Improvement of kojic acid production in Aspergillus oryzae B008 mutant strain and its uses in fermentation of concentrated corn stalk hydrolysate.

Abstract:

:A strain designated M866, producing kojic acid with a high yield, was obtained by combining induced mutation using ion beam implantation and ethyl methane sulfonate treatment of a wild type strain of Aspergillus oryzae B008. The amount of kojic acid produced by the strain M866 in a shaking flask was 40.2 g/L from 100 g/L of glucose, which was 1.7 times higher than that produced by wild strain (23.58 g/L). When the mixture of glucose and xylose was used as carbon source, the resulting kojic acid production was raised with the increasing of glucose ratios in the mixture. With concentrations of glucose at 75 g/L and xylose at 25 g/L mixed in the medium, the production of kojic acid reached 90.8 %, which was slightly lower than with glucose as the sole source of carbon. In addition, the kojic acid fermentation of the concentrated hydrolysate from corn stalk was also investigated in this study, the maximum concentration of kojic acid accumulated at the end of the fermentation was 33.1 g/L and this represents the yield based on reducing sugar consumed and the overall productivity of 0.36 g/g and 0.17 g/L/h, respectively.

journal_name

Bioprocess Biosyst Eng

authors

Yan S,Tang H,Wang S,Xu L,Liu H,Guo Y,Yao J

doi

10.1007/s00449-013-1081-5

subject

Has Abstract

pub_date

2014-06-01 00:00:00

pages

1095-103

issue

6

eissn

1615-7591

issn

1615-7605

journal_volume

37

pub_type

杂志文章
  • Asymmetric synthesis of tert-butyl (3R,5S)-6-chloro-3,5-dihydroxyhexanoate using a self-sufficient biocatalyst based on carbonyl reductase and cofactor co-immobilization.

    abstract::tert-Butyl (3R,5S)-6-chloro-3,5-dihydroxyhexanoate [(3R,5S)-CDHH] is the key chiral intermediate to synthesize the side chain of the lipid-lowering drug rosuvastatin. Carbonyl reductases showed excellent activity for the biosynthesis of (3R,5S)-CDHH. The requirement of cofactor NADH/NADPH leads to high cost for the in...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-019-02201-x

    authors: Zhang XJ,Wang WZ,Zhou R,Liu ZQ,Zheng YG

    更新日期:2020-01-01 00:00:00

  • Characterization of a commercial cellulase for hydrolysis of agroindustrial substrates.

    abstract::This work is focused on the characterization of a commercial cellulase in terms of optimum pH and temperature, stability to pH and temperature and affinity of this enzyme to several substrates, determining the Michaelis-Menten parameters. Maximum activity of cellulase was obtained for the temperature range from 40 to ...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-012-0710-8

    authors: Balsan G,Astolfi V,Benazzi T,Meireles MA,Maugeri F,Di Luccio M,Dal Prá V,Mossi AJ,Treichel H,Mazutti MA

    更新日期:2012-09-01 00:00:00

  • Characterization of Pb2+ biosorption from aqueous solution by Rhodotorula glutinis.

    abstract::The yeast Rhodotorula glutinis was examined for its ability to remove Pb(2+) from aqueous solution. Within 10 min of contact, Pb(2+) sorption reached nearly 80% of the total Pb(2+) sorption. The optimum initial pH value for removal of Pb(2+ )was 4.5-5.0. The percentage sorption increased steeply with the biomass conce...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-002-0315-8

    authors: Cho DH,Kim EY

    更新日期:2003-03-01 00:00:00

  • Phospholipase D engineering for improving the biocatalytic synthesis of phosphatidylserine.

    abstract::Phosphatidylserine is widely used in food, health, chemical and pharmaceutical industries. The phospholipase D-mediated green synthesis of phosphatidylserine has attracted substantial attention in recent years. In this study, the phospholipase D was heterologously expressed in Bacillus subtilis, Pichia pastoris, and C...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-019-02116-7

    authors: Hou HJ,Gong JS,Dong YX,Qin J,Li H,Li H,Lu ZM,Zhang XM,Xu ZH,Shi JS

    更新日期:2019-07-01 00:00:00

  • Effects of dissolved oxygen and pH levels on weissellin A production by Weissella paramesenteroides DX in fermentation.

    abstract::Experiments carried out with the dissolved oxygen tension (DOT) maintained during fermentation at 0, 10, 50, 70 and 100% showed a direct effect of the dissolved oxygen levels on weissellin A production with no correlative increase on biomass. An estimate of the yield of weissellin A per gram biomass revealed the 50% D...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-012-0689-1

    authors: Papagianni M

    更新日期:2012-08-01 00:00:00

  • Plasmid DNA primary recovery from E. coli lysates by depth bed microfiltration.

