Abstract:
:Installing membranes for solid-liquid separation into biological nutrient removal (BNR) activated sludge (AS) systems makes a profound difference not only in the design of the BNR system itself, but also in the design approach for the whole wastewater treatment plant (WWTP). In multizone BNR systems with membranes in the aerobic reactor and fixed volumes for the anaerobic, anoxic, and aerobic zones (i.e., fixed volume fractions), the mass fractions can be controlled (within a range) with the interreactor recycle ratios. This zone mass fraction flexibility is a significant advantage in membrane BNR systems over conventional BNR systems with SSTs, because it allows for changing of the mass fractions to optimize biological N and P removal in conformity with influent wastewater characteristics and the effluent N and P concentrations required. For PWWF/ADWF ratios in the upper range (f(q) approximately 2.0), aerobic mass fractions in the lower range (f(maer) < 0.60), and high (usually raw) wastewater strengths, the indicated mode of operation of MBR BNR systems is as extended aeration WWTPs. Although the volume reduction compared with equivalent conventional BNR systems with secondary settling tanks is not as large (40% to 60%), the cost of the membranes can be offset against sludge thickening and stabilization costs. Moving from a flow-unbalanced raw wastewater system to a flow-balanced (f(q) = 1), low (usually settled) wastewater strength system can double the ADWF capacity of the biological reactor, but the design approach of the WWTP changes from extended aeration to include primary sludge stabilization. The cost of primary sludge treatment then has to be paid from the savings from the increased WWTP capacity.
journal_name
Biotechnol Bioengjournal_title
Biotechnology and bioengineeringauthors
Ramphao M,Wentzel MC,Merritt R,Ekama GA,Young T,Buckley CAdoi
10.1002/bit.20311subject
Has Abstractpub_date
2005-03-20 00:00:00pages
630-46issue
6eissn
0006-3592issn
1097-0290journal_volume
89pub_type
杂志文章abstract::The possibility of enhancing the biomass productivity of a continuous culture of Saccharomyces cerevisiae growing on a glucose-limited medium is addressed. An unstructured Monod-type model is first identified using steady-state data. The culture is subjected to step changes in dilution rate, and it is seen that the Mo...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260340603
更新日期:1989-09-01 00:00:00
abstract::The activities of lipase from Candida cylindracea and Rhizopus delemar have been investigated in water/AOT/iso-octane reverse micellar media through the use of two esterification reactions: fatty acid-alcohol esterification and glyceride synthesis. Such media promotes the occurrence of these two lipase-catalyzed react...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260350807
更新日期:1990-04-05 00:00:00
abstract::We consider the application of high-throughput experimentation (HTE), including combinatorial methods, to catalyst discovery and early-phase optimization. While combinatorial- and parallel-testing methods have an already substantial history in catalysis, recent work by several groups promises significant efficiency ga...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(1998)61:4<203::aid-cc3>3.0
更新日期:1998-01-01 00:00:00
abstract::The study reports on the development of a bioreactor for the production of alpha-keto acids from D,L- or D-amino acids using Rhodotorula gracilis D-amino acid oxidase. D-amino acid oxidase was co-immobilized with catalase on Affi-Gel 10 matrix, and the reactor was operated as a continuous-stirred tank reactor (CSTR) o...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260441104
更新日期:1994-12-01 00:00:00
abstract::Hepatic steatosis is a process of abnormal lipid deposition within the liver cells, often caused by excessive alcohol uptake or obesity. A conventional in vitro model for hepatic steatosis uses a liver cell culture, treated with fatty acids and measures accumulation of lipids within the cells. This model does not reca...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26793
更新日期:2018-11-01 00:00:00
abstract::The kinetics of the cellulase-catalyzed conversion of soluble cellulose into glucose have been studied over a range of substrate concentrations and temperatures, and at pH values ranging from 4.75 to 7.0. Lineweaver-Burk plots were linear and led to V = 6.2muM/s and K(m) = 13.1 mM at pH 5.8 and 25.0 degrees C. The pK ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260251011
更新日期:1983-10-01 00:00:00
abstract::Two types of polyethylenimine-coated glass microbeads (13-44 micrometer) were synthesized and used for the immobilization of glucose oxidase from Aspergillus niger and catalase from A. niger and beef liver. The two types of beads were distinguishable by differences in their surface topography. Immobilizations were per...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260220203
