Abstract:
BACKGROUND:For the cultivation of Escherichia coli in bioreactors trace element solutions are generally designed for optimal growth under aerobic conditions. They do normally not contain selenium and nickel. Molybdenum is only contained in few of them. These elements are part of the formate hydrogen lyase (FHL) complex which is induced under anaerobic conditions. As it is generally known that oxygen limitation appears in shake flask cultures and locally in large-scale bioreactors, function of the FHL complex may influence the process behaviour. Formate has been described to accumulate in large-scale cultures and may have toxic effects on E. coli.Although the anaerobic metabolism of E. coli is well studied, reference data which estimate the impact of the FHL complex on bioprocesses of E. coli with oxygen limitation have so far not been published, but are important for a better process understanding. RESULTS:Two sets of fed-batch cultures with conditions triggering oxygen limitation and formate accumulation were performed. Permanent oxygen limitation which is typical for shake flask cultures was caused in a bioreactor by reduction of the agitation rate. Transient oxygen limitation, which has been described to eventually occur in the feed-zone of large-scale bioreactors, was mimicked in a two-compartment scale-down bioreactor consisting of a stirred tank reactor and a plug flow reactor (PFR) with continuous glucose feeding into the PFR.In both models formate accumulated up to about 20 mM in the culture medium without addition of selenium, molybdenum and nickel. By addition of these trace elements the formate accumulation decreased below the level observed in well-mixed laboratory-scale cultures. Interestingly, addition of the extra trace elements caused accumulation of large amounts of lactate and reduced biomass yield in the simulator with permanent oxygen limitation, but not in the scale-down two-compartment bioreactor. CONCLUSION:The accumulation of formate in oxygen limited cultivations of E. coli can be fully prevented by addition of the trace elements selenium, nickel and molybdenum, necessary for the function of FHL complex. For large-scale cultivations, if glucose gradients are likely, the results from the two-compartment scale-down bioreactor indicate that the addition of the extra trace elements is beneficial. No negative effects on the biomass yield or on any other bioprocess parameters could be observed in cultures with the extra trace elements if the cells were repeatedly exposed to transient oxygen limitation.
journal_name
Microb Cell Factjournal_title
Microbial cell factoriesauthors
Soini J,Ukkonen K,Neubauer Pdoi
10.1186/1475-2859-7-26subject
Has Abstractpub_date
2008-08-07 00:00:00pages
26issn
1475-2859pii
1475-2859-7-26journal_volume
7pub_type
杂志文章abstract:BACKGROUND:Fine-tuning the aeration for cultivations when oxygen-limited conditions are demanded (such as the production of vaccines, isobutanol, 2-3 butanediol, acetone, and bioethanol) is still a challenge in the area of bioreactor automation and advanced control. In this work, an innovative control strategy based on...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-019-1198-6
更新日期:2019-09-04 00:00:00
abstract:BACKGROUND:Numerous studies have shown that stress induction and genetic engineering can effectively increase lipid accumulation, but lead to a decrease of growth in the majority of microalgae. We previously found that elevated CO2 concentration increased lipid productivity as well as growth in Phaeodactylum tricornutu...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-019-1214-x
更新日期:2019-09-23 00:00:00
abstract:BACKGROUND:The discovery of the autotransporter family has provided a mechanism for surface expression of proteins in laboratory strains of Escherichia coli. We have previously reported the use of the AIDA-I autotransport system to express the Salmonella enterica serovar Enteritidis proteins SefA and H:gm. The SefA pro...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-11-118
更新日期:2012-09-03 00:00:00
abstract:BACKGROUND:The CRISPR/Cas9 system is a powerful tool for genome editing, in which the sgRNA binds and guides the Cas9 protein for the sequence-specific cleavage. The protocol is employable in different organisms, but is often limited by cell damage due to the endonuclease activity of the introduced Cas9 and the potenti...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-017-0758-x
更新日期:2017-08-16 00:00:00
