Abstract:
:The purpose of this study was to develop the correlation of cycle parameters between a laboratory and a production freeze-dryer. With the established correlation, key cycle parameters obtained using a laboratory dryer may be converted to those for a production dryer with minimal experimental efforts. In order to develop the correlation, it was important to consider the contributions from the following freeze-drying components: (1) the dryer, (2) the vial, and (3) the formulation. The critical parameters for the dryer are the shelf heat transfer coefficient and shelf surface radiation emissivity. The critical parameters for the vial are the vial bottom heat transfer coefficients (the contact parameter Kcs and separation distance lv), and vial top heat transfer coefficient. The critical parameter of the formulation is the dry layer mass transfer coefficient. The above heat and mass transfer coefficients were determined by freeze-drying experiments in conjunction with mathematical modeling. With the obtained heat and mass transfer coefficients, the maximum product temperature, Tbmax, during primary drying was simulated using a primary drying subroutine as a function of the shelf temperature and chamber pressure. The required shelf temperature and chamber pressure, in order to perform a successful cycle run without product collapse, were then simulated based on the resulting values of Tbmax. The established correlation approach was demonstrated by the primary drying of the model formulation 5% mannitol solution. The cycle runs were performed using a LyoStar dryer as the laboratory dryer and a BOC Edwards dryer as the production dryer. The determined normalized dried layer mass transfer resistance for 5% mannitol is expressed as RpN=0.7313+17.19l, where l is the receding dry layer thickness. After demonstrating the correlation approach using the model formulation 5% mannitol, a practical comparison study was performed for the actual product, the lactate dehydrogenase (LDH) formulation. The determined normalized dried layer mass transfer resistance for the LDH formulation is expressed as RpN=4.344+10.85l. The operational templates Tbmax and primary drying time were also generated by simulation. The cycle run for the LDH formulation using the Edwards production dryer verified that the cycle developed in a laboratory freeze-dryer was transferable at the production scale.
journal_name
Int J Pharmjournal_title
International journal of pharmaceuticsauthors
Kuu WY,Hardwick LM,Akers MJdoi
10.1016/j.ijpharm.2005.06.022keywords:
subject
Has Abstractpub_date
2005-09-30 00:00:00pages
56-67issue
1-2eissn
0378-5173issn
1873-3476pii
S0378-5173(05)00450-3journal_volume
302pub_type
杂志文章abstract::Spray-freezing into liquid (SFL) is a novel particle engineering technology where a feed solution containing an active pharmaceutical ingredient (API) and pharmaceutical excipient(s) is atomized beneath the surface of a cryogenic liquid, such as liquid nitrogen. Intense atomization results from the impingement that oc...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/s0378-5173(02)00154-0
更新日期:2002-08-21 00:00:00
abstract::The sublingual administration of nifedipine (NIF) is currently used in clinical practice. The sublingual administration of NIF solid dispersions (SD), by using a suitable dispenser, appears an interesting approach in the treatment of moderate and severe hypertensive emergencies. With this aim nine SD made of NIF and a...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/s0378-5173(02)00173-4
更新日期:2002-08-21 00:00:00
abstract::As the number of pharmaceutical candidate compounds increases, so does the need for development workflow that is capable of handling more compounds in shorter times. In this paper, the establishment of a high-throughput automated powder compatibility testing system is reported. The integrated robotic system automatica...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2007.12.002
更新日期:2008-05-01 00:00:00
abstract::Polymeric micelles (PM) based on poly(ethylene glycol)-b-poly(N-2-benzoyloxypropyl methacrylamide) (mPEG-b-p(HPMA-Bz)) loaded with paclitaxel (PTX-PM) have shown promising results in overcoming the suboptimal efficacy/toxicity profile of paclitaxel. To get insight into the stability of PTX-PM formulations upon storage...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2020.119409
更新日期:2020-06-30 00:00:00
abstract::High molecular weight polyethylene oxides (PEOs) have recently been proposed as an alternative to hydroxypropylmethylcellulose (HPMC) in controlled release matrix tablets. In this study, we compared the performance of PEO and HPMC polymers when employed in the Geomatrix technology, a versatile, well-known method to ac...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/s0378-5173(99)00402-0
更新日期:2000-02-15 00:00:00
abstract::In this study, the potential of lecithin/chitosan nanoparticles (NPs) as a mucoadhesive colloidal nanosystem for transmucosal delivery of melatonin was investigated. The size, zeta potential and melatonin loading of the lecithin/chitosan NPs were investigated as a function of lecithin type (Lipoid S45, S75 and S100) a...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2009.07.001
