Analysis of the Fracture Mechanism of Ti-6Al-4V Alloy Rods That Failed Clinically After Spinal Instrumentation Surgery.

Abstract:

STUDY DESIGN:Retrieval analysis of 2 Ti-6Al-4V alloy rods that fractured after spinal instrumentation surgery. OBJECTIVE:To determine the mechanism that underlies fractures of Ti-6Al-4V alloy rods after spinal instrumentation surgery from a materials science viewpoint. SUMMARY OF BACKGROUND DATA:Rod failures after spinal instrumentation surgery are often reported and many case-based studies have been published. However, the details of the mechanism that underlies the fractures have not yet been fully elucidated. METHODS:Two patients, a 71-year-old female and an 11-year-old male, underwent radiography and removal of their fractured rods. The latter patient had been treated using the growing-rod method. Metallurgical failure analysis of the retrieved rods was conducted, and material properties were compared between the unused and fractured rods. RESULTS:The microstructures and mechanical properties of the Ti-6Al-4V alloy rods that failed after spinal instrumentation surgery were similar to those of unused rods. Analysis of the fracture surfaces clearly identified fatigue cracking in both cases that would have lowered the resistance of the rods to failures caused by external stresses. Shot blasting the surfaces of Ti-6Al-4V alloy rods and bending the rods to fit particular contours, which is always conducted during spinal instrumentation surgery, probably introduced fatigue cracking because the alloy is highly notch sensitive. CONCLUSION:Improvements should be made to rod design and/or rod material, because the fatigue resistance of titanium alloys is intrinsically lower than that of other commercially available rod materials, including cobalt-chromium alloys. These imperfections may have greater consequences for the growing-rod method and pseudarthrosis, where the rods are not completely fixed, and they subsequently suffer from severe long-arm moments. LEVEL OF EVIDENCE:N/A.

journal_name

Spine (Phila Pa 1976)

journal_title

Spine

authors

Yamanaka K,Mori M,Yamazaki K,Kumagai R,Doita M,Chiba A

doi

10.1097/BRS.0000000000000881

subject

Has Abstract

pub_date

2015-07-01 00:00:00

pages

E767-73

issue

13

eissn

0362-2436

issn

1528-1159

journal_volume

40

pub_type

杂志文章

相关文献

SPINE文献大全
  • False-negative transcranial motor-evoked potentials during scoliosis surgery causing paralysis: a case report with literature review.

    abstract:STUDY DESIGN:Case report. OBJECTIVE:To report a case of false-negative intraoperative motor-evoked potentials (MEP) that developed paraplegia after surgery. SUMMARY OF BACKGROUND DATA:Although several false-negative results have been reported with somatosensory-evoked potentials, there is no report noted with MEP. Th...

    journal_title:Spine

    pub_type: 杂志文章,评审

    doi:10.1097/BRS.0b013e3181b40d4f

    authors: Modi HN,Suh SW,Yang JH,Yoon JY

    更新日期:2009-11-15 00:00:00

  • Risk of vertebrobasilar stroke and chiropractic care: results of a population-based case-control and case-crossover study.

    abstract:STUDY DESIGN:Population-based, case-control and case-crossover study. OBJECTIVE:To investigate associations between chiropractic visits and vertebrobasilar artery (VBA) stroke and to contrast this with primary care physician (PCP) visits and VBA stroke. SUMMARY OF BACKGROUND DATA:Chiropractic care is popular for neck...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0b013e3181644600

    authors: Cassidy JD,Boyle E,Côté P,He Y,Hogg-Johnson S,Silver FL,Bondy SJ

    更新日期:2008-02-15 00:00:00

  • Strategies for outcome research in spinal disorders. An introduction.

    abstract::The evaluation of the clinical utility of the clinical diagnostic tests and procedures, what works in spinal disorders, and for whom and how treatment affects a patient's symptoms and function are key questions of outcomes research. This paper describes the advantages and limitations of the main study approaches used....