    abstract::Recently, several studies have been published on the application of plasmid DNA (pDNA) in gene therapy and vaccine production. The bioprocess to obtain pDNA involves the steps of fermentation, primary recovery, secondary recovery and final purification. The pDNA primary recovery, which is the key step to the rest of t...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-015-1351-5

    authors: Padilla-Zamudio A,Guerrero-Germán P,Tejeda-Mansir A

    更新日期:2015-06-01 00:00:00

  • Biohydrogen production in an AFBR using sugarcane molasses.

    abstract::This study evaluated an anaerobic fluidized bed reactor to produce hydrogen from sugarcane molasses of 25 g-COD L-1. The reactor of 1.2 L working volume contained shredded tires as support material. The inoculum was sludge obtained in a UASB reactor of a sewage treatment plant. The AFBR was operated at hydraulic reten...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-020-02443-0

    authors: Chaves TC,Gois GNSB,Peiter FS,Vich DV,de Amorim ELC

    更新日期:2020-09-26 00:00:00

  • Magneto-controlled bioelectronics for the antigen-antibody interaction based on magnetic-core/gold-shell nanoparticles functionalized biomimetic interface.

    abstract::A new protein assay system for the antigen-antibody interaction was developed by immobilization of carcinoembryonic antibody (anti-CEA) onto magnetic-core/gold-shell nanoparticles-functionalized biomimetic interface on multiporous polythionine modified magnetic carbon paste electrodes (MCPE). Differential pulse voltam...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-007-0145-9

    authors: Tang D,Yuan R,Chai Y

    更新日期:2008-02-01 00:00:00

  • Immobilized L-aspartate ammonia-lyase from Bacillus sp. YM55-1 as biocatalyst for highly concentrated L-aspartate synthesis.

    abstract::L-aspartate ammonia-lyase from Bacillus sp. YM55-1 (AspB, EC 4.3.1.1) catalyzes the reversible conversion of L-aspartate (Asp) into fumarate and ammonia with a high specific activity toward the substrate. AspB was expressed in Escherichia coli and partially purified by heat precipitation and saturation with ammonium s...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-012-0732-2

    authors: Cárdenas-Fernández M,López C,Alvaro G,López-Santín J

    更新日期:2012-10-01 00:00:00

  • Application of reverse micelle extraction process for amylase recovery using response surface methodology.

    abstract::The effect of different process variables of reverse micelle extraction process like pH, addition of surfactant (AOT) concentration and potassium chloride (KCl) concentration on amylase recovery has been studied and analysed. Solid-state fermentation was used for the production of amylase enzyme. Response surface meth...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-007-0172-6

    authors: Bera MB,Panesar PS,Panesar R,Singh B

    更新日期:2008-06-01 00:00:00

  • The effect of discontinuous airlift mixing in outdoor flat panel photobioreactors on growth of Scenedesmus obliquus.

    abstract::Discontinuous airlift mixing was realized by injecting pressured air at time intervals with a frequency between 0.033 and 0.25 Hz (at 80 kPa; i.e., every 4-30 s; valve opening time 800 ms) into outdoor flat panel photobioreactors ([Formula: see text]). This caused a flow velocity between 2 and 20 cm s(-1) of the cultu...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-013-0939-x

    authors: Leupold M,Hindersin S,Kerner M,Hanelt D

    更新日期:2013-11-01 00:00:00

  • A general inhibition kinetics model for ethanol production using a novel carbon source: sodium gluconate.

    abstract::In this study, sodium gluconate was applied as a novel carbon source for the fuel ethanol production using an engineered Escherichia coli strain KO11 in batch fermentations. Ethanol and acetic acid were produced as two major products as well as small amount of lactic acid during the fermentation. Compared to the conve...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-013-0938-y

    authors: Wu W,Fan Z

    更新日期:2013-11-01 00:00:00

  • Poly(styrene-divinylbenzene) beads surface functionalized with di-block polymer grafting and multi-modal ligand attachment: performance of reversibly immobilized lipase in ester synthesis.

    abstract::Fibrous poly(styrene-b-glycidylmethacrylate) brushes were grafted on poly(styrene-divinylbenzene) (P(S-DVB)) beads using surface-initiated atom transfer radical polymerization. Tetraethyldiethylenetriamine (TEDETA) ligand was incorporated on P(GMA) block. The ligand attached beads were used for reversible immobilizati...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-011-0523-1

    authors: Bayramoglu G,Karagoz B,Altintas B,Arica MY,Bicak N

    更新日期:2011-08-01 00:00:00

  • Recovery of electric energy from formate by using a recombinant strain of Escherichia coli.

