Cephalosporin C production by a highly productive Cephalosporium acremonium strain in an airlift tower loop reactor with static mixers.

Abstract:

:The production of cephalosporin C (CPC) and its precursors penicillin N (PEN N), deacetoxycephalosporin C (DAOC) and deacetylcephalosporin C (DAC), with a highly productive strain of Cephalosporin acremonium, was investigated in an 80-1 airlift tower loop reactor with four static mixer modules (Type SMV, Sulzer) (ATLRM) on a complex medium containing 50 g l-1 peanut flour (PF). The most important key parameters such as glucose concentration and cell mass concentration were monitored during a fed-batch cultivation process. The concentrations of products CPC, PEN N, DAOC an DAC were determined on line by HPLC. The influences of four motionless mixers on the dissolved oxygen concentration (DOC), oxygen transfer rate, the cell growth and the CPC production, as well as the reactor performance, were evaluated. The results were compared with the performance of an airlift tower loop reactor (ATLR) without static mixers as well as with a stirred tank reactor (STR). A comparison of cultivations in the ATLRM and ATLR with 50 g l-1 PF indicates that the obtained maximal CPC concentration and the (CPC + DAC + DAOC) concentration were 7% and 22% higher in the ATLRM (4.96 and 7.46 g l-1) than in the ATLR (4.63 and 6.13 g l-1) respectively. The maximal CPC volumetric productivity in the ATLRM (55.1 mg l-1 h-1) was also considerably higher than that in the ATLR (48.5 mg l-1 h-1). The specific power input was reduced from 2.36 to 1.5 kW m-3, the specific productivity pertaining to the power input was improved from 1.96 to 3.31 g W-1. On the other hand, cultivation in the ATLRM had a lower maximum CPC concentration and volumetric productivity than those in STR (7.2 g l-1 and 71.2 mg l-1 h-1) with the same medium due to the lower shear stress levels and the lower specific power input (1.5 vs. 3.0 kW m-3); but the specific power imput-based yield coefficient was in the ATLRM (3.31 g W-1) higher than in the STR (2.40 g W-1). By increasing the amount of PF, it was possible to enhance the CPC concentration and volumetric productivity in the STR. However, the performance of the ATLRM was limited to using a medium containing maximal 50 g l-1 PF because of the high viscosity of the medium, the limited energy input and thus the limited oxygen supply.

journal_name

J Biotechnol

journal_title

Journal of biotechnology

authors

Zhou W,Holzhauer-Rieger K,Bayer T,Schügerl K

doi

10.1016/0168-1656(93)90168-m

subject

Has Abstract

pub_date

1993-04-01 00:00:00

pages

165-77

issue

2-3

eissn

0168-1656

issn

1873-4863

pii

0168-1656(93)90168-M

journal_volume

28

pub_type

杂志文章
  • Fast and efficient protein purification using membrane adsorber systems.

    abstract::The purification of proteins from complex cell culture samples is an essential step in proteomic research. Traditional chromatographic methods often require several steps resulting in time consuming and costly procedures. In contrast, protein purification via membrane adsorbers offers the advantage of fast and gentle ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.07.023

    authors: Suck K,Walter J,Menzel F,Tappe A,Kasper C,Naumann C,Zeidler R,Scheper T

    更新日期:2006-02-10 00:00:00

  • Maximizing microbial degradation of perchlorate using a genetic algorithm: Media optimization.

    abstract::Microbial communities are under constant influence of physical and chemical components in ecosystems. Shifts in conditions such as pH, temperature or carbon source concentration can translate into shifts in overall ecosystem functioning. These conditions can be manipulated in a laboratory setup using evolutionary comp...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2011.10.011

    authors: Kucharzyk KH,Crawford RL,Paszczynski AJ,Soule T,Hess TF

    更新日期:2012-01-01 00:00:00

  • In vitro production and purification of isochorismate using a two-enzyme cascade.