更新日期:1980-02-01 00:00:00
abstract::The calculation of many derived fermentation variables such as the respiratory quotient (RQ) and mass transfer coefficient (K(L)a) requires the differences between the molar percentages of oxygen and carbon dioxide in the fermentor inlet and exit gas, called the %OUR and %CER. Noise and bias in %CER data is of order t...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260400511
更新日期:1992-08-01 00:00:00
abstract::The amount of ATP produced during n-alkane, fatty acid, or acetate metabolism in Candida tropicalis has been established from the P/O ratios measured on isolated mitochondria, yield on substrate and carbon balance. For these three kinds of substrates YATP value has been found to be close to 4, although Ysub on acetate...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260171202
更新日期:1975-12-01 00:00:00
abstract::C-terminal lysine (C-K) variants are commonly observed in therapeutic monoclonal antibodies and recombinant proteins. Heterogeneity of C-K residues is believed to result from varying degree of proteolysis by endogenous carboxypeptidase(s) during cell culture production. The achievement of batch-to-batch culture perfor...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.24510
更新日期:2012-09-01 00:00:00
abstract::A generic "system on a plate" modular multicompartmental bioreactor array which enables microwell protocols to be transferred directly to the bioreactor modules, without redesign of cell culture experiments or protocols is described. The modular bioreactors are simple to assemble and use and can be easily compared wit...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22671
更新日期:2010-05-01 00:00:00
abstract::The evolution of microbial populations involved in simulated-heap leaching of a polymetallic black schist sulfide ore (from the recently-commissioned Talvivaara mine, Finland) was monitored in aerated packed bed column reactors over a period of 40 weeks. The influence of ore particle size (2-6.5 mm and 6.5-12 mm) on c...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21951
更新日期:2008-11-01 00:00:00
abstract::Genome-scale flux analysis of Escherichia coli DH5alpha growth in a complex medium was performed to investigate the relationship between the uptake of various nutrients and their metabolic outcomes. During the exponential growth phase, we observed a sequential consumption order of serine, aspartate and glutamate in th...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22119
更新日期:2009-02-15 00:00:00
abstract::A method was developed for obtaining high signal-to-noise 13C NMR spectra of intracellular compounds in metabolically active cultured cells. The method allows TCA cycle labeling kinetics to be determined in real time without significant oxygen transport limitations. Cells were immobilized on the surface of nonporous m...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20191
更新日期:2004-09-30 00:00:00
abstract::A biodevice involving thiolated ssDNA and engineered cytochrome b5 linked through a cis-platine bridge is described. This original nanostructure is associated to a supported membrane through a floating anchor, thus constituting a dynamic bidimensionnal DNA capture device contrasting with the constrained geometry of cu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10111
更新日期:2002-01-20 00:00:00
abstract::A model for cometabolism is verified experimentally for a defined methanotrophic mixed culture. The model includes the effects of cell growth, endogenous cell decay, product toxicity, and competitive inhibition with the assumption that cometabolic transformation rates are enhanced by reducing power obtained from oxida...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19971205)56:5<492::AID-BIT
更新日期:1997-12-05 00:00:00
abstract::A simple approach was developed to determine the half-saturation coefficient for dissolved oxygen (K(DO)) for three bacteria by maintaining a constant oxygen concentration in continuous culture, and employing a dynamic method to obtain the specific growth rate (mu) for each species. Measurement of mu at selected disso...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260250209
更新日期:1983-02-01 00:00:00
abstract::Cell culture longevity in fed-batch culture of hybridomas is often limited by elevated medium osmolality caused by repeated nutrient feeding. Shotwise feeding of 10x Dulbecco's modified Eagle's medium (DMEM) concentrates elevated the osmolality of medium up to 540 mOsm/kg at the end of fed-batch culture of S3H5/gamma2...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19990105)62:1<120::aid-bit
更新日期:1999-01-05 00:00:00
