Establishing the scalable manufacture of primary human T-cells in an automated stirred-tank bioreactor.

Abstract:

:Advanced cell and gene therapies such as chimeric antigen receptor T-cell immunotherapies (CAR-T), present a novel therapeutic modality for the treatment of acute and chronic conditions including acute lymphoblastic leukemia and non-Hodgkin lymphoma. However, the development of such immunotherapies requires the manufacture of large numbers of T-cells, which remains a major translational and commercial bottleneck due to the manual, small-scale, and often static culturing systems used for their production. Such systems are used because there is an unsubstantiated concern that primary T-cells are shear sensitive, or prefer static conditions, and therefore do not grow as effectively in more scalable, agitated systems, such as stirred-tank bioreactors, as compared with T-flasks and culture bags. In this study, we demonstrate that not only T-cells can be cultivated in an automated stirred-tank bioreactor system (ambr® 250), but that their growth is consistently and significantly better than that in T-flask static culture, with equivalent cell quality. Moreover, we demonstrate that at progressively higher agitation rates over the range studied here, and thereby, higher specific power inputs (P/M W kg-1 ), the higher the final viable T-cell density; that is, a cell density of 4.65 ± 0.24 × 106 viable cells ml-1 obtained at the highest P/M of 74 × 10-4  W kg-1 in comparison with 0.91 ± 0.07 × 106 viable cells ml-1 at the lowest P/M of 3.1 × 10-4 W kg-1 . We posit that this improvement is due to the inability at the lower agitation rates to effectively suspend the Dynabeads®, which are required to activate the T-cells; and that contact between them is improved at the higher agitation rates. Importantly, from the data obtained, there is no indication that T-cells prefer being grown under static conditions or are sensitive to fluid dynamic stresses within a stirred-tank bioreactor system at the agitation speeds investigated. Indeed, the opposite has proven to be the case, whereby, the cells grow better under higher agitation speeds while maintaining their quality. This study is the first demonstration of primary T-cell ex vivo manufacture activated by Dynabeads® in an automated stirred-tank bioreactor system such as the ambr® 250 and the findings have the potential to be applied to multiple other cell candidates for advanced therapy applications.

journal_name

Biotechnol Bioeng

authors

Costariol E,Rotondi M,Amini A,Hewitt CJ,Nienow AW,Heathman TRJ,Micheletti M,Rafiq QA

doi

10.1002/bit.27088

subject

Has Abstract

pub_date

2019-10-01 00:00:00

pages

2488-2502

issue

10

eissn

0006-3592

issn

1097-0290

journal_volume

116

pub_type

杂志文章
  • Tissue-engineering approaches in pancreatic islet transplantation.

    abstract::Pancreatic islet transplantation is a promising alternative to whole-pancreas transplantation as a treatment of type 1 diabetes mellitus. This technique has been extensively developed during the past few years, with the main purpose of minimizing the complications arising from the standard protocols used in organ tran...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章,评审

    doi:10.1002/bit.26821

    authors: Perez-Basterrechea M,Esteban MM,Vega JA,Obaya AJ

    更新日期:2018-12-01 00:00:00

  • Leveraging flow mechanics to determine critical process and scaling parameters in a continuous viral inactivation reactor.

    abstract::A continuous viral inactivation (CVI) chamber has been designed to operate with acceptable residence time distribution (RTD) characteristics. However, altering the CVI's geometry and operation to accommodate the scale was not obvious. In this work, we elucidate the influence of Dean vortices and leverage the transitio...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.27223

    authors: Brown MR,Orozco R,Coffman J

    更新日期:2020-03-01 00:00:00

  • Optimization of biomass productivity and substrate utility of a hydrogen bacterium, Alcaligenes hydrogenophilus.

    abstract::Optimizations of cell productivity and utility of gaseous substrates were investigated for Alcaligenes hydrogenophilus. Theoretical analyses for the cell productivity and substrate utility were discussed in the light of experimental data. It was proved from the theoretical analyses that the maximum cell productivity w...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260240514

    authors: Miura Y,Okazaki M,Ohi K,Nishimura T,Komemushi S

    更新日期:1982-05-01 00:00:00

  • Organic solvents strip water off enzymes.

    abstract::Exchange of enzyme-bound H(2)O with T(2)O in aqueous solution followed by freeze drying provided tritiated water bound to chymotrypsin, subtilisin Carlsberg, and horseradish peroxidase. The desorption of T(2)O from these enzymes suspended in various organic solvents showed that all three enzymes lost enzyme-bound wate...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260390405

    authors: Gorman LA,Dordick JS

    更新日期:1992-02-20 00:00:00

  • Macrokinetic and quantitative microbial investigation on a bench-scale biofilter treating styrene-polluted gaseous streams.

