Abstract：
:This work studies the sequential execution of dilute sulfuric acid (DAP) (0.1-0.75 %, v/v) and dilute sodium hydroxide (AKP) (0.25-3 %, w/v) [i.e., DAP followed by AKP (DAP+AKP) and vice versa (AKP+DAP)] at low temperatures (<121 °C) and short reaction times (5-60 min) for maximizing sugar recovery in the enzymatic hydrolysis of wheat straw with low enzyme dosage. The pretreatment effectiveness was measured by the sum of the severity factors of both pretreatments and the saccharification yield achieved in the subsequent stage of enzymatic hydrolysis. Degradation compounds were quantified and mass balance calculations were carried out for each pretreatment sequence to verify the correct account of the input biomass and output products. Results show that sequential pretreatments (AKP+DAP and DAP+AKP) had a positive effect in enzyme accessibility thus improving monosaccharide yields compared to single DAP and AKP pretreatments. DAP+AKP achieved a high xylose yield (ca. 0.867 of theoretical) at the DAP stage, while no xylose monosaccharides were detected in the subsequent AKP. After enzyme saccharification of double-pretreated solids, the total monosaccharide yield was 0.786 (of theoretical). For AKP+DAP sequence, lower results were obtained (total monosaccharide yield 0.783 of theoretical). Sequential pretreatments total yields increased by 21 % compared to single pretreatments. AKP removed more than half of the lignin from the wheat straw in all cases. Acid and alkali concentrations played a relevant role in all pretreatment sequences, while reaction time and temperature were less important with an almost-linear effect on the total monosaccharide yields.
journal_name
Bioprocess Biosyst Engjournal_title
Bioprocess and biosystems engineeringauthors
Sanchez A,Gil JC,Rojas-Rejón OA,de Alba AP,Medina A,Flores R,Puente Rdoi
10.1007/s00449-015-1355-1subject
Has Abstractpub_date
2015-06-01 00:00:00pages
1127-41issue
6eissn
1615-7591issn
1615-7605journal_volume
38pub_type
杂志文章abstract：:Recycled paper mills produce large quantities of fibrous rejects and fines which are usually sent to landfills as solid waste. These cellulosic materials can be enzymatically hydrolyzed into sugars for the production of biofuels and biomaterials. Paper mill wastes also contain large amounts of calcium carbonate which ...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-017-1745-7
更新日期：2017-06-01 00:00:00
abstract：:This study proposes a microfluidic device capable of separating monocytes from a type of cancer cell that is called T-cell acute lymphoblastic leukemia (RPMI-8402) in a continuous flow using negative and positive dielectrophoretic forces. The use of both the hydrodynamic and dielectrophoretic forces allows the separat...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-020-02349-x
更新日期：2020-09-01 00:00:00
abstract：:Bacteria from Patagonian Merino wool were isolated to assess their wool-keratinolytic activity and potential for felt-resist treatments. Strains from Bacillus, Exiguobacterium, Deinococcus, and Micrococcus produced wool-degrading enzymes. Bacillus sp. G51 showed the highest wool-keratinolytic activity. LC-MS/MS analys...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-017-1748-4
更新日期：2017-06-01 00:00:00
abstract：:Gas sparging performances of a flat sheet and tubular polymeric membranes were investigated in 3.1 m bubble column bioreactor operated in a semi batch mode. Air-water and air-CMC (Carboxymethyl cellulose) solutions of 0.5, 0.75 and 1.0 % w/w were used as interacting gas-liquid mediums. CMC solutions were employed in t...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-016-1543-7
更新日期：2016-04-01 00:00:00
abstract：:Corrosion in bioprocessing applications is described for a 25-year-old bioprocessing pilot plant facility. Various available stainless steel alloys differ greatly in properties owing to the impact of specific alloying elements and their concentrations. The alloy property evaluated was corrosion resistance as a functio...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章,评审
doi：10.1007/s00449-008-0223-7
更新日期：2009-01-01 00:00:00
abstract：:Calcitriol is an important drug used for treating osteoporosis, which can be produced from vitamin D3. The current method of producing calcitriol from vitamin D3 during cultivation of microbial cells results in low yields of calcitriol and high purification costs. Therefore, in this study, the steps of cell cultivatio...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-015-1368-9
更新日期：2015-07-01 00:00:00
abstract：:Armillaria sp. F022, a white-rot fungus isolated from decayed wood in tropical rain forest was used to biodegrade anthracene in cultured medium. The percentage of anthracene removal by Armillaria sp. F022 reached 13 % after 7 days and at the end of the experiment, anthracene removal level was at 87 %. The anthracene r...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-012-0850-x