    abstract::Recombinant Escherichia coli cells were applied for the recovery of electric energy from formate. Initially, the fdh gene, which encodes formate dehydrogenase (FDH) of Mycobacterium vaccae, was introduced into E. coli cells to allow efficient degradation of formate. The constructed microbial fuel cell (MFC) with E. co...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-014-1179-4

    authors: Ojima Y,Kawata T,Matsuo N,Nishinoue Y,Taya M

    更新日期:2014-10-01 00:00:00

  • Effect of the N/P ratio on biomass productivity and nutrient removal from municipal wastewater.

    abstract::The aim of this study is to investigate the effect of the N/P ratio on biomass growth with the simultaneous removal of nutrients from municipal wastewaters. An optical panel photobioreactor is employed for this investigation because it provides a uniform light distribution within the reactor, which enhances the effici...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-014-1317-z

    authors: Choi HJ,Lee SM

    更新日期:2015-04-01 00:00:00

  • Effect of pH on the stability of Pleurotus eryngii versatile peroxidase during heterologous production in Emericella nidulans.

    abstract::Complementary DNA (cDNA) encoding the new versatile peroxidase from the ligninolytic basidiomycete Pleurotus eryngii has been expressed in the ascomycete Emericella nidulans. In recombinant E. nidulans cultures, the pH reached values as high as 8.3, correlating with a sharp decrease in peroxidase activity. Peroxidase ...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-004-0365-1

    authors: Lú-Chau TA,Ruiz-Dueñas FJ,Camarero S,Feijoo G,Martínez MJ,Lema JM,Martínez AT

    更新日期:2004-10-01 00:00:00

  • Surfactant removal from wastewater using photo-cathode microbial fuel cell and laterite-based hybrid treatment system.

    abstract::Sodium dodecyl sulfate (SDS) is a widely used anionic surfactant, which finds its way to the receiving water body due to the incapability of conventional wastewater treatment systems to completely remove it. A hybrid treatment system consisting of upflow microbial fuel cell (MFC) with titanium dioxide (TiO2) as a phot...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-020-02396-4

    authors: Sathe SM,Bhowmick GD,Dubey BK,Ghangrekar MM

    更新日期:2020-11-01 00:00:00

  • Measuring the adhesion limit of fibronectin for fibroblasts with a narrow-gap rotational rheometer.

    abstract::We study the adhesion limit of 3T6 fibroblasts, cultured in Dulbecco's modified Eagle's medium with 10% fetal bovine serum at 37 °C and 5% CO2, with a narrow-gap rotational rheometer in the parallel-disk configuration. Reducing the uncertainty in gap width to about 1 µm allows studying the cells at narrow gaps, which ...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-017-1868-x

    authors: Dakhil H,Do H,Hübner H,Wierschem A

    更新日期:2018-03-01 00:00:00

  • Impact of operating conditions on performance of a novel gas double-dynamic solid-state fermentation bioreactor (GDSFB).

    abstract::A self-designed novel solid-state fermentation (SSF) bioreactor named "gas double-dynamic solid-state fermentation bioreactor (GDSFB)" showed great success in processes for the production of several valuable products. For the present study, a simple GDSFB (2 L in volume) was designed to investigate the impact of exhau...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-013-0950-2

    authors: Chen H,Li Y,Xu F

    更新日期:2013-11-01 00:00:00

  • Production of lipase by high cell density fed-batch culture of Candida cylindracea.

    abstract::Candida cylindracea NRRL Y-17506 was grown to produce extracellular lipase from oleic acid as a carbon source. Through flask cultures, it was found that the optimum initial oleic acid concentration for cell growth was 20 g l(-1). However, high initial concentrations of oleic acid up to 50 g l(-1) were not inhibitory. ...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-006-0058-z

    authors: Kim BS,Hou CT

    更新日期:2006-06-01 00:00:00

  • Benzene vapor treatment using a two-phase partitioning bioscrubber: an improved steady-state protocol to enhance long-term operation.

    abstract::The performance and stability of a two-phase partitioning bioscrubber (TPPB) containing 33% (vol.) n-hexadecane as an immiscible phase was investigated during 30 days of continuous gaseous benzene treatment. Elimination capacities of 141 +/- 12 g/m(3) h were achieved by Achromobacter xylosoxidans Y234 while maintainin...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-006-0071-2

    authors: Nielsen DR,Sask KN,McLellan PJ,Daugulis AJ

    更新日期:2006-10-01 00:00:00

  • Changes in morphology of Rhizopus chinensis in submerged fermentation and their effect on production of mycelium-bound lipase.

    abstract::In order to control suitable mycelium morphology to obtain high lipase productivity by Rhizopus chinensis in submerged fermentation, the effects of fungal morphology on the lipase production by this strain both in shake flask and fermentor were investigated. Different inoculum level and shear stress were used to devel...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-008-0259-8

    authors: Teng Y,Xu Y,Wang D

    更新日期:2009-04-01 00:00:00

  • Enhancement of extracellular pullulanase production from recombinant Escherichia coli by combined strategy involving auto-induction and temperature control.