    abstract::Combining the isochorismate synthase EntC and the chorismatase FkbO in a sequential enzyme cascade provides a useful system for the biocatalytic production and subsequent purification of isochorismate from an isochorismate/chorismate mixture. FkbO has a strict preference for chorismate - isochorismate is not accepted ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2014.06.003

    authors: Hubrich F,Müller M,Andexer JN

    更新日期:2014-12-10 00:00:00

  • Assessing gene expression variation in normal human tissues using GeneTag, a novel, global, sensitive profiling method.

    abstract::GeneTag is a novel expression profiling method that allows the visualization, quantification and identification of expressed genes-whether known or novel-in any species, tissue or cell type, independent of knowledge of the underlying sequence. Here we describe the application of this method to determine variation of g...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(02)00301-2

    authors: Wong LY,Hafeman A,Boyd VL,Bodeau J,Lazaruk KD,Liew SN,Casey P,Belonogoff V,Bit S,Sumner C,Bredo A,Ho N,Chu E,Olson S,Rabkin S,Maltchenko S,Spier G,Gilbert D,Baumhueter S

    更新日期:2003-03-20 00:00:00

  • Molecular recognition of esterase plays a major role on the removal of fatty soils during detergency.

    abstract::In this work it is describe for the first time, the use of an esterase with null activity (Tfu_0883 bacterial cutinase from Thermobifida fusca) on the removal of fat from the surface of a cotton substrate. Similar levels of fat removal were found for both null and wild-type proteins, despite that only wild type protei...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2012.06.019

    authors: Silva C,Azoia NG,Martins M,Matamá T,Wu J,Cavaco-Paulo A

    更新日期:2012-10-31 00:00:00

  • A new arylesterase from Pseudomonas pseudoalcaligenes can hydrolyze ionic phthalic polyesters.

    abstract::Extracellular enzymes are assumed to be responsible for the initial and rate limiting step in biodegradation of polymers. Mainly enzymes with aliphatic esters as their natural substrates (e.g. lipase, cutinases) have until now been evaluated for polyester hydrolysis studies. However, the potential of enzymes with arom...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2017.01.012

    authors: Haernvall K,Zitzenbacher S,Yamamoto M,Schick MB,Ribitsch D,Guebitz GM

    更新日期:2017-09-10 00:00:00

  • Refolding of hexameric porcine leucine aminopeptidase using a cationic detergent and dextrin-10 as artificial chaperones.

    abstract::The application of artificial chaperones in biotechnology has been inspired by the mechanism of molecular chaperones like GroEL/GroES. It involves addition of a capturing detergent during dilution of the chaotropic reagent, that prevents protein aggregation, and finally, addition of a oligosaccharide that removes the ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2009.01.023

    authors: Laslo AC,Ganea E,Obinger C

    更新日期:2009-03-25 00:00:00

  • Effect of different levels of NADH availability on metabolic fluxes of Escherichia coli chemostat cultures in defined medium.

    abstract::Escherichia coli overexpressing a NAD(+)-dependent formate dehydrogenase (FDH) from Candida boidinii was grown in chemostat culture on various carbon sources at 0.05 h(-1) dilution rate, under anaerobic conditions using defined medium and compared to a control without the heterologous FDH pathway. Metabolic fluxes, NA...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.02.006

    authors: Sánchez AM,Bennett GN,San KY

    更新日期:2005-06-29 00:00:00

  • Adsorption behavior of two glucanases on three lignins and the effect by adding sulfonated lignin.

    abstract::The adsorption behaviors of two glucanases, TvEG and TrCel7A, on three lignins were investigated. Three lignins were isolated from raw aspen and its pretreated solid residue. The isolated lignins were labeled as Asp-MWL, DA-MWL (pretreated by dilute acid), and GL-MWL (pretreated by green liquor), respectively. The sur...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2020.07.013

    authors: Zhang Y,Jiang X,Wan S,Wu W,Wu S,Jin Y

    更新日期:2020-11-10 00:00:00

  • Long-term stability of marker gene expression in Prunus subhirtella: a model fruit tree species.

