Abstract：
:In this study, the roll compaction of an intermediate drug load formulation was performed using horizontally and vertically force fed roll compactors. The horizontally fed roll compactor was equipped with an instrumented roll technology allowing the direct measurement of normal stress at the roll surface, while the vertically fed roll compactor was equipped with a force gauge between the roll axes. Furthermore, characterization of ribbons, granules and tablets was also performed. Ribbon porosity was primarily found to be a function of normal stress, exhibiting a quadratic relationship thereof. A similar quadratic relationship was also observed between roll force and ribbon porosity of the vertically fed roll compactor. The predicted peak pressure (Pmax) using the Johanson model was found to be higher than the measured normal stress, however, the predicted Pmax correlated well with the ribbon relative density/porosity and the majority of downstream properties of granules and tablets, demonstrating its use as a scale-independent parameter. A latent variable model was developed for both the horizontal and vertical fed roll compactors to express ribbon porosity as a function of geometric and process parameters. The model validation, performed with new data, resulted in overall good predictions. This study successfully demonstrated the scale up/transfer between two different roll compactors and revealed that the combined use of design of experiments, latent variable models and in silico predictions result in better understanding of the critical process parameters in roll compaction.
journal_name
Int J Pharmjournal_title
International journal of pharmaceuticsauthors
Souihi N,Reynolds G,Tajarobi P,Wikström H,Haeffler G,Josefson M,Trygg Jdoi
10.1016/j.ijpharm.2015.02.042subject
Has Abstractpub_date
2015-04-30 00:00:00pages
192-206issue
1-2eissn
0378-5173issn
1873-3476pii
S0378-5173(15)00151-9journal_volume
484pub_type
杂志文章abstract：:Modification of recombinant proteins with polyethylene-glycol (PEG) can improve their pharmacokinetic properties, although their bioactivity may be reduced after PEGylation due to structural changes. In this study, simultaneous optimization of PEGylation efficiency and preserved bioactivity of recombinant human growth...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2018.12.034
更新日期：2019-02-25 00:00:00
abstract：:Floating (F) microcapsules containing melatonin (MT) were prepared by the ionic interaction of chitosan and a negatively charged surfactant, sodium dioctyl sulfosuccinate (DOS). The DOS/chitosan complex formation was confirmed employing infrared spectroscopy, differential scanning calorimetry (DSC), solubility and X-r...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/s0378-5173(02)00396-4
更新日期：2002-12-05 00:00:00
abstract：:How prevalent are peptide therapeutic products? How innovative are the formulations used to deliver peptides? This review provides a critical analysis of therapeutic peptide products and the formulations approved by the United States Food and Drug administration (FDA), the European Medicines Agency (EMA), and the Japa...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章,评审
doi：10.1016/j.ijpharm.2020.119491
更新日期：2020-09-25 00:00:00
abstract：:Semifluorinated alkanes (SFAs) have been described as potential excipients for pulmonary drug delivery, but proof of their efficacy is still lacking. We tested whether SFA formulations with the test drug ibuprofen can be nebulised and evaluated their pharmacokinetics. Physico-chemical properties of five different ibup...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2011.10.051
更新日期：2012-01-17 00:00:00
abstract：:This work was designed to investigate the effect of the degree of substitutions of caproic acid on plasmid DNA (pDNA) binding, cellular uptake, biocompatibility, and transfection efficiency of caproic acid grafted chitosan (CGC). The CGC with three substitution degrees (CGC-5, CGC-15, and CGC-25) were synthesized by c...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2013.02.052
更新日期：2013-04-15 00:00:00
abstract：:The role of the newly discovered cysteine protease, cathepsin K, in osteoporosis and rheumatoid arthritis is reviewed. The current development of cathepsin K inhibitors and their targeted delivery using synthetic polymer carriers are discussed. Future challenges and possible strategies to improve these delivery system...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章,评审
doi：10.1016/j.ijpharm.2003.03.003
更新日期：2004-06-11 00:00:00
abstract：:For effective topical delivery, a drug must cross the stratum corneum (SC) barrier into viable tissue. The use of permeation enhancers is a widespread approach for barrier modification. In the current study, flufenamic acid (FluA), a non-steroidal anti-inflammatory drug, is a model agent for investigating the influenc...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2016.04.011