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199409151-00004

    authors: Liang MH,Andersson G,Bombardier C,Cherkin DC,Deyo RA,Keller RB,Lee CK,Lipscomb B,Shekelle P,Spratt KF

    更新日期:1994-09-15 00:00:00

  • Atlantoaxial instability in os odontoideum with myelopathy.

    abstract:STUDY DESIGN:This study analyzed the correlation between the atlantoaxial instability (especially sagittal plane rotatory instability) and myelopathy. Thirty-four patients with os odontoideum were reviewed in clinical symptoms and radiographs. OBJECTIVES:The results were correlated to provide a rationale for the genes...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199606150-00007

    authors: Watanabe M,Toyama Y,Fujimura Y

    更新日期:1996-06-15 00:00:00

  • Three-dimensional rotational X-ray imaging for spine surgery: a quantitative validation study comparing reconstructed images with corresponding anatomical sections.

    abstract:STUDY DESIGN:A validation study was done in which reconstructed three-dimensional rotational x-ray images were quantitatively compared with corresponding anatomic sections. OBJECTIVES:To assess the accuracy of reconstructed images acquired on a three-dimensional rotational x-ray imaging device. SUMMARY OF BACKGROUND ...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/01.brs.0000154650.31781.85

    authors: Verlaan JJ,van de Kraats EB,van Walsum T,Dhert WJ,Oner FC,Niessen WJ

    更新日期:2005-03-01 00:00:00

  • Patient classification, a key to evaluate pain treatment: a psychological study in chronic low back pain patients.

    abstract::It has been proposed that pain treatment evaluation is hindered by heterogeneous properties of patient samples. Therefore, to facilitate pain treatment evaluation in this psychological study, a heterogeneous group of chronic low back pain patients was classified into more homogeneous subgroups. Two designs were used t...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199209000-00001

    authors: Talo S,Rytökoski U,Puukka P

    更新日期:1992-09-01 00:00:00

  • Anterior surgical management of single-level cervical disc disease: a cost-effectiveness analysis.

    abstract:STUDY DESIGN:Cost-effectiveness analysis with decision analysis and meta-analysis. OBJECTIVE:To determine the relative cost-effectiveness of anterior cervical discectomy with fusion (with autograft, allograft, or spacers), anterior cervical discectomy without fusion (ACD), and cervical disc replacement (CDR) for the t...

    journal_title:Spine

    pub_type: 杂志文章,meta分析

    doi:10.1097/BRS.0000000000000612

    authors: Lewis DJ,Attiah MA,Malhotra NR,Burnett MG,Stein SC

    更新日期:2014-12-01 00:00:00

  • Spinal cord morphology and dynamics during cervical laminoplasty: evaluation with intraoperative sonography.

    abstract:STUDY DESIGN:An intraoperative sonographic study for evaluating spinal cord decompression status was conducted. OBJECTIVES:To analyze the spinal cord decompression status using intraoperative sonography and to evaluate the relation to postoperative neurologic recovery following cervical laminoplasty. SUMMARY OF BACKG...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0b013e318155784d

    authors: Mihara H,Kondo S,Takeguchi H,Kohno M,Hachiya M

    更新日期:2007-10-01 00:00:00

  • The role of steroids and their effects on phospholipase A2. An animal model of radiculopathy.

    abstract:STUDY DESIGN:The possible role of phospholipase A2 in an animal model for lumbar radiculopathy and mechanisms of epidural steroid injections were studied. OBJECTIVES:To clarify the pathophysiologic mechanism of the recently proved animal model for lumbar radiculopathy and to characterize further the mechanisms of acti...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199806010-00001

    authors: Lee HM,Weinstein JN,Meller ST,Hayashi N,Spratt KF,Gebhart GF

    更新日期:1998-06-01 00:00:00

  • Spinal Fusion in Parkinson's Disease Patients: A Propensity Score-Matched Analysis With Minimum 2-Year Surveillance.

    abstract:STUDY DESIGN:Retrospective analysis. OBJECTIVE:To compare outcomes and complication rates between patients with and without Parkinson's disease (PD) patients undergoing surgery for adult spinal deformity (ASD). SUMMARY OF BACKGROUND DATA:There is limited literature evaluating the impact of PD on long-term outcomes af...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0000000000002998

    authors: Shah NV,Beyer GA,Solow M,Liu S,Tarabichi S,Stroud SG,Hollern DA,Bloom LR,Liabaud B,Agarwal S,Passias PG,Paulino CB,Diebo BG