更新日期:2009-11-03 00:00:00
abstract::Many studies have demonstrated the uptake mechanisms of various nanoparticle delivery systems with different physicochemical properties in different cells. In this study, we report for the first time the preparation and characterization of teniposide (VM-26) poly(D,L-lactide-co-glycolide) (PLGA) nanoparticles (NPs) an...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2012.07.050
更新日期:2012-10-15 00:00:00
abstract::The human body harbours a large variety of microbial communities. It is already well-known that these communities play an important role in human health. Therefore, microbial imbalances can be responsible for several health disorders by different mechanisms. In recent years, probiotic bacteria have been increasingly a...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2020.119755
更新日期:2020-10-15 00:00:00
abstract::Personalized medicine is a challenging research area in paediatric treatments. Elaborating new paediatric formulations when no commercial forms are available is a common practice in pharmacy laboratories; among these, oral liquid formulations are the most common. But due to the lack of specialized equipment, frequentl...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2013.11.006
更新日期:2014-01-02 00:00:00
abstract::Block-polymer nanoparticles are now well-known candidates for the delivery of various non-soluble drugs to cells. The release of drugs from these nanoparticles is a major concern related to their efficiency as nanovectors and is still not completely deciphered. Various processes have been identified, depending of both...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2015.09.032
更新日期:2015-11-30 00:00:00
abstract::The mechanical characteristics of non-ionic bilayer membranes composed of sorbitan monostearate, cholesterol and poly-24-oxyethylene cholesteryl were studied by measuring the modulus of surface elasticity (mu), a measure of membrane strength, as a function of cholesterol content and temperature. The modulus of surface...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2005.05.009
更新日期:2005-08-26 00:00:00
abstract::This study describes the effect of coating temperature on the performance of mechanical particle coating using ethylcellulose, which was done to produce controlled-release particles (diameters less than 100 μm) with different release rates. First, theophylline crystals were spheronized using a mechanical powder proces...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2018.11.061
更新日期:2019-01-10 00:00:00
abstract::The objective of this study is to evaluate the biodistribution characteristics of liposomes surface-modified with the mixture of polyethylene glycol (PEG) and polyvinyl alcohol (PVA) as a drug carrier for passive targeting of drugs. The liposomes (egg phosphatidylcholine:cholesterol=55:40, molar ratio) modified with b...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2008.04.004
更新日期:2008-07-09 00:00:00
abstract::The results obtained previously by Ruckenstein and Shulgin [Int. J. Pharm. 258 (2003a) 193; Int. J. Pharm. 260 (2003b) 283] via the fluctuation theory of solutions regarding the solubility of drugs in binary aqueous mixed solvents were extended in the present paper to multicomponent aqueous solvents. The multicomponen...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2003.08.006
更新日期:2003-11-28 00:00:00
abstract::The purpose of this study was to prepare solid SMEDDS (sSMEDDS) particles produced by spray-drying using maltodextrin (MD), hypromellose (HPMC), and a combination of the two as a solid carrier. Naproxen (NPX) as the model drug was dissolved (at 6% concentration) or partially suspended (at 18% concentration) in a liqui...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2015.03.015
更新日期:2015-05-15 00:00:00
abstract::In spite of the high incidence of breast cancer worldwide, there are few strategies for its chemoprevention, and they have limited adherence mainly due to their serious adverse effects. As a new approach for local breast cancer chemoprevention, we developed and optimized microemulsions for topical delivery of celecoxi...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2019.02.011
更新日期:2019-04-05 00:00:00
abstract::Corticosteroids have long been used to treat intraocular inflammation by intravitreal injection. We describe dexamethasone loaded poly-DL-lactide-co-glycolide (PLGA) microparticles that were fabricated by thermally induced phase separation (TIPS). The dexamethasone loaded microparticles were evaluated using a two-comp...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2017.02.047
更新日期:2017-04-30 00:00:00
abstract::Paclitaxel is widely used to treat several types of solid tumors. The commercially available paclitaxel formulation contains Cremophor/ethanol as solubilizers. This study evaluated the effects of D-alpha-tocopheryl polyethylene glycol 400 succinate (TPGS 400) on the oral absorption of paclitaxel in mice. Mice were giv...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2008.04.013
更新日期:2008-07-09 00:00:00