abstract:BACKGROUND:Bifidobacterium spp. are representative probiotics that play an important role in the health of their hosts. Among various Bifidobacterium spp., B. bifidum BGN4 exhibits relatively high cell adhesion to colonic cells and has been reported to have various in vivo and in vitro bio functionalities (e.g., anti-a...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-020-01505-y
更新日期:2021-01-19 00:00:00
abstract:BACKGROUND:Lipases (EC 3.1.1.3) catalyze the hydrolysis of triacyl glycerol to glycerol and are involved in the synthesis of both short chain and long chain acylglycerols. They are widely used industrially in various applications, such as baking, laundry detergents and as biocatalysts in alternative energy strategies. ...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-11-72
更新日期:2012-06-01 00:00:00
abstract:BACKGROUND:In Saccharomyces cerevisiae, alpha-glucosidase (maltase) is a key enzyme in maltose metabolism. In addition, the overexpression of the alpha-glucosidase-encoding gene MAL62 has been shown to increase the freezing tolerance of yeast in lean dough. However, its cryoprotection mechanism is still not clear. RES...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-020-01454-6
更新日期:2020-10-19 00:00:00
abstract:BACKGROUND:The unicellular cyanobacterium Synechocystis sp. PCC 6803 has been widely used as a photoautotrophic host for synthetic biology studies. However, as a green chassis to capture CO2 for biotechnological applications, the genetic toolbox for Synechocystis 6803 is still a limited factor. RESULTS:We systematical...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-018-0897-8
更新日期:2018-03-26 00:00:00
abstract:BACKGROUND:Ethanologenic alphaproteobacterium Zymomonas mobilis has been acknowledged as a promising biofuel producer. There have been numerous efforts to engineer this species applicable for an industrial-scale bioethanol production. Although Z. mobilis is robustly resilient to certain abiotic stress such as ethanol, ...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-020-01406-0
更新日期:2020-07-20 00:00:00
abstract:BACKGROUND:Amylases are used in various industrial processes and a key requirement for the efficiency of these processes is the use of enzymes with high catalytic activity at ambient temperature. Unfortunately, most amylases isolated from bacteria and filamentous fungi have optimal activity above 45 °C and low pH. For ...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-017-0693-x
更新日期:2017-05-02 00:00:00
abstract::The biotechnology industry has become a key element in modern societies. Within this industry, the production of recombinant enzymes and biopharmaceutical proteins is of major importance. The global markets for such recombinant proteins are growing rapidly and, accordingly, there is a continuous need for new productio...
journal_title:Microbial cell factories
pub_type: 社论
doi:10.1186/1475-2859-12-3
更新日期:2013-01-14 00:00:00
abstract:BACKGROUND:Trypsin has many applications in food and pharmaceutical manufacturing. Although commercial trypsin is usually extracted from porcine pancreas, this source carries the risks of infectivity and immunogenicity. Microbial Streptomyces griseus trypsin (SGT) is a prime alternative because it possesses efficient h...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-020-01338-9
更新日期:2020-04-13 00:00:00
abstract:BACKGROUND:Oil palm empty fruit bunch (EFB) is a lignocellulosic waste produced in palm oil industry. EFB mainly consists of cellulose, hemicellulose (mainly xylan) and lignin and has a great potential to be reused. Converting EFB to fermentable sugars and value-added chemicals is a much better choice than treating EFB...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-014-0157-5
更新日期:2014-11-11 00:00:00
abstract::Innovative new genome engineering technologies for manipulating chromosomes have appeared in the last decade. One of these technologies, recombination mediated genetic engineering (recombineering) allows for precision DNA engineering of chromosomes and plasmids in Escherichia coli. Single-stranded DNA recombineering (...
journal_title:Microbial cell factories
pub_type: 杂志文章,评审
doi:10.1186/1475-2859-13-S1-S10
更新日期:2014-08-29 00:00:00
abstract:BACKGROUND:Although the citric acid fermentation by Aspergillus niger is one of the most important industrial microbial processes and various aspects of the fermentation appear in a very large number of publications since the 1950s, the effect of the spore inoculum level on fungal morphology is a rather neglected area....