更新日期：2016-05-30 00:00:00
abstract：:The blood-brain barrier (BBB) has a pivotal role in maintaining brain homeostasis. It robustly protects the brain parenchyma against the invasion of irrelevant substances, which may interrupt its critical function. From a pharmaceutical point of view, such a barrier may cause central nervous system (CNS) disorders ref...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章,评审
doi：10.1016/j.ijpharm.2020.119582
更新日期：2020-08-30 00:00:00
abstract：:An increasing number of non-viral vectors are being developed for the use of gene delivery nowadays, among which cationic polymers and lipoplexes receive most attention. Most of these researches are focused on how to increase the transfection efficiency of non-viral vectors as well as the reduction of toxicity. In thi...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章,评审
doi：10.1016/j.ijpharm.2009.11.006
更新日期：2010-02-15 00:00:00
abstract：:The primary aim of the study was to investigate the effects of pulsed liquid feed on granule size. The secondary aim was to increase knowledge of this technique in granule size targeting. Pulsed liquid feed refers to the pump changing between on- and off-positions in sequences, called duty cycles. One duty cycle consi...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2009.04.041
更新日期：2009-07-30 00:00:00
abstract：:Phenoporlamine hydrochloride is a novel compound that is used for the treatment of hypertension. The purpose of this study was to develop a sustained release tablet for phenoporlamine hydrochloride because of its short biological half-life. Three floating matrix formulations of phenoporlamine hydrochloride based on ga...
journal_title：International journal of pharmaceutics
pub_type： 临床试验,杂志文章
doi：10.1016/j.ijpharm.2005.12.003
更新日期：2006-03-09 00:00:00
abstract：:The aim of the current study is the evaluation of a recently optimized SEDDS, composed of Solutol HS15 and medium chain glycerides, and self-emulsifying pellets by means of ESR. Tempol-benzoate (TB)-loaded SEDDS were produced and electron spin resonance (ESR) spectroscopy was used to evaluate the diluted self-emulsify...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2008.09.014
更新日期：2009-02-09 00:00:00
abstract：:The aim of this study was to evaluate the potential application of microemulsions as a transdermal drug delivery for naproxen (Np). The pseudo-ternary phase diagrams were developed for microemulsions composed of isopropyl myristate, Span 80, Labrafil M, Labrasol, and Cremophor EL, ethanol and isopropyl alcohol and 0.5...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2011.06.026
更新日期：2011-09-15 00:00:00
abstract：:Composites of paracetamol loaded poly(ethylene glycol) (PEG) with a naturally derived and partially synthetic layered silicate (nanoclay) were prepared using hot-melt extrusion. The extent of dispersion and distribution of the paracetamol and nanoclay in the PEG matrix was examined using a combination of field emissio...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2008.06.027
更新日期：2008-11-03 00:00:00
abstract：:The effect of different formulation factors (lipid type, cholesterol, charge, internal buffer capacity, drug-to-lipid incubation ratio) on the encapsulation efficiency and size of primaquine liposomes (SUV's) in response to a pH gradient was investigated by a fractional factorial screen ing design. Three of the factor...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/s0378-5173(00)00338-0
更新日期：2000-04-05 00:00:00
abstract：:The treatment of patients suffering from advanced Parkinson's disease is highly challenging, because the efficacy of the "gold standard" levodopa declines with time. Co-administration of the dopamine receptor agonist apomorphine is beneficial, but difficult due to the poor oral bioavailability and short half-life of t...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2013.01.008
更新日期：2013-02-25 00:00:00
abstract：:Maedi Visna virus (MVV) is an ovine lentivirus with high prevalence all over the world. Since conventional vaccines had failed in protecting animals against the infection, the development of a DNA vaccine can be an alternative. The candidate vaccine was constructed by cloning the sequence encoding MVV p25 protein and ...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2009.05.005
更新日期：2009-07-30 00:00:00
abstract：:Poly(methyl methacrylate) (PMMA) is used to fill the gap between the prosthesis and the surrounding bone in cemented arthroplasties. Biocompatibility problems related to bone cement application limit the clinical success of these cemented arthroplasties. Being the cement surface in close connection with the living bon...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2004.03.011
更新日期：2004-06-18 00:00:00