    更新日期:2019-07-15 00:00:00

  • Two cases of Pseudomonas aeruginosa epidural abscesses and cervical osteomyelitis after dental extractions.

    abstract:STUDY DESIGN:Case report. OBJECTIVES:To report 2 unusual cases of Pseudomonas aeruginosa epidural abscesses and cervical osteomyelitis after routine dental extractions and to review relevant literature. SUMMARY OF BACKGROUND DATA:Pseudomonas aeruginosa is a rare cause of cervical osteomyelitis in patients after denta...

    journal_title:Spine

    pub_type: 杂志文章,评审

    doi:10.1097/BRS.0b013e31816c9120

    authors: Walters HL,Measley R

    更新日期:2008-04-20 00:00:00

  • Peroperative three-dimensional correction of idiopathic scoliosis with the Cotrel-Dubousset procedure.

    abstract:STUDY DESIGN:A peroperative measurement technique based on magnetic fields was used to document the thoracic and lumbar vertebral changes induced by derotation of the concave rod during corrective surgery of idiopathic scoliotic deformities with Cotrel-Dubousset instrumentation. OBJECTIVES:Objective was to accurately ...

    journal_title:Spine

    pub_type: 临床试验,杂志文章

    doi:

    authors: Labelle H,Dansereau J,Bellefleur C,de Guise J,Rivard CH,Poitras B

    更新日期:1995-06-15 00:00:00

  • Dual growing rod technique followed for three to eleven years until final fusion: the effect of frequency of lengthening.

    abstract:STUDY DESIGN:Retrospective case review of children completing dual growing rod treatment at our institutions. Patients had a minimum of 2 years follow-up. OBJECTIVE:To identify the factors influencing dual growing rod treatment outcome followed to final fusion. SUMMARY OF BACKGROUND DATA:Published reports on dual gro...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0b013e31816c8b4e

    authors: Akbarnia BA,Breakwell LM,Marks DS,McCarthy RE,Thompson AG,Canale SK,Kostial PN,Tambe A,Asher MA,Growing Spine Study Group.

    更新日期:2008-04-20 00:00:00

  • Left thoracic scoliosis configurations. Why so different?

    abstract:STUDY DESIGN:Patients in the scoliosis screening database were analyzed with respect to curve convexity, severity, and outcome, using standard statistical methods. OBJECTIVES:This study assessed whether left thoracic scoliosis is always pathologic and inquired why this is the case. SUMMARY OF BACKGROUND DATA:Left tho...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199406000-00013

    authors: Goldberg CJ,Dowling FE,Fogarty EE

    更新日期:1994-06-15 00:00:00

  • Load-sharing characteristics of stabilized lumbar spine segments.

    abstract:STUDY DESIGN:Load sharing in stabilized spinal segments was evaluated using sequential injury and stabilization with a posterior instrumentation system under an in vitro flexibility protocol. OBJECTIVE:To analyze the partitioning of applied loads between anatomic and implanted structures of lumbar functional spinal un...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-200001150-00006

    authors: Cripton PA,Jain GM,Wittenberg RH,Nolte LP

    更新日期:2000-01-15 00:00:00

  • Does early management of whiplash-associated disorders assist or impede recovery?

    abstract:STUDY DESIGN:Narrative review of the literature and commentary. OBJECTIVE:To discuss from an epidemiological and sociological perspective whether the early clinical management of whiplash-associated disorders can lead to iatrogenic disability. SUMMARY OF BACKGROUND DATA:There is a lack of evidence supporting the effe...

    journal_title:Spine

    pub_type: 杂志文章,评审

    doi:10.1097/BRS.0b013e3182388d32

    authors: Côté P,Soklaridis S

    更新日期:2011-12-01 00:00:00

  • A comparative study of chemonucleolysis with recombinant human cathepsin L and chymopapain. A radiologic, histologic, and immunohistochemical assessment.

