Abstract:
:Foam separation may have potential for protein recovery. However, for foam separation to be a viable protein recovery technique it is important to demonstrate, not only that high enrichments and recoveries can be achieved for single proteins, but also that high enrichments and recoveries, together with selectivity of partition, can be achieved for recovery from multi-component mixtures. Most process streams which require purification are indeed complex multi-component mixtures, for example, fermentation broths. In this study, three binary protein mixtures were chosen for continuous foam separation: beta-casein:lysozyme; Bovine serum albumin (BSA):lysozyme and beta-casein:BSA (mixtures 1, 2, and 3, respectively). For each of these mixtures, the expected outcome of each experiment, based on a previous knowledge and determination of relevant protein physical properties, was that the first protein should be preferentially separated into the foam phase. On the basis of results reported in Part I of this study for the continuous foam separation of beta-casein, conditions found to favor maximum enrichment were selected. For each mixture a range of concentrations of both proteins was considered. For mixture 1, maximum protein recoveries in the foam phase were 85.6% and 25% for beta-casein and lysozyme, respectively; and for mixture 2, maximum recoveries of 77. 6% and 18.9% were obtained for BSA and lysozyme, respectively. Maximum enrichment ratios in the foam phase were 79.4 and 2.5 for beta-casein and lysozyme respectively in mixture 1; and 74.0 and 1.4 for BSA and lysozyme respectively in mixture 2. Selective partitioning of beta-casein and BSA into the foam phase was obtained in mixtures 1 and 2, respectively, particularly for protein concentrations at which dilute protein films are known to form at the gas-liquid interface in the foam. Maximum partition ratios for mixtures 1 and 2 were 31.8 and 52.8, respectively. For mixture 3, both BSA and beta-casein were enriched into the foam phase. Maximum enrichments were 42.9 and 24.7 for BSA and beta-casein, respectively; however, selective partitioning in mixture 3 was limited (maximum partition ratio being 1.8).
journal_name
Biotechnol Bioengjournal_title
Biotechnology and bioengineeringauthors
Brown AK,Kaul A,Varley Jdoi
10.1002/(sici)1097-0290(19990205)62:3<291::aid-bitsubject
Has Abstractpub_date
1999-02-05 00:00:00pages
291-300issue
3eissn
0006-3592issn
1097-0290pii
10.1002/(SICI)1097-0290(19990205)62:3<291::AID-BITjournal_volume
62pub_type
杂志文章abstract::The effects of low intensity pulsed ultrasound (LIPUS) on proliferation and chondrogenic differentiation of human mesenchymal stem cells (hMSCs) seeded on 3D printed poly-(ethylene glycol)-diacrylate (PEG-DA) scaffolds with varying pore geometries (square and hexagonal channels) were investigated. The scaffold with sq...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26480
更新日期:2018-02-01 00:00:00
abstract::A simple methodology has been successfully employed to explain the solvent dependence of the substrate specificity of enzymes in organic media. This methodology, which does not require the knowledge of the enzyme structure and is thus applicable to lyophilized and other noncrystalline enzyme preparations, predicts tha...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19971105)56:3<340::AID-BIT
更新日期:1997-11-05 00:00:00
abstract::Hydrocarbon oils of the alga Botryococcus braunii, extracted from a natural "bloom" of the plant, have been hydrocracked to produce a distillate comprising 67% gasoline fraction, 15% aviation turbine fuel fraction, 15% diesel fuel fraction, and 3% residual oil. The distillate was examined by a number of standard petro...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260240116
更新日期:1982-01-01 00:00:00
abstract::The purpose of this article is to provide a few concrete examples of the potential to acceptably reduce the scope of validation and qualification testing based on scientific justification for the specific area of microbial fermentation. The key areas explored include: autoclave operational qualification (OQ) testing, ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.1094
更新日期:2001-07-05 00:00:00
abstract::The attrition bioreactor (ABR) combines wet ball milling and enzymatic hydrolysis in one process step. It was found that the ABR did not accelerate enzyme deactivation. Interfacial forces, not shear forces, caused the most deactivation. Elimination of the air-liquid interface by covering the reactor substantially incr...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260310106
更新日期:1988-01-01 00:00:00
abstract::A thermodynamic framework (UNIQUAC model with temperature dependent parameters) is applied to model the salt-induced protein crystallization equilibrium, i.e., protein solubility. The framework introduces a term for the solubility product describing protein transfer between the liquid and solid phase and a term for th...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19990720)64:2<144::aid-bit