    abstract::Transgenic trees currently are being produced by Agrobacterium-mediated transformation and biolistics. Since trees are particularly suited for long-term evaluations of the impact of the technology, Prunus subhirtella autumno rosa (PAR) was chosen as model fruit tree species and transformed with a reporter gene (uidA) ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2006.06.016

    authors: Maghuly F,da Câmara Machado A,Leopold S,Khan MA,Katinger H,Laimer M

    更新日期:2007-01-01 00:00:00

  • Use of hydrophilic ionic liquids in a two-phase system to improve Mung bean epoxide hydrolases-mediated asymmetric hydrolysis of styrene oxide.

    abstract::A comparative study was made of Mung bean epoxide hydrolases-catalyzed asymmetric hydrolysis of styrene oxide to (R)-1-phenyl-1,2-ethanediol in an n-hexane/buffer biphasic system containing various hydrophilic ionic liquids (ILs). Compared to the n-hexane/buffer biphasic system alone, addition of a small amount of hyd...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2012.09.006

    authors: Chen WJ,Lou WY,Yu CY,Wu H,Zong MH,Smith TJ

    更新日期:2012-12-31 00:00:00

  • Enhancement of the antibacterial activity of an E. faecalis strain by the heterologous expression of enterocin A.

    abstract::The genus Enterococcus occurs as native microbiota of fermented products due to its broad environmental distribution and its resistance to salt concentrations. Enterococcus faecalis F, a non-pathogenic strain isolated from a ripened cheese, has demonstrated useful enzymatic capabilities, a probiotic behavior and antib...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2018.06.346

    authors: Serrano-Maldonado CE,Quirasco M

    更新日期:2018-10-10 00:00:00

  • Transformation of Bowes melanoma cells with SV40 T antigen.

    abstract::A serum-dependent and two serum-independent variants of the Bowes melanoma cell line, RPMI7272, were transfected with plasmids containing a geneticin-resistance (neo) gene transcribed by the HSV thymidine kinase promoter and an SV40 T antigen gene under control of the mouse metallothionein I promoter. T-antigen increa...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/0168-1656(92)90014-z

    authors: Asselbergs FA

    更新日期:1992-11-01 00:00:00

  • Intracellular glucose 6-phosphate content in Streptomyces coelicolor upon environmental changes in a defined medium.

    abstract::A new, chemically defined medium providing dispersed growth and high biomass formation and a method for quantitative extraction of intracellular metabolites was used to investigate the cellular response of Streptomyces coelicolor A3(2) during growth and upon changes in nutrient utilization. Fast changes of the glucose...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(99)00215-1

    authors: Mira de Orduña R,Theobald U

    更新日期:2000-02-17 00:00:00

  • Preparation of a ribosomally synthesized fungal peptide toxin precursor and its in-vitro cyclization.

    abstract::Amatoxins are ribosomally synthesized and post-translationally modified peptides (RiPPs) found in poisonous mushrooms. These cyclic peptides are potent inhibitors of RNA polymerase II transcriptional activity. Though the macrocyclization of amatoxin is extensively studied, little is known about its subsequent post-tra...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2019.12.004

    authors: Pathiraja D,Byun J,Lee S,Choi IG

    更新日期:2020-01-20 00:00:00

  • Complete genome sequence of endophyte Bacillus flexus KLBMP 4941 reveals its plant growth promotion mechanism and genetic basis for salt tolerance.

    abstract::Bacillus flexus KLBMP 4941 is a halotolerant endophyte isolated from the halophyte Limonium sinense. This strain can improve host seedling growth under salt stress conditions. We here report the complete genome information of endophyte KLBMP 4941. It has a circular chromosome and two plasmids for a total genome 4,104,...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2017.09.001

    authors: Wang TT,Ding P,Chen P,Xing K,Bai JL,Wan W,Jiang JH,Qin S

    更新日期:2017-10-20 00:00:00

  • Dual nutrient limited growth: models, experimental observations, and applications.