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-5-3
更新日期:2006-01-25 00:00:00
abstract:: The aim of this work is to present a critical review on slurry bioreactors (SB) and their application to bioremediation of soils and sediments polluted with recalcitrant and toxic compounds. The scope of the review encompasses the following subjects: (i) process fundamentals of SB and analysis of advantages and disad...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-7-5
更新日期:2008-02-29 00:00:00
abstract:BACKGROUND:Molecular mechanisms generating genetic variation provide the basis for evolution and long-term survival of a population in a changing environment. In stable, laboratory conditions, the variation-generating mechanisms are dispensable, as there is limited need for the cell to adapt to adverse conditions. In f...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-11-11
更新日期:2012-01-20 00:00:00
abstract:BACKGROUND:Epimutations arising from transcriptional slippage seem to have more important role in regulating gene expression than earlier though. Since the level and the fidelity of transcription primarily determine the overall efficiency of gene expression, all factors contributing to their decrease should be identifi...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-018-0999-3
更新日期:2018-09-21 00:00:00
abstract::This article describes the use of biofilm reactors for the production of various chemicals by fermentation and wastewater treatment. Biofilm formation is a natural process where microbial cells attach to the support (adsorbent) or form flocs/aggregates (also called granules) without use of chemicals and form thick lay...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-4-24
更新日期:2005-08-25 00:00:00
abstract:BACKGROUND:The sesquiterpenoid abscisic acid (ABA) is mostly known for regulating developmental processes and abiotic stress responses in higher plants. Recent studies show that ABA also exhibits a variety of pharmacological activities. Affordable and sustainable production will be required to utilize the compound in a...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-019-1257-z
更新日期:2019-11-25 00:00:00
abstract:BACKGROUND:Catalase (EC 1.11.1.6) is one of the important industrial enzyme employed in diagnostic and analytical methods in the form of biomarkers and biosensors in addition to their enormous applications in textile, paper, food and pharmaceutical sectors. The present study demonstrates the utility of a newly isolated...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-016-0410-1
更新日期:2016-01-14 00:00:00
abstract:BACKGROUND:Crocin is a carotenoid-derived natural product found in the stigma of Crocus spp., which has great potential in medicine, food and cosmetics. In recent years, microbial production of crocin has drawn increasing attention, but there were no reports of successful implementation. Escherichia coli has been engin...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-019-1166-1
更新日期:2019-07-05 00:00:00
abstract:BACKGROUND:Rhodosporidium and Rhodotorula are two genera of oleaginous red yeast with great potential for industrial biotechnology. To date, there is no effective method for inducible expression of proteins and RNAs in these hosts. RESULTS:We have developed a luciferase gene reporter assay based on a new codon-optimiz...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-015-0357-7
更新日期:2015-10-26 00:00:00
abstract::Industrial development may result in the increase of environmental risks. The enzymatic transformation of polluting compounds to less toxic or even innocuous products is an alternative to their complete removal. In this regard, a number of different redox enzymes are able to transform a wide variety of toxic pollutant...
journal_title:Microbial cell factories
pub_type: 社论
doi:10.1186/1475-2859-3-10
更新日期:2004-08-02 00:00:00
abstract:BACKGROUND:Invertase Suc2 was recently identified as a key hydrolase for inulin catabolism in Saccharomyces cerevisiae, whereas the Suc2 activity degrading inulin varies greatly in different S. cerevisiae strains. The molecular mechanism causing such variation remained obscure. The aim of this study is to investigate h...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-015-0243-3
更新日期:2015-04-17 00:00:00
abstract:BACKGROUND:A key advantage of recombinant antibody technology is the ability to optimize and tailor reagents. Single domain antibodies (sdAbs), the recombinantly produced variable domains derived from camelid and shark heavy chain antibodies, provide advantages of stability and solubility and can be further engineered ...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-017-0837-z
更新日期:2017-12-12 00:00:00
abstract:BACKGROUND:D-Lactate is a valued chemical which can be produced by some bacteria including Klebsiella pneumoniae. However, only a few studies have focused on K. pneumoniae for D-lactate production with a significant amount of by-products, which complicated the purification process and decreased the yield of D-lactate. ...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-017-0822-6
更新日期:2017-11-21 00:00:00
abstract:BACKGROUND:Nowadays, microbial infections have caused increasing economic losses in aquaculture industry and deteriorated worldwide environments. Many of these infections are caused by opportunistic pathogens through cell-density mediated quorum sensing (QS). The disruption of QS, known as quorum quenching (QQ), is an ...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-020-01448-4
更新日期:2020-10-07 00:00:00
abstract:BACKGROUND:Plasmid expression is a popular method in studies of MVA pathway for isoprenoid production in Escherichia coli. However, heterologous gene expression with plasmid is often not stable and might burden growth of host cells, decreases cell mass and product yield. In this study, MVA pathway was divided into thre...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/s12934-016-0607-3
更新日期:2016-12-01 00:00:00
abstract:BACKGROUND:The selection of bacterial recombinants that harbour a desired insert, has been a key factor in molecular cloning and a series of screening procedures need to be performed for selection of clones carrying the genes of interest. The conventional cloning techniques are reported to have problems such as screeni...
journal_title:Microbial cell factories
pub_type: 杂志文章
doi:10.1186/1475-2859-9-30
更新日期:2010-05-11 00:00:00