abstract：:In transdermal drug delivery systems (TDDS), it is a challenge to achieve stable and prolonged high permeation rates across the skin since the concentrations of the drug dissolved in the matrix have to be high in order to maintain zero order release kinetics. Several attempts have been reported to improve the permeabi...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2012.05.031
更新日期：2012-09-15 00:00:00
abstract：:Currently, the compressed tablet and its oral administration is the most popular drug delivery modality in medicine. The accurate porosity and tensile strength characterization of a tablet design is vital for predicting its performance such as disintegration, dissolution, and drug-release efficiency upon administratio...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2018.03.018
更新日期：2018-05-05 00:00:00
abstract：:In this paper, we report a new method based on supercritical carbon dioxide (scCO(2)) to fill and distribute the porous magnetic nanoparticles with n-octanol in a homogeneous manner. The high solubility of n-octanol in scCO(2) and high diffusivity and permeability of the fluid allow efficient delivery of n-octanol int...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2006.07.031
更新日期：2006-12-11 00:00:00
abstract：:The overexpression of secretory phospholipase A2 (sPLA2) in tumors has opened new avenues for enzyme-triggered active unloading of liposomal antitumor drug carriers selectively at the target tumor. However, the effects of the liposome composition, drug encapsulation, and tumor microenvironment on the activity of sPLA2...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2015.06.005
更新日期：2015-08-01 00:00:00
abstract：:Previously, chemical enhancer-induced permeation enhancement on human stratum corneum (SC) lipoidal pathway at enhancer thermodynamic activities approaching unity in the absence of cosolvents (defined as Emax) was determined and hypothesized to be related to the enhancer solubilities in the SC lipid domain. The object...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2009.09.014
更新日期：2010-01-04 00:00:00
abstract：:Metal-based photothermal therapy has been widely used in the biomedicine field and includes gold nanoparticles, silver nanoparticles and copper sulfide nanoparticles. Furthermore, the coordination bonding-based metal nanocomplex is a new generation of photothermal agents for cancer therapy due to its high photothermal...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2018.06.048
更新日期：2018-10-05 00:00:00
abstract：:Porphyrin and their derivatives are being systematically studied as photosensitizers for photodynamic therapy. The ability to predict their membrane partition properties is of key importance to unveil their in vivo activity and applications. Several n-octanol/water partition coefficients (logP(OW)) of porphyrin deriva...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2006.08.008
更新日期：2007-02-01 00:00:00
abstract：:The primary purpose of the present study was to design and optimize a liposomal formulation of the poorly water-soluble drug oleanolic acid (OA) to improve its oral bioavailability, and prolong the duration of therapeutic drug level. Liposomes containing a soybean lecithin and cholesterol lipid bilayer, a protective h...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2016.11.056
更新日期：2017-01-30 00:00:00
abstract：:The main objective of this study was to improve the safety and oxidative stability of glycerol monooleate (GMO)-based dry-emulsion (DE) formulation containing cyclosporine A (CsA) for inhalation therapy. GMO or highly purified GMO (hpGMO) was used as surfactant for the DE formulations (GMO/DE or hpGMO/DE), the toxicol...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2013.03.026
更新日期：2013-05-01 00:00:00
abstract：:In situ amorphization is a concept that allows to amorphize a given drug in its final dosage form right before administration. Hence, this approach can potentially be used to circumvent recrystallization issues that other amorphous formulation approaches are facing during storage. In this study, the feasibility of mic...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2017.01.035
更新日期：2017-03-15 00:00:00
abstract：:In this study, a temperature and ROS-responsive drug delivery system ROSP@MSN based on mesoporous silica nanoparticles has been designed and synthesized by taking advantage of 4-(4,4,5,5-tetramethyl-1,3,2-dioxaborolan-2-yl)benzyl acrylate modified polymers (ROSP) as "nano-valve", which can respond selectively to cance...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2017.11.025
更新日期：2018-01-30 00:00:00
abstract：:In this proof-of principle study, we determined whether biocompatible, biodegradable and sterically stabilized phospholipid nanomicelles (SSNMs) improve viability and membrane integrity of cryopreserved oral keratinocytes. Cultured chemically transformed hamster oral keratinocytes were frozen gradually with and stored...
journal_title：International journal of pharmaceutics
pub_type： 杂志文章
doi：10.1016/j.ijpharm.2007.02.002
更新日期：2007-06-29 00:00:00