    abstract::We performed a macrokinetic and quantitative microbial investigation of a continuously operating bench-scale biofilter treating styrene-polluted gases. The device was filled with a mixture of peat and glass beads as packing medium and inoculated with the styrene-oxidizing strain, Rhodococcus rhodochrous AL NCIMB 13259...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10640

    authors: Zilli M,Converti A,Di Felice R

    更新日期:2003-07-05 00:00:00

  • Medium-induced inhibition of microbial adsorption to nickel and activated charcoal.

    abstract::Equilibrium adsorption studies on Escherichia coli and Saccharomyces sp. revealed the capacity and affinity of these organisms for the surfaces of powdered charcoal and nickel. In simple salt solutions both organisms readily adsorbed to each solid with an affinity and maximum loading capacity individual to each cell-s...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260340703

    authors: Protheroe RG,Cumming RH,Matchett A

    更新日期:1989-10-05 00:00:00

  • A comparison of oxygenation methods fro high-density perfusion culture of animal cells.

    abstract::A perfusion culture system was developed to investigate the oxygenation of high-density hybridoma cell cultures. The culture system was composed of a stirred-tank bioreactor and an external microfiltration hollow fiber cartridge for medium perfusion. Cell growth and antibody production were examined with large bubble ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260410702

    authors: Zhang S,Handa-Corrigan A,Spier RE

    更新日期:1993-03-25 00:00:00

  • Directed evolution of xylose specific transporters to facilitate glucose-xylose co-utilization.

    abstract::A highly active xylose specific transporter without glucose inhibition is highly desirable in cost-effective production of biofuels from lignocellulosic biomass. However, currently available xylose specific transporters suffer from low overall activity and most are inhibited by glucose. In this study, we applied a dir...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.25724

    authors: Wang M,Yu C,Zhao H

    更新日期:2016-03-01 00:00:00

  • Development of a formaldehyde biosensor with application to synthetic methylotrophy.

    abstract::Formaldehyde is a prevalent environmental toxin and a key intermediate in single carbon metabolism. The ability to monitor formaldehyde concentration is, therefore, of interest for both environmental monitoring and for metabolic engineering of native and synthetic methylotrophs, but current methods suffer from low sen...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.26455

    authors: Woolston BM,Roth T,Kohale I,Liu DR,Stephanopoulos G

    更新日期:2018-01-01 00:00:00

  • Development of a new bioprocess scheme using frozen seed train intermediates to initiate CHO cell culture manufacturing campaigns.

    abstract::Agility to schedule and execute cell culture manufacturing campaigns quickly in a multi-product facility will play a key role in meeting the growing demand for therapeutic proteins. In an effort to shorten campaign timelines, maximize plant flexibility and resource utilization, we investigated the initiation of cell c...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.24808

    authors: Seth G,Hamilton RW,Stapp TR,Zheng L,Meier A,Petty K,Leung S,Chary S

    更新日期:2013-05-01 00:00:00

  • Determination of diffusion coefficients of proteins in stationary phases by frontal chromatography.

    abstract::A strategy to determine effective diffusion coefficients of proteins in chromatographic gels is presented in this article. An experimental methodology based on frontal liquid chromatography was combined with a numerical methodology based on a mathematical model describing the chromatographic process including the extr...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.20738

    authors: Kempe H,Persson P,Axelsson A,Nilsson B,Zacchi G

    更新日期:2006-03-05 00:00:00

  • Integrated reactor concepts for the enzymatic kinetic synthesis of cephalexin.

    abstract::Integrated process concepts for enzymatic cephalexin synthesis were investigated by our group, and this article focuses on the integration of reactions and product removal during the reactions. The last step in cephalexin production is the enzymatic kinetic coupling of activated phenylglycine (phenylglycine amide or p...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.10348

    authors: Schroën CG,Nierstrasz VA,Bosma R,Kroon PJ,Tjeerdsma PS,DeVroom E,VanderLaan JM,Moody HM,Beeftink HH,Janssen AE,Tramper J

    更新日期:2002-10-20 00:00:00

  • Real-time measurements of human chondrocyte heat production during in vitro proliferation.

    abstract::Isothermal microcalorimeters (IMC) are highly sensitive instruments that allow the measurement of heat flow in the microwatt range. Due to their detection of minute thermal heat, IMC techniques have been used in numerous biological applications, including the study of fermentation processes, pharmaceutical development...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.23268

    authors: Santoro R,Braissant O,Müller B,Wirz D,Daniels AU,Martin I,Wendt D

    更新日期:2011-12-01 00:00:00

  • Pilot-and production-scale containment of cytotoxic and oncogenic fermentation processes.

    abstract::Proper design of fermentation facilities and equipment modification can control the risks associated with largescale production and purification of microbially produced cytotoxic agents and oncogenic viruses. The primary biohazard risks to operators and the environment are generation of aerosols and accidental spills....

