Abstract:
:The sufficient provision of oxygen is mandatory for enzymatic oxidations in aqueous solution, however, in process optimization this still is a bottleneck that cannot be overcome with the established methods of macrobubble aeration. Providing higher mass transfer performance through microbubble aerators, inefficient aeration can be overcome or improved. Investigating the mass transport performance in a model protein solution, the microbubble aeration results in higher kL a values related to the applied airstream in comparison with macrobubble aeration. Comparing the aerators at identical kL a of 160 and 60 1/h, the microbubble aeration is resulting in 25 and 44 times enhanced gas utility compared with aeration with macrobubbles. To prove the feasibility of microbubbles in biocatalysis, the productivity of a glucose oxidase catalyzed biotransformation is compared with macrobubble aeration as well as the gas-saving potential. In contrast to the expectation that the same productivities are achieved at identically applied kL a, microbubble aeration increased the gluconic acid productivity by 32% and resulted in 41.6 times higher oxygen utilization. The observed advantages of microbubble aeration are based on the large volume-specific interfacial area combined with a prolonged residence time, which results in a high mass transfer performance, less enzyme deactivation by foam formation, and reduced gas consumption. This makes microbubble aerators favorable for application in biocatalysis.
journal_name
Biotechnol Bioengjournal_title
Biotechnology and bioengineeringauthors
Thomas B,Ohde D,Matthes S,Engelmann C,Bubenheim P,Terasaka K,Schlüter M,Liese Adoi
10.1002/bit.27556subject
Has Abstractpub_date
2021-01-01 00:00:00pages
130-141issue
1eissn
0006-3592issn
1097-0290journal_volume
118pub_type
杂志文章abstract::Microfluidic bioreactors have been shown valuable for various cellular applications. The use of micro-wells/grooves bioreactors, in which micro-topographical features are used to protect sensitive cells from the detrimental effects of fluidic shear stress, is a promising approach to culture sensitive cells in these pe...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22153
更新日期:2009-03-01 00:00:00
abstract::Saccharomyces cerevisiae (yeast) cells were employed as a source of alcohol dehydrogenase in the NAD(+)-to-NADH reaction. The cells were immobilized in calcium alginate monofilament fibers and used in a biological reactor. The alginate could not be heat sterilized since temperatures above 80 degrees C caused the polym...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260360706
更新日期:1990-10-05 00:00:00
abstract::The development of a lentiviral system to deliver genes to specific cell types could improve the safety and the efficacy of gene delivery. Previously, we have developed an efficient method to target lentivectors to specific cells via an antibody-antigen interaction in vitro and in vivo. We report herein a targeted len...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22378
更新日期:2009-09-01 00:00:00
abstract::The secretion of heterologous IgG proteins in the baculovirus-insect cell expression system is accompanied by substantial insoluble immunoglobulin in the infected cells. The accumulation of these insoluble forms suggests a limitation in the processing and secretory pathway of the infected cells. As a result, cytosolic...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:
更新日期:1998-04-20 00:00:00
abstract::The influence of solution Eh on the rate of ferrous iron oxidation by Acidithiobacillus ferrooxidans is characterized. The experimental approach was based on the use of a two-chamber bioelectrochemical cell, which can determine the ferrous iron oxidation rate at controlled potential. Results enabled the formulation of...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10371
更新日期:2002-11-05 00:00:00
abstract::The use of recombinant adenoviral vectors for vaccination and gene therapy requires the development of purification processes that are cost-effective, scalable, and capable of robust host cell DNA clearance. An adenovirus purification process was developed which incorporates selective precipitation of host cell DNA, e...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20406
更新日期:2005-07-05 00:00:00
abstract::Equilibrium isotherms for adsorption of bovine serum albumin (BSA) on a new adsorbent, a strongly basic crosslinked chitosan (Chitopearl 2503), which is hard and is not compressed by pressure in a column, have been presented and compared with diethylaminoethyl (DEAE) Sepharose Fast Flow (hard gel). In Chitopearl 2503,...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260431112
更新日期:1994-05-01 00:00:00