    abstract:STUDY DESIGN:Investigation of the effects of recombinant human cathepsin L on intervertebral discs and comparison with the effects of chymopapain. OBJECTIVE:To evaluate the effects of cathepsin L on intervertebral discs as an agent for chemonucleolysis. SUMMARY BACKGROUND DATA:Cathepsin L is a typical cysteine protei...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199901150-00004

    authors: Kubo S,Tajima N,Katunuma N,Fukuda K,Kuroki H

    更新日期:1999-01-15 00:00:00

  • Efficacy of Intraoperative Intervention Following Transcranial Motor-evoked Potentials Alert During Posterior Decompression and Fusion Surgery for Thoracic Ossification of the Posterior Longitudinal Ligament: A Prospective Multicenter Study of the Monitor

    abstract:STUDY DESIGN:Prospective, multicenter, observational study. OBJECTIVE:The aim of this study was to investigate the efficacy of intervention after an alert in intraoperative neurophysiological monitoring (IONM) using transcranial motor-evoked potentials (Tc-MEPs) during surgery for thoracic ossification of the posterio...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0000000000003774

    authors: Kobayashi K,Imagama S,Yoshida G,Ando M,Kawabata S,Yamada K,Kanchiku T,Fujiwara Y,Taniguchi S,Iwasaki H,Tadokoro N,Takahashi M,Wada K,Yamamoto N,Shigematsu H,Funaba M,Yasuda A,Ushirozako H,Tani T,Matsuyama Y

    更新日期:2021-02-15 00:00:00

  • Comparison of in vivo and in vitro adjacent segment motion after lumbar fusion.

    abstract:STUDY DESIGN:For in vitro studies, there is no basis for choosing a "load control study" over a "displacement control" study. This study qualitatively compared results from in vitro and in vivo tests, allowing the authors to address the experimental assumptions that in vitro testing contributes to the understanding of ...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199408000-00015

    authors: Dekutoski MB,Schendel MJ,Ogilvie JW,Olsewski JM,Wallace LJ,Lewis JL

    更新日期:1994-08-01 00:00:00

  • Finite element analysis of the effects of pedicle screw fixation nut loosening on lumbar interbody fusion based on the elasto-plateau plasticity of bone characteristics.

    abstract:STUDY DESIGN:Cylindrical cages and pedicle screw fixation (PSF) have been used for the setting of a lumbar interbody fusion. OBJECTIVE:To investigate the effects of PSF-nut loosening on lumbar interbody fusion based on the elasto-plateau plasticity of bone characteristics. SUMMARY OF BACKGROUND DATA:The stress-strain...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0b013e3181b6258a

    authors: Kim Y,Kim TW

    更新日期:2010-03-15 00:00:00

  • Noninvasive discrimination of brachial plexus involvement in upper limb pain.

    abstract::The ability of Elvey's "brachial plexus tension test" to identify pain referred from the cervical region was investigated in 50 patients with unilateral shoulder and upper arm pain: 25 reported symptoms commencing after open heart surgery, indicating a high probability of referred pain due to that procedure; 25 were a...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199401000-00006

    authors: Selvaratnam PJ,Matyas TA,Glasgow EF

    更新日期:1994-01-01 00:00:00

  • Experimental vertebroplasty using osteoconductive granular material.

    abstract:STUDY DESIGN:Osteoporotic human cadaveric thoracic vertebral bodies and vertebral bodies from mature sheep were used as model systems to assess coral resorption and new bone formation after injection of coral granules. OBJECTIVE:To evaluate the use of natural coral exoskeleton, an osteoconductive material, for the fil...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-200005010-00006

    authors: Cunin G,Boissonnet H,Petite H,Blanchat C,Guillemin G

    更新日期:2000-05-01 00:00:00

  • Kinematics of the canine lumbar intervertebral joint. An in vivo study before and after adjacent instrumentation.

    abstract:STUDY DESIGN:In vivo, canine lumbar spine intervertebral motion was measured before and after instrumentation of caudal segments. The three-dimensional kinematics of the intervertebral joint were described using helical axes and Fourier series. OBJECTIVE:The in vivo three-dimensional kinematics of the intervertebral j...

    journal_title:Spine

    pub_type: 杂志文章

    doi:

    authors: Schendel MJ,Dekutoski MB,Ogilvie JW,Olsewski JM,Wallace LJ

    更新日期:1995-12-01 00:00:00

  • Transient paraparesis: a complication of the surgical management of Scheuermann's kyphosis secondary to thoracic stenosis.