更新日期：2013-09-01 00:00:00
abstract：:The enzymatic method for synthesising polyglycerol polyricinoleate (PGPR), a food additive named E-476, was successfully carried out in the presence of immobilised Rhizopus oryzae lipase in a solvent-free medium. The great advantage of using the commercial preparation of R. oryzae lipase is that it is ten times cheape...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-012-0874-2
更新日期：2013-09-01 00:00:00
abstract：:The lack of sensors for some relevant state variables in fermentation processes can be coped by developing appropriate software sensors. In this work, NARX-ANN, NARMAX-ANN, NARX-SVM and NARMAX-SVM models are compared when acting as software sensors of biomass concentration for a solid substrate cultivation (SSC) proce...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-013-0925-3
更新日期：2014-01-01 00:00:00
abstract：:The performance of down-flow hanging sponge (DHS) system treating UASB reactor effluent at different sponge volume of 38.2, 28.7, 19.1 and 9.6% was investigated. The hydraulic retention time (HRT) and flow rate were kept constant at 2.6 h and 0.46 m(3)/day, respectively. The results obtained indicated that reducing th...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-009-0399-5
更新日期：2010-09-01 00:00:00
abstract：:Lysozyme is a lytic enzyme, which has antimicrobial activity. It has been used for food and pharmaceutical applications. This study was undertaken to evaluate fed-batch and continuous fermentations for the human lysozyme production in biofilm reactor. Results showed that addition of lactose the mid-log phase to make t...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-015-1483-7
更新日期：2015-12-01 00:00:00
abstract：:Development of highly efficient anode is critical for enhancing the power output of microbial fuel cells (MFCs). The aim of this work is to investigate whether modification of carbon paper (CP) anode with graphene (GR) via layer-by-layer assembly technique is an effective approach to promote the electricity generation...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-014-1148-y
更新日期：2014-09-01 00:00:00
abstract：:A new method for immobilization of acetylcholinesterase (AChE) to alginate gel beads by activating the carbonyl groups of alginate using carbodiimide coupling agent has been successfully developed. Maximum reaction rate (V (max)) and Michaelis-Menten constant (K (m)) were determined for the free and binary immobilized...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-006-0106-8
更新日期：2007-03-01 00:00:00
abstract：:The hydrolase (Thermobifida fusca hydrolase; TfH) from T. fusca was produced in Escherichia coli as fusion protein using the OmpA leader sequence and a His(6) tag. Productivity could be raised more than 100-fold. Both batch and fed-batch cultivations yield comparable cell specific productivities whereas volumetric pro...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-006-0069-9
更新日期：2006-08-01 00:00:00
abstract：:Membrane bioreactors (MBR) are being increasingly used for wastewater treatment. Mathematical modeling of MBR systems plays a key role in order to better explain their characteristics. Several MBR models have been presented in the literature focusing on different aspects: biological models, models which include solubl...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-012-0806-1
更新日期：2013-04-01 00:00:00
abstract：:A carbon membrane-aerated biofilm reactor (CMABR) was developed to treat synthetic wastewater. Such membrane exhibited a high degree of adhesion and good permeability. Continuous experiments showed that COD and NH4(+)-N removal efficiency were 90 +/- 2 and 92 +/- 4% at removal rates of 35.6 +/- 3.8 g COD/m2 per day an...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-007-0116-1
更新日期：2007-07-01 00:00:00
abstract：:In this study, a new-generation subsurface upflow wetland (SUW) system packed with the unique sorption media was introduced for nutrient removal. To explore the interface between hydraulic and environmental performance, a tracer study was carried out in concert with a transport model to collectively provide hydraulic ...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-011-0578-z
更新日期：2012-03-01 00:00:00
abstract：:Determination of hydrogen peroxide (H2O2) has become essential in pharmaceutical, biological, clinical and environmental studies. The conventional detection methods of H2O2 such as colourimetry, titration, chromatography, spectrophotometry, fluorimetry, chemiluminescence have limited success, due to their poor selecti...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章,评审
doi：10.1007/s00449-017-1878-8
更新日期：2018-03-01 00:00:00