    abstract::Pullulanase was extracellularly produced with an engineered Escherichia coli with a combined strategy. When auto-induction instead of isopropyl β-D-1-thiogalactopyranoside (IPTG) induction method was implemented, we observed increased extracellular activity (4.2 U ml(-1)) and cell biomass (7.95 g DCW l(-1)). Subsequen...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-013-1026-z

    authors: Chen WB,Nie Y,Xu Y,Xiao R

    更新日期:2014-04-01 00:00:00

  • Covalent immobilization of Kluyveromyces fragilis β-galactosidase on magnetic nanosized epoxy support for synthesis of galacto-oligosaccharide.

    abstract::The novel magnetic nanobeads with epoxy groups on the surface were prepared from glycidyl methacrylate (GMA), ethylene glycol dimethacrylate (EGDMA) and hydroxyethyl methacrylate (HEMA) via emulsifier-free emulsion polymerisation, and they were characterized by scanning electron microscopy and vibrating sample magneto...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-012-0716-2

    authors: Liu H,Liu J,Tan B,Zhou F,Qin Y,Yang R

    更新日期:2012-10-01 00:00:00

  • Red yeast rice fermentation with Bacillus subtilis B2 under blue light-emitting diodes increases antioxidant secondary products (Manuscript ID: BPBSE-18-0387).

    abstract::Light and bacteria can be used in combination to enhance secondary metabolite production during fermentation. Red yeast rice powder (RYRP) was inoculated with Bacillus subtilis (B2) isolated from freshwater seafood and incubated under light-emitting diodes (LEDs) of different colors (blue, green, red, white), fluoresc...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-018-2056-3

    authors: Elumalai P,Park YJ,Cho M,Shea PJ,Oh BT

    更新日期:2019-04-01 00:00:00

  • Effect of pH on the metabolic flux of Klebsiella oxytoca producing 2,3-butanediol in continuous cultures at different dilution rates.

    abstract::The efficiency of the bioconversion process and the achievable end-product concentration decides the economic feasibility of microbial 2,3-butanediol (2,3-BDO) production. In 2,3-BDO production, optimization of culture condition is required for cell growth and metabolism. Also, the pH is an important factor that influ...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-013-0932-4

    authors: Park C,Lu M,Yun S,Park K,Lee J

    更新日期:2013-06-01 00:00:00

  • A systematic correlation analysis of carotenoids, chlorophyll, non-pigmented cell mass, and cell number for the blueprint of Dunaliella salina culture in a photobioreactor.

    abstract::Microalgal carotenoids are attractive health ingredients, but their production should be optimized to improve cost-effectiveness. Understanding cellular physiology centered on carotenoid synthesis is the prerequisite for this work. Therefore, systematic correlation analyses were conducted among chlorophyll, carotenoid...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-018-1957-5

    authors: Song HG,Byeon SY,Chung GY,Jung SM,Choi JI,Shin HS

    更新日期:2018-09-01 00:00:00

  • A tracer study for assessing the interactions between hydraulic retention time and transport processes in a wetland system for nutrient removal.

    abstract::In this study, a new-generation subsurface upflow wetland (SUW) system packed with the unique sorption media was introduced for nutrient removal. To explore the interface between hydraulic and environmental performance, a tracer study was carried out in concert with a transport model to collectively provide hydraulic ...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-011-0578-z

    authors: Chang NB,Xuan Z,Wanielista MP

    更新日期:2012-03-01 00:00:00

  • Modelling the growth kinetics of Kocuria marina DAGII as a function of single and binary substrate during batch production of β-Cryptoxanthin.

    abstract::In the present investigation, growth kinetics of Kocuria marina DAGII during batch production of β-Cryptoxanthin (β-CRX) was studied by considering the effect of glucose and maltose as a single and binary substrate. The importance of mixed substrate over single substrate has been emphasised in the present study. Diffe...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-016-1678-6

    authors: Mitra R,Chaudhuri S,Dutta D

    更新日期:2017-01-01 00:00:00

  • Quantitative metabolic flux analysis revealed uneconomical utilization of ATP and NADPH in Acremonium chrysogenum fed with soybean oil.

    abstract::A metabolic network was constructed for the Acremonium chrysogenum cultivation fed with soybean oil. Metabolic flux analysis indicated that the shift from exponential growth to rapid cephalosporin C (CPC) formation was accompanied by 1.63- and 5-fold carbon flux enlargement in TCA cycle and glyoxylate by-pass, respect...

    journal_title:Bioprocess and biosystems engineering

    pub_type: 杂志文章

    doi:10.1007/s00449-010-0439-1

    authors: Li J,Yang Y,Chu J,Huang M,Li L,Zhang X,Wang Y,Zhuang Y,Zhang S

    更新日期:2010-11-01 00:00:00