Abstract:
:The safety and environmental aspects of a manufacturing process are important due to increased environmental regulations and life quality. In this paper, the concentration of aerosols in the breathing zone of the operator of Electrical Discharge Machining (EDM), a commonly used non traditional manufacturing process is presented. The pattern of aerosol emissions from this process with varying process parameters such as peak current, pulse duration, dielectric flushing pressure and the level of dielectric was evaluated. Further, the HAZOP technique was employed to identify the inherent safety aspects and fire risk of the EDM process under different working conditions. The analysis of aerosol exposure showed that the concentration of aerosol was increased with increase in the peak current, pulse duration and dielectric level and was decreased with increase in the flushing pressure. It was also found that at higher values of peak current (7A) and pulse duration (520 micros), the concentration of aerosols at breathing zone of the operator was above the permissible exposure limit value for respirable particulates (5 mg/m(3)). HAZOP study of the EDM process showed that this process is vulnerable to fire and explosion hazards. A detailed discussion on preventing the fire and explosion hazard is presented in this paper. The emission and risk of fire of the EDM process can be minimized by selecting proper process parameters and employing appropriate control strategy.
journal_name
Ind Healthjournal_title
Industrial healthauthors
Jose M,Sivapirakasam SP,Surianarayanan Mdoi
10.2486/indhealth.ms1127subject
Has Abstractpub_date
2010-01-01 00:00:00pages
478-86issue
4eissn
0019-8366issn
1880-8026pii
JST.JSTAGE/indhealth/MS1127journal_volume
48pub_type
杂志文章abstract::The effects of work on the heart are mediated by chemical, physical, and psychological stressors. It is standard clinical practice to assess personal risk factors such as cigarette smoking, hypertension, and cholesterol. Evaluation of a patient's acute symptoms and activity level at the time of presentation is also st...
journal_title:Industrial health
pub_type: 杂志文章,评审
doi:10.2486/indhealth.ms1191
更新日期:2011-01-01 00:00:00
abstract::The present study was initiated to examine the quantitative relationship between blood lead (Pb-B) and urinary delta-aminolevulinic acid (ALA-U) among Pb-exposed workers, and to find a threshold Pb-B level to induce an increase in ALA-U. For this purpose, pairs of venous blood and spot urine samples were collected fro...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.38.181
更新日期:2000-04-01 00:00:00
abstract::A study was undertaken to identify the work stressors among male and female weavers (N=516) in powerloom and handloom and examine the association of work stressors with the prevalence of work related musculo-skeletal disorders (MSDs). Physical and psychosocial stresses of work, job diagnostics, hazards of workplace, w...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.48.339
更新日期:2010-01-01 00:00:00
abstract::In a household appliance plant, several rinse-free lubricating fluids have been used instead of neat mineral oils since 1994: mixtures of isoparaffinic hydrocarbons with 9 to 14 carbons per molecule. As such they denature keratin, irritate and defat the skin, and remove water from it. Work gloves have been worn over p...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.40.291
更新日期:2002-07-01 00:00:00
abstract::Considering a fatal case of an aged individual, who died due to falling down stairs, the cause of the fatal fall was investigated through experiments. A witness, who was with the victim, when the fatal accident occurred, stated that the aged individual had miss-footed, lost balance at the top of the stairs, and fell a...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2014-0092
更新日期:2014-01-01 00:00:00
abstract::Recent studies suggest that unstable employment contracts may affect the health of workers. Many Japanese workers working full time in ostensibly permanent positions actually operate within unstable and precarious employment conditions. We compared the health status of Japanese workers with precarious employment contr...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.ms1260
更新日期:2012-01-01 00:00:00
abstract::Working time arrangements that require shift work or other non-standard working hours have significant potential to encroach on time that is highly valued for family, social and leisure activity. This can often result in workers experiencing poorer work-family or work-life balance. Based on an extensive literature sea...