abstract：:Commercial lipase from Thermomyces lanuginosus has been immobilized on glutaraldehyde-activated rice husk particles via covalent attachment. It was reached maximum immobilized protein concentration of 27.5 ± 1.8 mg g-1 of dry support using the initial protein loading of 40 mg g-1 of support. The immobilized biocatalys...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-018-1929-9
更新日期：2018-07-01 00:00:00
abstract：:The aim of this study is to investigate the effect of the N/P ratio on biomass growth with the simultaneous removal of nutrients from municipal wastewaters. An optical panel photobioreactor is employed for this investigation because it provides a uniform light distribution within the reactor, which enhances the effici...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-014-1317-z
更新日期：2015-04-01 00:00:00
abstract：:The effectiveness of coil UV reactor series for the online sterilization of cheese whey was compared to those of the single conventional and coil reactors at various flow rates (5-70 mL/min). The residence time varied from 168 to 12 min and from 48 to 24 min for the single and the series reactors, respectively. Hundre...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-006-0076-x
更新日期：2006-10-01 00:00:00
abstract：:The paper describes a recombinant Schneider 2 (rS2) cell culture and protein expression in a bioreactor. S2 cells were transfected with a plasmid containing a fusion protein (human mu opioid receptor, hMOR, and green fluorescent protein, EGFP) under the control of inducible metallothionein promoter. A bioprocess in a ...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-005-0033-0
更新日期：2006-04-01 00:00:00
abstract：:Laccases are versatile oxidases that are capable of decolorizing various synthetic dyes. Recombinant Bacillus amyloliquefaciens laccase was immobilized as magnetic cross-linked enzyme aggregates (M-CLEAs) for application in dye decolorization. Several parameters influencing the activity recovery were evaluated during ...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-020-02481-8
更新日期：2020-11-27 00:00:00
abstract：:Horseradish peroxidase (HRP) was immobilized on the polyaniline (PANI) grafted polyacrylonitrile (PAN) films. The maximum HRP immobilization capacity of the PAN-g-PANI-3 film was 221 μg/cm(2). The HRP-immobilized PAN-g-PANI-3 film retained 79 % of the activity of the same quantity free enzyme. The HRP-immobilized PAN-...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-012-0724-2
更新日期：2012-10-01 00:00:00
abstract：:In this study, a microbial consortium from an acid-treated rumen fluid was used to improve the yields of H2 production from paper residues in batch reactors. The anaerobic batch reactors, which contained paper and cellulose, were operated under three conditions: (1) 0.5 g paper/L, (2) 2 g paper/L, and (3) 4 g paper/L....
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-016-1663-0
更新日期：2016-12-01 00:00:00
abstract：:A strain designated M866, producing kojic acid with a high yield, was obtained by combining induced mutation using ion beam implantation and ethyl methane sulfonate treatment of a wild type strain of Aspergillus oryzae B008. The amount of kojic acid produced by the strain M866 in a shaking flask was 40.2 g/L from 100 ...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-013-1081-5
更新日期：2014-06-01 00:00:00
abstract：:Penicillin G acylase (PGA) from Kluyvera citrophila immobilized on Amberzyml was used for enantioselective hydrolysis of N-phenylacetylated-DL-tert-leucine (N-Phac-DL-Tle) to produce L-tert-leucine (L-Tle). The effects of various organic cosolvents on hydrolysis of N-Phac-DL-Tle have been investigated in aqueous-cosol...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-005-0027-y
更新日期：2006-04-01 00:00:00
abstract：:L-Lysine is an essential amino acid that can be produced by chemical processes from fossil raw materials, as well as by microbial fermentation, the latter being a more efficient and environmentally friendly procedure. In this work, the production process of L-lysine-HCl is studied using a systematic approach based on ...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-017-1766-2
更新日期：2017-07-01 00:00:00
abstract：:An alternating pumped sequencing batch biofilm reactor (APSBBR) system was developed to treat small-scale domestic wastewater. This laboratory system had two reactor tanks, Reactor 1 and Reactor 2, with two identical plastic biofilm modules in each reactor. Reactor 1 of the APSBBR had five operational phases--fill, an...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-005-0038-8
更新日期：2006-04-01 00:00:00
abstract：:Industrial grade soluble corn starch was used directly and effectively as the fermentation substrate for microbial exopolysaccharides production. Bacillus subtilis mutant strain NJ308 grew with untreated starch raw material as the sole carbon source. The real-time PCR results demonstrated that up-regulated genes encod...
journal_title：Bioprocess and biosystems engineering
pub_type： 杂志文章
doi：10.1007/s00449-018-1915-2
更新日期：2018-06-01 00:00:00