abstract::A key point of protein stability engineering is to identify specific target residues whose mutations can stabilize the protein structure without negatively affecting the function or activity of the protein. Here, we propose a method called RiSLnet (Rapid identification of Smart mutant Library using residue network) to...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.26861
更新日期:2019-02-01 00:00:00
abstract::The bacterial consortium MPD-M, isolated from sediment associated with Colombian mangrove roots, was effective in the treatment of hydrocarbons in water with salinities varying from 0 to 180 g L(-1). Where the salinity of the culture medium surpassed 20 g L(-1), its effectiveness increased when the cells were immobili...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10318
更新日期:2002-07-20 00:00:00
abstract::The clustered regularly interspaced short palindromic repeats (CRISPR) system-associated Cas9 endonuclease is a molecular tool that enables specific sequence editing with high efficiency. In this study, we have explored the use of CRISPR/Cas9 system for the engineering of baculovirus. We have shown that the delivering...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27139
更新日期:2019-11-01 00:00:00
abstract::In glutamic acid fermentation, the molasses feeding policy and time of penicillin addition significantly affected glutamic acid production, and a fuzzy supervisory control system was developed for their quasi-optimal regulation.From the trend of the experimental data, production rules and membership functions of fuzzy...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260440113
更新日期:1994-06-05 00:00:00
abstract::Predicting and improving oxygen transport within bioartificial liver (BAL) devices continues to be an important engineering challenge since oxygen is one of the critical nutrients necessary for maintaining hepatocyte viability and function. Such a computational model would not only help predict outcomes but it would a...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.10531
更新日期:2003-04-05 00:00:00
abstract::A model that was used to describe toxicity from high concentrations of chlorinated aliphatic hydrocarbons (CAHs) on reductively dechlorinating cultures in batch reactors (Sabalowsky and Semprini (in press)) was extended here to simulate observations in continuous flow suspended and attached growth reactors. The reduct...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22822
更新日期:2010-10-15 00:00:00
abstract::A novel endoglucanase gene, celM , was cloned from a thermal spring metagenome. The gene was expressed in Escherichia coli, and the protein was extracted and purified. The protein catalyzed the hydrolysis of amorphous cellulose in a wide range of temperatures, 30-95°C, with optimal activity at 80°C. It was able to tol...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.27668
更新日期:2021-01-06 00:00:00
abstract::The bioconversion of octanoic acid into 2-heptanone by spores of Penicillium roquefortii is performed using a fed-batch technique with pH control by addition of the liquid substrate itself. The early stage of this process takes place with a high bioconversion rate and high yield. These values then decrease as a result...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260440606
更新日期:1994-09-05 00:00:00
abstract::A sequencing batch membrane biofilm reactor (SBMBfR) was developed for simultaneous carbon, nitrogen, and phosphorus removal from wastewater. This reactor was composed of two functional parts: (1) a gas-permeable membrane on which a nitrifying biofilm formed and (2) a bulk solution in which bacteria, mainly denitrifyi...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20887
更新日期:2006-07-05 00:00:00
abstract::A computer-controlled headspace gas chromatograph was used to monitor the progress of ethanol production from both aerobic batch and anaerobic continuous fermentations. Using an automatic, electropneumatic sampling system, aliquots of fermentation headspace gas were injected directly onto the column for quantitative e...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260251103
更新日期:1983-11-01 00:00:00
abstract::Surface plasmon resonance (SPR) technique was used to directly detect an intact form of insect pathogen: the baculovirus, Autographa californica multiple nuclear polyhedrosis virus (AcMNPV). An SPR sensor chip with three bio-functional layers was used to detect the intact AcMNPV: amine-reactive crosslinker with a disu...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20882
更新日期:2006-07-05 00:00:00
abstract::Many sites of environmental concern contain groundwater contaminated with nonaqueous phase liquids (NAPL). In such sites interfacial processes may affect both the equilibrium and kinetic behavior of the system. In particular, insoluble hydrocarbon partitioning and microbial biodegradation of insoluble hydrocarbon are ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(sici)1097-0290(19990520)63:4<401::aid-bit