journal_title:Industrial health
pub_type: 杂志文章,评审
doi:10.2486/indhealth.SW-4
更新日期:2019-04-01 00:00:00
abstract::The potential of formaldehyde to produce chronic respiratory tract disease remains a controversial issue. The main purpose of this study was to investigate the respiratory effects, if any, of long term occupational exposure to formaldehyde. This cross-sectional study was carried out at a local melamine-formaldehyde re...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.ms1197
更新日期:2011-01-01 00:00:00
abstract::This study aimed to examine the cross-sectional association of non-standard employment with cardiovascular disease risk factors. Five yr of data from the Comprehensive Survey of Living Conditions and National Health and Nutritional Survey were combined. We used logistic regression to examine the association of employm...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2017-0079
更新日期:2018-07-27 00:00:00
abstract::Cyanoacrylate (CA) and its homologues have a variety of medical, dental and commercial applications as adhesives. The increasing use of CA in dentistry, particularly as an adhesive and sealing glue, has raised concerns regarding its potential toxicity in humans. Reported toxicity of CA is uncommon in the dental workpl...
journal_title:Industrial health
pub_type: 杂志文章,评审
doi:10.2486/indhealth.42.207
更新日期:2004-04-01 00:00:00
abstract::Various amines, such as triethylamine and N,N-dimethylethylamine, have been reported to cause glaucopsia in workers employed in epoxy, foundry, and polyurethane foam industries. This symptom has been related to corneal edema and vesicular collection of fluid within the corneal subepithelial cells. Exposure to amine va...
journal_title:Industrial health
pub_type: 杂志文章,评审
doi:10.2486/indhealth.2015-0071
更新日期:2016-01-01 00:00:00
abstract::To explore characteristics of the development of coal workers' pneumoconiosis (CWP) at present and trend in the future, we investigated 16,154 coal miners exposed to dust for at least 1 yr in the Tiefa Colliery in China. Occupational categories were divided into tunneling, mining, combining and helping. Four cohorts (...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.47.369
更新日期:2009-08-01 00:00:00
abstract::The purpose of this study was to evaluate the relationships between diabetes and medical and dental care costs from a 5-yr prospective observation of Japanese workers. The data were derived from health and dental examinations and health insurance claims of 4,086 workers aged 40-54 yr. At baseline, the subjects were as...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.ms1158
更新日期:2010-01-01 00:00:00
abstract::This study aimed to (1) determine the deposition and clearance rates of ultrafine metallic nickel (Uf-Ni) in rats after a 5 hours single inhalation exposure, and (2) to histopathologically examine the pulmonary lesions induced at dose levels comparable to the Occupational Exposure Limit recommended in Japan (OEL). The...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.37.353
更新日期:1999-10-01 00:00:00
abstract::The influence of 2-bromopropane, an alternative to freon, on ovulation was examined using superovulation induced by pregnant mare's serum gonadotropin and human chorionic gonadotropin (PMSG-hCG) treatment. Three groups of mice were injected intraperitoneally 8 times with 2-bromopropane (2-BP) at 500, 1,000 or 2,000 mg...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.36.297
更新日期:1998-07-01 00:00:00
abstract::Previous studies have shown that biomarkers of chemicals with long half-lives may be better surrogates of exposure for epidemiological analyses, leading to less attenuation of the exposure-disease association, than personal air samples. However, chemicals with short half-lives have shown inconsistent results. In the p...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2017-0225
更新日期:2018-07-27 00:00:00
abstract::The ambient air quality monitoring was carried during the May 2003 to April 2004 along the (NH-6) passing through Jalgaon city. The average concentration of SOx 64 microg/m3, NOx 58 microg/ m3, particulates (> 10 micro) 515 microg/m3 and respirable dust particulates 224 microg/m3 was reported at Prabhat during the stu...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.43.656
更新日期:2005-10-01 00:00:00
abstract::The effects of bright artificial light on the subjective mental state of 10 female nurses working shifts at a university hospital were assessed. We investigated two series of five consecutive workshifts rotations comprising one normal, two night and two evening shifts, using two self-administered rating scales. The su...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.35.41
更新日期:1997-01-01 00:00:00
abstract::The desastrous traffic accidents to date have provided the relevance for promotion of harmonization of work with treatment and prevention of sleep disordered breathing (SDB) in transport sectors. SDB is highly prevalent in commercial motor vehicle (CMV) drivers and is one cause of cognitive impairment and consequent t...