    abstract::Dual nutrient limited growth, the control of the cell growth rate (kinetic aspect) or the restriction of the amount of biomass (stoichiometric aspect) by two nutrients at the same time, is a relatively unknown ability of the microorganisms and consequently, still not mentioned in textbooks to date. Nevertheless, multi...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/j.jbiotec.2004.03.030

    authors: Zinn M,Witholt B,Egli T

    更新日期:2004-09-30 00:00:00

  • Natural ligand-receptor mediated loading of siRNA in milk derived exosomes.

    abstract::siRNA based therapeutics have become the next frontier in molecular medicine. Though exosomes emerge as a promising drug delivery vehicle for siRNAs, significant hurdle remains in finding safe and effective loading methods. Traditional methods of loading exogenous siRNAs in exosomes are marked by certain limitations l...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2020.04.015

    authors: Shandilya S,Rani P,Onteru SK,Singh D

    更新日期:2020-07-20 00:00:00

  • Modeling enzyme reactivity in organic solvents and water through computer simulations.

    abstract::In this article, we review how molecular modeling techniques can be used to shed light on how water and organic solvents influence the reactivity of enzymes. The application of thermodynamics-based models allowed the first qualitative predictions on the selectivity of many reaction types. However, it was with the appl...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/s0168-1656(02)00034-2

    authors: Colombo G,Carrea G

    更新日期:2002-06-13 00:00:00

  • Influence of tryptic hydrolysis on the enzymatic function of the membrane-bound form of particulate methane monooxygenase from Methylosinus trichosporium OB3b.

    abstract::Particulate methane monooxygenase (pMMO) is a membrane protein embedded in the intracytoplasmic membrane of methane-oxidizing bacteria. Structural analysis of pMMO showed the existence of a hydrophilic region exposed outside of the bacterial membrane. To obtain information regarding the role of this hydrophilic region...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2020.08.006

    authors: Miyaji A,Satou K,Baba T

    更新日期:2020-11-10 00:00:00

  • Evaluation of various serum and animal protein free media for the production of a veterinary rabies vaccine in BHK-21 cells.

    abstract::We have carried out the adaptation of BHK-21 cells to two serum free (Ex Cell 520 and HyQ PF CHO) and three animal protein free media: Ex Cell 302, HyQ PF CHO MPS and Rencyte BHK. After a direct switch or a gradual adaptation, we have achieved BHK-21 cells growth in the following media: HyQ PF CHO, HyQ PF CHO MPS, Ren...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(02)00009-3

    authors: Kallel H,Jouini A,Majoul S,Rourou S

    更新日期:2002-05-23 00:00:00

  • OpenMS - A platform for reproducible analysis of mass spectrometry data.

    abstract:BACKGROUND:In recent years, several mass spectrometry-based omics technologies emerged to investigate qualitative and quantitative changes within thousands of biologically active components such as proteins, lipids and metabolites. The research enabled through these methods potentially contributes to the diagnosis and ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/j.jbiotec.2017.05.016

    authors: Pfeuffer J,Sachsenberg T,Alka O,Walzer M,Fillbrunn A,Nilse L,Schilling O,Reinert K,Kohlbacher O

    更新日期:2017-11-10 00:00:00

  • Coupled production in biorefineries--combined use of biomass as a source of energy, fuels and materials.

    abstract::In spite of high prices for fossil raw materials the production of biomass-based products is rarely economically successful today. Depending on the location feedstock prices are currently so high that products from renewable resources are not marketable when produced in existing process chains. Apart from the higher f...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2009.03.016

    authors: Lyko H,Deerberg G,Weidner E

    更新日期:2009-06-01 00:00:00

  • Functional selection of phage displayed peptides for facilitated design of fusion tags improving aqueous two-phase partitioning of recombinant proteins.