更新日期:1999-05-20 00:00:00
abstract::A novel reaction system was developed to maximize the catalytic efficiency of chloroperoxidase (CPO, from Caldariomyces fumago) toward the oxidation of hydrocarbons. The reaction system consisted of an organic/aqueous emulsion comprising pure substrate and aqueous buffer supplemented with the surfactant dioctyl sulfos...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20769
更新日期:2006-05-05 00:00:00
abstract::Direct perfusion of 3D tissue engineered constructs is known to enhance osteogenesis, which can be partly attributed to enhanced nutrient and waste transport. In addition flow mediated shear stresses are known to upregulate osteogenic differentiation and mineralization. A quantification of the hydrodynamic environment...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22277
更新日期:2009-06-15 00:00:00
abstract::Screening tests of different marine algae biomas types revealed a high passive biosorptive uptake of lead up to 270 mg Pb/g of biomass in some brown marine algae. Members of the order Fucales perfomed particularly well in this descending sequence: Fucus > Ascophyllum > Sargassum. Although decreasing the swelling of we...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260431102
更新日期:1994-05-01 00:00:00
abstract::CTLA4 is a membrane receptor on cytotoxic T cells whose interaction with the B7 counterreceptor on B cells is important in alloantigen responses. Soluble recombinant human and murine CTLA4 were produced using either Chinese hamster ovary or NS-0 cell lines. Expression vectors were constructed containing the gene codin...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260460502
更新日期:1995-06-05 00:00:00
abstract::A structured kinetic model describing growth, differentiation, and penicillin production in submerged Penicillium chrysogenum fermentations is reported. The filamentous hyphae are divided into four distinct regions on the basis of the activities and structure of hyphal compartments, viz., actively growing (mainly apic...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19960905)51:5<558::AID-BIT
更新日期:1996-09-05 00:00:00
abstract::The high hydrophobicity of polycyclic aromatic hydrocarbons (PAHs) strongly reduces their bioavailability in aged contaminated soils, thus limiting their bioremediation. The biodegradation of PAHs in soils can be enhanced by employing surface-active agents. However, chemical surfactants are often recalcitrant and exer...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.20225
更新日期:2004-10-20 00:00:00
abstract::A new type of liquid emulsion membrane containing reversed micelles for protein extraction is introduced. A three-step extraction mechanism is proposed including solubilization, transportation, and release of the protein. The surfactants Span80 and sodium di(2-ethylhexyl)sulfosuccinate (AOT) are used to stabilize the ...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/(SICI)1097-0290(19970205)53:3<267::AID-BIT
更新日期:1997-02-05 00:00:00
abstract::This reports on the determination of the overall oxygen transfer coefficient in a mechanically agitated vessel using a randomly pulsed dynamic method. This method consists in exciting the system by randomly switching the inlet gas stream with air or nitrogen with an identical volumetric flow rate. A pseudo-random bina...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260370914
更新日期:1991-04-15 00:00:00
abstract::Clostridium formicoaceticum homofermentatively converts lactate to acetate at 37 degrees C and pH 6.6-9.6. However, this fermentation is strongly inhibited by acetic acid at acidic pH. The specific growth rate of this organism decreased from a maximum at pH 7.6 to zero at pH 6.6. This inhibition effect was found to be...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260340807
更新日期:1989-10-20 00:00:00
abstract::Buddleja davidii is a unique biomass that has many attractive agroenergy features, especially its wide range of growth habitat. The anatomical characteristics of B. davidii were investigated before and after ethanol organosolv pretreatment (one of the leading pretreatment technologies) in order to further understand t...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.22884
更新日期:2010-12-01 00:00:00
abstract::In this article, we present the factors which influence the stability of the emulsion forming under the circumstances of the direct extraction of penicillin fermentation broth and the conditions of demulsification. A laboratory method has been developed for testing demulsifiers and a quantitative evaluation of the pro...
journal_title:Biotechnology and bioengineering
pub_type: 杂志文章
doi:10.1002/bit.260400208
更新日期:1992-06-20 00:00:00