更新日期:1999-07-20 00:00:00
abstract::Increased stability at alkaline pH should be a valuable attribute for the utilization of penicillin acylase in bioreactors employed to convert penicillins into 6-aminopenicillanic acid, a precursor of semisynthetic penicillins. In these systems, base is added for pH control, which results in local alkaline conditions ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260480208
更新日期:1995-10-20 00:00:00
abstract::More than 80 years after its discovery, penicillin is still a widely used and commercially highly important antibiotic. Here, we analyse the metabolic network of penicillin synthesis in Penicillium chrysogenum based on the concept of elementary flux modes. In particular, we consider the synthesis of the invariant mole...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.25694
更新日期:2016-01-01 00:00:00
abstract::The feasibility of producing ethanol in a continuous system from cellulose using Clostridirrrn thermocellum was investigated. This anaerobic and therniophilic bacterium was able to degrade cellulose directly into ethanol with acetic acid, hydrogen. and carbon dioxide as by-products of this fermentation. The fermentati...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260240106
更新日期:1982-01-01 00:00:00
abstract::This article reports a study of the performance of membrane-attached biofilms grown in a single tube extractive membrane bioreactor (STEMS) used for the treatment of a synthetic wastewater containing a toxic VOC (1,2-dichloroethane [DCE]). Mass balances show that complete mineralization of DCE was achieved, and that t...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260470111
更新日期:1995-07-05 00:00:00
abstract::The development of renewable alternatives to diesel and jet fuels is highly desirable for the heavy transportation sector, and would offer benefits over the production and use of short-chain alcohols for personal transportation. Here, we report the development of a metabolically engineered strain of Escherichia coli t...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22660
更新日期:2010-06-01 00:00:00
abstract::Five microbial inocula were evaluated in batch tests for the ability to remediate mine drainage (MD). Dairy manure (DM), anaerobic digester sludge, substrate from the Luttrell (LUTR) and Peerless Jenny King (PJK) sulfate-reducing permeable reactive zones (SR-PRZs) and material from an MD-treatment column that had been...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21930
更新日期:2008-11-01 00:00:00
abstract::The compound 5-hydroxymethylfurfural (HMF) has attracted much attention due to its versatility as an important bio-based platform chemical. Here, we engineered Raoultella ornithinolytica BF60 as a whole-cell biocatalyst for a highly efficient synthesis of 2,5-furandicarboxylic acid (FDCA) from HMF. Specifically, vario...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26725
更新日期:2018-09-01 00:00:00
abstract::Metabolically active resting (i.e., nongrowing) bacterial cells have a high potential in cofactor-dependent redox biotransformations. Where growing cells require carbon and energy for biomass production, resting cells can potentially exploit their metabolism more efficiently for redox biocatalysis allowing higher spec...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.24404
更新日期:2012-05-01 00:00:00
abstract::A two-member methane-utilizing mixed culture of bacteria, formed by combining two pure cultures isolated from a naturally occurring methane-utilizing mixed culture, was studied in continuous culture. From the nutritional requirements and substrate ranges of the pure cultures, a mechanism for the interspecific interact...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260221010
更新日期:1980-10-01 00:00:00
abstract::A high-rate anaerobic digestion of food waste leachate were tested using intermittent continuously stirred tank reactors (iCSTRs) to evaluate how severe ammonia inhibition could be mitigated with internal dilution strategy, and to identify how bacterial and archaeal community respond in genus and species level. Experi...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.25968
更新日期:2016-09-01 00:00:00
abstract::The fermentation kinetics of methane production from whey permeate in a packed bed immobilized cell bioreactor at mesophilic temperatures and pHs around neutral was studied. Propionate and acetate were the only two major organic intermediates found in the methanogenic fermentation of lactose. Based on this finding, a ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260370412
更新日期:1991-02-20 00:00:00
abstract::A key challenge for bioprocess engineering is the identification of the optimum process conditions for the production of biochemical and biopharmaceutical compounds using prokaryotic as well as eukaryotic cell factories. Shake flasks and bench-scale bioreactor systems are still the golden standard in the early stage o...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27338