    abstract::Aqueous two-phase systems allow for the unequal distribution of proteins and other molecules in water-rich solutions containing phase separating polymers or surfactants. One approach to improve the partitioning properties of recombinant proteins is to produce the proteins as fused to certain peptide tags. However, the...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(01)00383-2

    authors: Bandmann N,Van Alstine J,Veide A,Nygren PA

    更新日期:2002-01-31 00:00:00

  • Screening and selection of synthetic peptides for a novel and optimized endotoxin detection method.

    abstract::The current validated endotoxin detection methods, in spite of being highly sensitive, present several drawbacks in terms of reproducibility, handling and cost. Therefore novel approaches are being carried out in the scientific community to overcome these difficulties. Remarkable efforts are focused on the development...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2014.06.018

    authors: Mujika M,Zuzuarregui A,Sánchez-Gómez S,Martínez de Tejada G,Arana S,Pérez-Lorenzo E

    更新日期:2014-09-30 00:00:00

  • Glucose oxidase immobilization on a novel cellulose acetate-polymethylmethacrylate membrane.

    abstract::Glucose oxidase (GOD) was immobilized on cellulose acetate-polymethylmethacrylate (CA-PMMA) membrane. The immobilized GOD showed better performance as compared to the free enzyme in terms of thermal stability retaining 46% of the original activity at 70 degrees C where the original activity corresponded to that obtain...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.08.019

    authors: Rauf S,Ihsan A,Akhtar K,Ghauri MA,Rahman M,Anwar MA,Khalid AM

    更新日期:2006-02-10 00:00:00

  • Bioregulatory mechanisms at the level of cell organelle interactions: microspectrofluorometric in situ studies.

    abstract::The spatiotemporal analysis of bioregulatory mechanisms at the level of intracellular multienzyme complexes and organelle interactions is made possible by the availability of endogenous and exogenous fluorescence probes, the development of microspectrofluorometers allowing one- and two-dimensional scans of intracellul...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/0168-1656(90)90128-x

    authors: Kohen E,Kohen C,Prince J,Schachtschabel DO,Hirschberg JG,Morliere P,Santus R,Dubertret L,Shapiro BL

    更新日期:1990-01-01 00:00:00

  • Purification and characterization of a new bioscouring pectate lyase from Bacillus pumilus BK2.

    abstract::An alkalophilic bacterium was isolated based on the potential of extra-cellular enzymes for bioscouring. The bacterium was identified as a new strain of Bacillus pumilus BK2 producing an extra-cellular endo-pectate lyase PL (EC 4.2.2.2). PL was purified to homogeneity in three steps and has a molecular mass of 37.3+/-...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.07.019

    authors: Klug-Santner BG,Schnitzhofer W,Vrsanská M,Weber J,Agrawal PB,Nierstrasz VA,Guebitz GM

    更新日期:2006-02-10 00:00:00

  • Extracellular transglycosylase and glyceraldehyde-3-phosphate dehydrogenase attributed to the anti-staphylococcal activity of Lactobacillus plantarum USM8613.

    abstract::Increasing levels of antibiotic resistance in pathogens, including Staphylococcus aureus, remains a serious problem for public health, leading to the need for better alternative antimicrobial strategies. The antimicrobial proteins produced by Lactobacillus plantarum USM8613 attributed to its anti-staphylococcal activi...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2019.05.006

    authors: Ong JS,Taylor TD,Wong CB,Khoo BY,Sasidharan S,Choi SB,Ohno H,Liong MT

    更新日期:2019-07-20 00:00:00

  • Kinetics and substrate selectivity of a Triticum aestivum xylanase inhibitor (TAXI) resistant D11F/R122D variant of Bacillus subtilis XynA xylanase.

    abstract::This study examined the kinetics and substrate selectivity of a GH11 Bacillus subtilis XynA xylanase (BsX) sensitive to inhibition by TAXI and an engineered variant, which is much less inhibited by TAXI (BsX(mut)). The main purpose of the work was to elucidate any influence of the structural point mutations on the kin...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2010.02.012

    authors: Rasmussen LE,Sørensen JF,Meyer AS

    更新日期:2010-04-15 00:00:00