abstract::Oral absorption of lopinavir (LPV) is limited due to P-glycoprotein (P-gp) and multidrug resistance-associated protein2 (MRP2) mediated efflux by intestinal epithelial cells. Moreover, LPV is extensively metabolized by CYP3A4 enzymes. In the present study, dipeptide prodrug approach was employed to circumvent efflux p...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2014.09.035
更新日期:2014-12-10 00:00:00
abstract::Blend uniformity analysis (BUA) is a routine and highly regulated aspect of pharmaceutical production. In most instances, it involves quantitative determination of individual components of a blend in order to ascertain the mixture ratio. This approach often entails the use of costly and sophisticated instrumentation a...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2012.07.073
更新日期:2012-11-15 00:00:00
abstract::The inactivation of catalase during spray-drying over a range of outlet gas temperatures could be closely represented by the Arrhenius equation. From this an activation energy for damage to the catalase could be calculated. The close fit to Arrhenius suggests that the thermally-induced part of inactivation of the cata...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2015.04.078
更新日期:2015-07-15 00:00:00
abstract::The influence of temperature, pH, keratinase concentration, substrate concentration and incubation time on the soluble proteins released by a new keratinase from Doratomyces microsporus was studied with a second-order experimental design. Only 15 or 18 spectrophotometric analyses were required to determine the optimal...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/s0378-5173(01)00749-9
更新日期:2001-08-14 00:00:00
abstract::Changes in the rheological properties of four o/w cream formulations differing in the combination of surfactants were studied. The non-ionic surfactants used were soybean derivatives, polyethylene glycol 10 and 25 soya sterol, and sorbitol derivatives, sorbitan monooleate and trioleate. Combinations of the soybean and...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/s0378-5173(01)00675-5
更新日期:2001-06-19 00:00:00
abstract::Melanoma is resistant to chemotherapeutics with poor prognosis and high potential of metastasis. Photodynamic therapy (PDT) represents a localized therapeutic modality, as cytotoxicity occurs when light activates photosensitizer (PS) at the tumour site. The aim of this study is dermal delivery of a high molecular weig...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2018.06.057
更新日期:2018-09-05 00:00:00
abstract::Over the last few decades, hot melt extrusion (HME) has emerged as a successful technology for a broad spectrum of applications in the pharmaceutical industry. As indicated by multiple publications and patents, HME is mainly used for the enhancement of solubility and bioavailability of poorly soluble drugs. This revie...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章,评审
doi:10.1016/j.ijpharm.2017.10.056
更新日期:2018-01-15 00:00:00
abstract::Primary objective of this investigation was to delineate the differential impact of efflux transporters P-glycoprotein (P-gp/Abcb1) and breast cancer resistance protein (Bcrp1/Abcg2) on brain disposition and plasma pharmacokinetics of pazopanib. In addition, this research investigated whether inhibition of these efflu...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2012.05.038
更新日期:2012-10-15 00:00:00
abstract::This paper first provides that Chinese yam polysaccharide (CYP) is encapsulated by PLGA using a double emulsion solvent evaporation method and aims to screen the optimal preparation of CYP-PLGA nanoparticles (CYPP) using response surface methodology (RSM). The volume ratio of the internal water phase to the organic ph...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2016.06.130
更新日期:2016-09-10 00:00:00
abstract::Protein aggregates have been discussed for a long time as a potential risk factor for immunogenicity in patients. Meanwhile, many research groups have investigated the immunogenicity of differently produced aggregates using in vitro or in vivo models. Despite all knowledge gained in these studies still little is known...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章,评审
doi:10.1016/j.ijpharm.2019.01.015
更新日期:2019-03-25 00:00:00
abstract::The static electricity generated by triggering a piezo gas igniter is shown to cause electroporation of the skin to deliver antigen. Mice were immunized with chicken albumin by electroporation using a piezo gas igniter and in another experiment, the gas igniter was replaced by a power supply. In both the groups identi...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/s0378-5173(01)00608-1
更新日期:2001-04-17 00:00:00
abstract::Sticking is a serious problem during the manufacturing process of tablets. In order to prevent this, we used alloying techniques to prepare metal hardening (MH) and electron beam processing infinite product (EIP) punches with rougher asperity of surfaces than a hard chrome plated (HCr) punch. This study evaluated the ...
journal_title:International journal of pharmaceutics
pub_type: 杂志文章
doi:10.1016/j.ijpharm.2012.12.006
更新日期:2013-01-30 00:00:00