abstract::A transient, two-culture model simulating methane production from biomass has been developed. The simulator, based partially on the work by Andrews and McCarty, is capable of calculating the hydrolysis products of several common organic materials, accommodating various substrate feeding modes, and simulating the trans...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260240903
更新日期:1982-09-01 00:00:00
abstract::Enzyme clustering into compact agglomerates could accelerate the processing of intermediates to enhance metabolic pathway flux. However, enzyme clustering is still a challenging task due to the lack of universal assembly strategy applicable to all enzymes. Therefore, we proposed an alternative enzyme assembly strategy...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27304
更新日期:2020-05-01 00:00:00
abstract::Short-chain carboxylic acids generated by various mixed- or pure-culture fermentation processes have been considered valuable precursors for production of bioalcohols. While conversion of carboxylic acids into alcohols is routinely performed with catalytic hydrogenation or with strong chemical reducing agents, here, a...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.24786
更新日期:2013-04-01 00:00:00
abstract::A novel technique for immobilization of Candida rugosa lipase onto anionic colloidal gas aphrons (CGAs) is described. CGAs are spherical microbubbles (10-100 microm) composed of an inner gas core surrounded by a surfactant shell. In this initial study, greater than 80% lipase (w/w) was effectively retained on the CGAs...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.1116
更新日期:2001-08-05 00:00:00
abstract::Aspergillus awamori NRRL 4869 was cultured on the solid substrate, wheat bran, in a modified Rollacell apparatus to produce alpha-galactosidase and invertase. The swivel cap on the elongated bottle permits the introduction of air while the bottle rotates. Parameters of air flow rate (0.05-0.2 liter/kg/min), rpm (0.15-...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260220213
更新日期:1980-02-01 00:00:00
abstract::Dielectric spectroscopy was applied to two industrial high cell density culture processes and used to determine on-line the concentration of CHO cells immobilized on macroporous microcarriers in a stirred bioreactor and in a packed-bed of disk carriers. The cell concentration predicted from the spectroscopic data was ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.1197
更新日期:2002-02-05 00:00:00
abstract::It is known that the rolA, rolB, and rolC genes of Agrobacterium rhizogenes T-DNA affect processes of plant development and activate the synthesis of secondary metabolites in transformed plant cells. Although a synergistic activity of the rol genes on root formation is well-documented, little is known about their indi...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.21727
更新日期:2008-05-01 00:00:00
abstract::Hairy root cultures of Catharanthus roseus were established by infection of seedlings with Agrobacterium rhizogenes 15834. Approximately 150 transformants from four different. C. roseus cultivars were screened for desirable traits in growth and indole alkaloid production. Five hairy root clones grew well in liquid cul...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260410511
更新日期:1993-03-05 00:00:00
abstract::Continuous propionic acid fermentations of lactate by Propionibacterium acidipropionici were studied in spiral wound fibrous bed bioreactors. Cells were imobilized by natural attachment to fiber surfaces and entrapment in the void volume within the fibrous matrix. A high cell density of approximately 37 g/L was attain...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260400404
更新日期:1992-08-05 00:00:00
abstract::A new high throughput technique for enzyme characterization with specific attention to the long term stability, called "Enzyme Test Bench," is presented. The concept of the Enzyme Test Bench consists of short term enzyme tests in 96-well microtiter plates under partly extreme conditions to predict the enzyme long term...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22242
更新日期:2009-06-01 00:00:00
abstract::This paper describes construction of a nanosensory device for amplified detection of biologically important amines as chemical signals. The device was inspired by a biological signal transduction system, and was fabricated on an artificial cell membrane through self-organization of the molecular components, such as a ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22521
更新日期:2010-01-01 00:00:00
abstract::The photosynthetic performance of a helical tubular photobioreactor ("Biocoil"), incorporating the filamentous cyanobacterium Spirulina platensis, was investigated. The photobioreactor was constructed in a cylindrical shape (0.9 m high) with a 0.25-m(2)basal area and a photostage comprising 60 m of transparent PVC tub...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260470218
更新日期:1995-07-20 00:00:00