    abstract:STUDY DESIGN:Transient paraparesis during the operative management of a 16-year-old patient with Scheuermann's kyphosis secondary to thoracic stenosis is reported. OBJECTIVE:To describe a treatable cause for paraparesis in a patient with Scheuermann's kyphosis undergoing surgical treatment. SUMMARY OF BACKGROUND DATA...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-200105010-00021

    authors: Tribus CB

    更新日期:2001-05-01 00:00:00

  • Acute intracranial subdural hematoma following a lumbar CSF leak caused by spine surgery.

    abstract:STUDY DESIGN:Case report. OBJECTIVE:To report a case of an acute intracranial subdural hematoma that formed due to cerebrospinal fluid (CSF) leak following lumbar surgery. SUMMARY OF BACKGROUND DATA:Intracranial hypotension may occur when CSF is removed from the subarachnoid space. Intracranial subdural hematoma form...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/01.brs.0000192208.66360.29

    authors: Sciubba DM,Kretzer RM,Wang PP

    更新日期:2005-12-15 00:00:00

  • Segmental contribution toward total lumbar range of motion in disc replacement and fusions: a comparison of operative and adjacent levels.

    abstract:STUDY DESIGN:Radiographic results from a prospective, randomized, multicenter trial assessing patients who underwent lumbar total disc replacement (TDR) or circumferential arthrodesis for 1-level degenerative disc disease. OBJECTIVE:To quantify the relative segmental contribution to total lumbar range of motion (ROM) ...

    journal_title:Spine

    pub_type: 杂志文章,多中心研究,随机对照试验

    doi:10.1097/BRS.0b013e3181af2622

    authors: Auerbach JD,Jones KJ,Milby AH,Anakwenze OA,Balderston RA

    更新日期:2009-11-01 00:00:00

  • Development of degenerative spondylosis of the lumbar spine after partial discectomy. Comparison of laminotomy, discectomy, and posterolateral discectomy.

    abstract:STUDY DESIGN:The development of degenerative spondylosis after successful operative decompression of the affected nerve root was prospectively evaluated in a comparative case series of 100 patients with a herniated lumbar nucleus pulposus. OBJECTIVES:The objective of this study was to compare the relative incidence of...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-199503010-00018

    authors: Kambin P,Cohen LF,Brooks M,Schaffer JL

    更新日期:1995-03-01 00:00:00

  • Costs of school scoliosis screening: a large, population-based study.

    abstract:STUDY DESIGN:This was a population-based retrospective study. OBJECTIVE:To fully estimate the costs of the Hong Kong scoliosis screening program through a large, population-based study. SUMMARY OF BACKGROUND DATA:School screening for scoliosis has often been criticized for having high costs. In fact, the screening co...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0b013e3181cbcc10

    authors: Lee CF,Fong DY,Cheung KM,Cheng JC,Ng BK,Lam TP,Mak KH,Yip PS,Luk KD

    更新日期:2010-12-15 00:00:00

  • Disc pressure measurements.

    abstract::By measurement of intradiscal pressure in vitro, the hydrostatic properties of the nucleus pulposus of normal lumbar intervertebral disc were proven. The hydrodynamic properties seem to exist also in the somewhat degenerated disc, but not in the more severely deranged ones. Intravitally-performed measurements of disc ...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/00007632-198101000-00020

    authors: Nachemson AL

    更新日期:1981-01-01 00:00:00

  • Perioperative complications of combined anterior and posterior cervical decompression and fusion crossing the cervico-thoracic junction.

    abstract:STUDY DESIGN:Retrospective review. OBJECTIVE:To determine the perioperative complications for patients undergoing single stage, multilevel, anterior, and posterior cervical fusions crossing the cervico-thoracic junction. SUMMARY OF BACKGROUND DATA:Cervical spinal stenosis with kyphosis involving 3 or more disc levels...

    journal_title:Spine

    pub_type: 杂志文章

    doi:10.1097/BRS.0b013e318190affe

    authors: Hart RA,Tatsumi RL,Hiratzka JR,Yoo JU

    更新日期:2008-12-15 00:00:00