journal_title:Industrial health
pub_type: 杂志文章,评审
doi:10.2486/indhealth.2018-0083
更新日期:2019-02-05 00:00:00
abstract::This study was conducted to examine how each psychosocial factor on working conditions is related to a worker's well-being. Data from the 2011 Korean Working Conditions Survey were analyzed for 33,569 employed workers aged ≥15 years. Well-being was evaluated through the WHO-5 questionnaire and variables about occupati...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2015-0191
更新日期:2016-06-10 00:00:00
abstract::This study was performed to elucidate the status of the implementation of health promotion programs (HPPs) and future tasks in occupational settings in Japan. A survey was conducted using a multiple type questionnaire mailed to 395 companies throughout Japan in 1993. The questionnaire was mailed back, after having bee...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.34.101
更新日期:1996-01-01 00:00:00
abstract::A telephone survey was conducted among a sample of managers (n=30) in Ireland who had previously commissioned an asbestos survey in their workplace buildings. The aims of the telephone survey were to examine the extent to which managers had completed Asbestos Safety Awareness (ASA) training, and to assess how such tra...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2014-0162
更新日期:2015-01-01 00:00:00
abstract::Seats have been newly developed with an anti-vibration suspension system for agricultural machinery. These seats were examined in a series of laboratory tests to determine their static and dynamic physical characteristics. These seats are specifically designed for the Japanese physique. An artificial track was constru...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.36.133
更新日期:1998-04-01 00:00:00
abstract::The present work is dedicated to the study of occupational cold environments in food distribution industrial units. Field measurements and a subjective assessment based on an individual questionnaire were considered. The survey was carried out in 5 Portuguese companies. The field measurements include 26 workplaces, wh...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2012-0078
更新日期:2014-01-01 00:00:00
abstract::India, a growing economy and world's largest democracy, has population exceeding 1.2 billion. Out of this huge number, 63.6% form working age group. More than 90% work in the informal economy, mainly agriculture and services. Less than 10% work in the organized sector; mainly industry, mining and some services. New se...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.ms1366
更新日期:2012-01-01 00:00:00
abstract::An infrasound experiment system has been constructed in order to investigate the effects of infrasound on human health from the point of view of industrial hygiene and to establish a method to assess it in working environments. Some measurements were carried out to evaluate the acoustic performance of the system in th...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.35.480
更新日期:1997-10-01 00:00:00
abstract::A questionnaire survey was done to examine the associations between the dimensions of safety climate and the nurses' motivation toward patient safety. Excluding nursing directors, a total of 371 full-time female Japanese nurses (registered nurses and licensed practical nurses) working in 6 hospitals of fewer than 250 ...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.47.70
更新日期:2009-01-01 00:00:00
abstract::The objective of present study was to assess relationship between biomarkers of Manganese (Mn) and neuropsychological effects. The study was carried out on 27 welders and 31 ferroalloy smelters as Mn-exposed groups and 30 office workers as unexposed controls. Air Mn concentrations were determined according to NIOSH me...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.2014-0250
更新日期:2016-01-01 00:00:00
abstract::Glutaraldehyde (GA) and ortho-phtalaldehyde (OPA) have been widely used as major components of disinfectants in hospitals. We evaluated the alterations in GA or OPA in rats after subacute inhalation exposure by determining levels of neurotransmitters (norepinephrine [NE], dopamine [DA], DA metabolites, dihydroxyphenyl...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.ms1156
更新日期:2011-01-01 00:00:00
abstract::A prospective study examined whether working 50 hours or less per week was associated with an increase of mental and circulatory disorders, and if so, whether it was significant for managing workers' health. White-collar workers aged 20 to 60 working at an office of a Japanese company were surveyed from August 1997 to...
journal_title:Industrial health
pub_type: 杂志文章
doi:10.2486/indhealth.41.101
更新日期:2003-04-01 00:00:00