更新日期:2020-07-01 00:00:00
abstract::We have developed a dual-chambered bioreactor (DCB) that incorporates a membrane to study stratified 3D cell populations for skin tissue engineering. The DCB provides adjacent flow lines within a common chamber; the inclusion of the membrane regulates flow layering or mixing, which can be exploited to produce layers o...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27164
更新日期:2019-12-01 00:00:00
abstract::Mixed culture of microorganisms immobilized onto Celite diatomaceous earth particles were used to degrade 3,4-dichloroaniline (34DCA) in a three-phase draft tube fluidized bed bioreactor. Biodegradation was confirmed as the dominant removal mechanism by measurements of the concomitant chloride ion evolution. Degradati...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260380308
更新日期:1991-07-01 00:00:00
abstract::Anaerobic digestion of biological organic particulates to methane has been described by a structured mathematical model based on multiple-reaction stoichiometry, conventional material balances, and liquid phase equilibrium chemistry. A general stoichiometric treatment for any set of multiple biological reactions is de...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260270514
更新日期:1985-05-01 00:00:00
abstract::The kinetics and mechanism of Fe(III) reduction to Fe(II) were studied in pure batch cultures of Pseudomonas sp. 200. The rate of iron reduction has been mechanistically related to aqueous phase iron speciation. In the absence of microbial activity the iron reduction rate was negligible. Initial rates of microbial iro...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260281110
更新日期:1986-11-01 00:00:00
abstract::In this study, the effects of the electric charges and fields on the viability of airborne microorganisms were investigated. The electric charges of different magnitude and polarity were imparted on airborne microbial cells by a means of induction charging. The airborne microorganisms carrying different electric charg...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10290
更新日期:2002-07-20 00:00:00
abstract::Continuous manufacturing is currently being seriously considered in the biopharmaceutical industry as the possible new paradigm for producing therapeutic proteins, due to production cost and product quality related benefits. In this study, a monoclonal antibody producing CHO cell line was cultured in perfusion mode an...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26069
更新日期:2017-02-01 00:00:00
abstract::Effective enzyme-mediated viscosity reduction, disaggregation, or "liquefaction," is required to overcome the rheological challenges resulting from the fibrous, hygroscopic nature of lignocellulosic biomass, particularly at the high solids loadings that will be required for an economically viable process. However, the...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26381
更新日期:2017-11-01 00:00:00
abstract::Substrate transfer rates from organic to aqueous phases were measured in the presence and absence of biocatalyst in the reaction medium, using modified Lewis cells. These measurements, in combination with intrinsic aqueous phase biocatalytic reaction kinetics, were used to confirm that benzyl acetate hydrolysis by pig...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260370207
更新日期:1991-01-20 00:00:00
abstract::Glycosylation is a key critical quality attribute for monoclonal antibodies and other recombinant proteins because of its impact on effector mechanisms and half-life. In this study, a variety of compounds were evaluated for their ability to modulate glycosylation profiles of recombinant monoclonal antibodies produced ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26904
更新日期:2019-04-01 00:00:00
abstract::Although several compelling benefits for bioprocess intensification have been reported, the need for a streamlined integration of perfusion cultures with capture chromatography still remains unmet. Here, a robust solution is established by conducting tangential flow filtration-based perfusion with a wide-surface pore ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27504
更新日期:2020-07-15 00:00:00
abstract::The treatment of large segmental bone defects remains a challenge as infection, delayed union, and nonunion are common postoperative complications. A three-dimensional printed bioresorbable and physiologically load-sustaining graft substitute was developed to mimic native bone tissue for segmental bone repair. Fabrica...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26780
更新日期:2018-09-01 00:00:00
abstract::Whole cell pyruvate decarboxylase (PDC) from Candida utilis enhanced the enzymatic production of (R)-phenylacetylcarbinol (PAC) in an aqueous/octanol biotransformation compared to the partially purified PDC especially for a lower range of initial activities (0.3-2.5 U/mL). With an initial activity of 1.1 U/mL and at a...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20959
更新日期:2006-08-20 00:00:00