract::Genetically engineered microbes have been intensively investigated as a means for the cost-effective production of isoprenoids. Bacillus subtilis is a promising microbial host for this purpose because of its fast growth rate and GRAS (generally regarded as safe) status. To date, development of this host has been impai...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.24900
更新日期:2013-09-01 00:00:00
abstract::Foam separation may have potential for protein recovery. However, for foam separation to be a viable protein recovery technique it is important to demonstrate, not only that high enrichments and recoveries can be achieved for single proteins, but also that high enrichments and recoveries, together with selectivity of ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19990205)62:3<291::aid-bit
更新日期:1999-02-05 00:00:00
abstract::Saccharomyces cerevisiae is a widely used host organism for the production of heterologous proteins, often cultivated in glucose-based fed-batch processes. This production system however has many factors limiting the productivity, mainly towards the end of the fermentation. For the optimised production of a Camelid an...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21150
更新日期:2007-02-15 00:00:00
abstract::This article studies the operation of a new process for the production of biopolymers (polyhydroxyalkanoates, PHAs) at different applied organic load rates (OLRs). The process is based on the aerobic enrichment of activated sludge to obtain mixed cultures able to store PHAs at high rates and yields. A mixture of aceti...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20683
更新日期:2006-01-05 00:00:00
abstract::Mevalonate is a useful metabolite synthesized from three molecules of acetyl-CoA, consuming two molecules of NADPH. Escherichia coli ( E. coli) catabolizes glucose to acetyl-CoA via several routes, such as the Embden-Meyerhof-Parnas (EMP) and the oxidative pentose phosphate (oxPP) pathways. Although the oxPP pathway s...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26923
更新日期:2019-05-01 00:00:00
abstract::The effects of low intensity pulsed ultrasound (LIPUS) on proliferation and chondrogenic differentiation of human mesenchymal stem cells (hMSCs) seeded on 3D printed poly-(ethylene glycol)-diacrylate (PEG-DA) scaffolds with varying pore geometries (square and hexagonal channels) were investigated. The scaffold with sq...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26480
更新日期:2018-02-01 00:00:00
abstract::The dissolved oxygen (DO) is an important variable in aerobic fermentations and affects the cell growth and product formation. Dissolved oxygen control is difficult in batch fermentations because of the time-varying conditions, time delays, and the probe dynamics. Modeling of the various patterns of biological activit...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19981005)60:1<1::aid-bit1>
更新日期:1998-10-05 00:00:00
abstract::Mathematical modeling of animal cell growth and metabolism is essential for the understanding and improvement of the production of biopharmaceuticals. Models can explain the dynamic behavior of cell growth and product formation, support the identification of the most relevant parameters for process design, and signifi...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27288
更新日期:2020-05-01 00:00:00
abstract::Engineered strains of Saccharomyces cerevisiae are used for industrial production of succinic acid. Optimal process conditions for dicarboxylic-acid yield and recovery include slow growth, low pH, and high CO2 . To quantify and understand how these process parameters affect yeast physiology, this study investigates in...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27210
更新日期:2020-03-01 00:00:00
abstract::Biofouling is the undesirable adhesion and development of microorganisms and macroorganisms in a water environment. An electrochemical antifouling system based on management of primary adhesion of microorganisms was developed employing titanium electrode for antifouling of seawater cooling pipes and marine infrastruct...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21022
更新日期:2006-10-20 00:00:00
abstract::The downstream processing of virus particles for vaccination or gene therapy is becoming a critical bottleneck as upstream titers keep improving. Moreover, the growing pressure to develop cost-efficient processes has brought forward new downstream trains. This review aims at analyzing the state-of-the-art in viral dow...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章,评审
doi:10.1002/bit.25545
更新日期:2015-05-01 00:00:00
abstract::Accurate measurement of enzymatic cellulose digestibility (X) is important in evaluating the efficiency of lignocellulose pretreatment technologies, assessing the performance of reconstituted cellulase mixtures, and conducting economic analysis for biorefinery processes. We analyzed the effect of sugars contained in e...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21178
更新日期:2007-01-01 00:00:00
abstract::A novel acetone-butanol production process was developed which integrates a repeated fed-batch fermentation with continuous product removal and cell recycle. The inhibitory product concentrations of the fermentation by Clostridium acetobutylicum were reduced by the simultaneous extraction process using polyvinylpyridi...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260470405
更新日期:1995-08-20 00:00:00
abstract::We report the assembly of seven different antibodies (and two antigens) into functional supramolecular structures that are specifically designed to facilitate integration into devices using entirely biologically based bottom-up fabrication. This is enabled by the creation of an engineered IgG-binding domain (HG3T) wit...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22238
更新日期:2009-06-01 00:00:00
abstract::By feeding ethanol at various high rates to low cell density cultures of Saccharomyces cerevisiae it was shown that the sharp fall in viability when ethanol is produced during rapid fermentations is in part a direct consequence of the high rate of change of extracellular ethanol concentration. Nevertheless, the fall i...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260350202
更新日期:1990-01-20 00:00:00
abstract::The adsorption of Thiobacillus ferrooxidans to coal surfaces has been studied. Adsorption experiments were conducted on coal samples from eight different Eastern coal fields. In all cases the adsorption process was at least 90% complete within the first two minutes following inoculation. The results of these experimen...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260280402
更新日期:1986-04-01 00:00:00
abstract::Efficient xylose utilization will facilitate microbial conversion of lignocellulosic sugar mixtures into valuable products. In Escherichia coli, xylose catabolism is controlled by carbon catabolite repression (CCR). However, in E. coli such as the succinate-producing strain KJ122 with disrupted CCR, xylose utilization...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27004
更新日期:2019-08-01 00:00:00
abstract::The lignin peroxidases (LIP) and manganese peroxidases (MNP) of Phanerochaete chrysosporium catalyze a wide range of lignin depolymerization reactions with lignin models and synthetic lignins in solution. However, their ability to degrade insoluble natural lignin in aqueous media has not been demonstrated. Insoluble i...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19980320)57:6<704::aid-bit
更新日期:1998-03-20 00:00:00
abstract::The growth and product formation of a Savinase-producing Bacillus clausii were investigated in high-cell-density fed-batch cultivations with both linear and exponential feed profiles. The highest specific productivity of Savinase was observed shortly after the end of the initial batch phase for all feed profiles appli...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10675
更新日期:2003-08-05 00:00:00