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260260808

    authors: Flickinger MC,Sansone EB

    更新日期:1984-08-01 00:00:00

  • YATP value in Candida tropicalis grown on n-alkanes, fatty acids, and acetate.

    abstract::The amount of ATP produced during n-alkane, fatty acid, or acetate metabolism in Candida tropicalis has been established from the P/O ratios measured on isolated mitochondria, yield on substrate and carbon balance. For these three kinds of substrates YATP value has been found to be close to 4, although Ysub on acetate...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260171202

    authors: Gallo M,Azoulay E

    更新日期:1975-12-01 00:00:00

  • Yield stress of pretreated corn stover suspensions using magnetic resonance imaging.

    abstract::Cellulose fibers in water form networks that give rise to an apparent yield stress, especially at high solids contents. Measuring the yield stress and correlating it with fiber concentration is important for the biomass and pulp industries. Understanding how the yield stress behaves at high solids concentrations is cr...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.23197

    authors: Lavenson DM,Tozzi EJ,McCarthy MJ,Powell RL

    更新日期:2011-10-01 00:00:00

  • Development of a novel ER stress based selection system for the isolation of highly productive clones.

    abstract::Most biotherapeutic drugs are recombinant monoclonal antibodies which are mostly produced in monoclonal cell lines derived from Chinese hamster ovary (CHO) cells. Various clones expressing a monoclonal recombinant antibody were analyzed and a correlation of the antibody concentration and the relative mRNA level of cal...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.24527

    authors: Kober L,Zehe C,Bode J

    更新日期:2012-10-01 00:00:00

  • Kinetics of pure cultures of hydrogen-oxidizing denitrifying bacteria and modeling of the interactions among them in mixed cultures.

    abstract::In this study we report the isolation of four denitrifying bacteria from a batch reactor, where the progress of hydrogenotrophic denitrification was examined. Only three of the strains had the ability to use hydrogen as electron donor. In the present work, kinetic batch experiments were carried out in order to study t...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.21031

    authors: Vasiliadou IA,Siozios S,Papadas IT,Bourtzis K,Pavlou S,Vayenas DV

    更新日期:2006-10-20 00:00:00

  • Equations and calculations for fermentations of butyric acid bacteria. Reprinted from Biotechnology and Bioengineering, Vol. XXVI, Pp 174-187 (1984).

    abstract::A stoichiometric equation has been derived which describes the interrelations among the various products and biomass in fermentations of butyric acid bacteria. The derivation of the equation is based on an assumed ATP yield, two biological regularities, and the biochemistry of product formation of the fermentations. T...

    journal_title:Biotechnology and bioengineering

    pub_type: 传,古典文章,历史文章,杂志文章

    doi:

    authors: Papoutsakis ET

    更新日期:2000-03-20 00:00:00

  • Factors promoting emissions of nitrous oxide and nitric oxide from denitrifying sequencing batch reactors operated with methanol and ethanol as electron donors.

    abstract::The emissions of nitrous oxide (N(2)O) and nitric oxide (NO) from biological nitrogen removal (BNR) operations via nitrification and denitrification is gaining increased prominence. While many factors relevant to the operation of denitrifying reactors can influence N(2)O and NO emissions from them, the role of differe...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.22704

    authors: Lu H,Chandran K

    更新日期:2010-06-15 00:00:00

  • Yeast suspension filtration: flux enhancement using an upward gas/liquid slug flow-application to continuous alcoholic fermentation with cell recycle.

    abstract::This study deals with the use of an upward gas/liquid slug flow to reduce tubular mineral membrane fouling. The injection of air into the feedstream is designed to create hydrodynamic conditions that destabilize the cake layer over the membrane surface inside the filtration module complex. Experimental study was carri...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(sici)1097-0290(19980405)58:1<47::aid-bit5

    authors: Mercier M,Maranges C,Fonade C,Lafforgue-Delorme C

    更新日期:1998-04-05 00:00:00

  • Use of exogenous specialised bacteria in the biological detoxification of a dump site-polychlorobiphenyl-contaminated soil in slurry phase conditions

    abstract::The possibility of biologically detoxifying a contaminated soil from an Italian dump site containing about 1500 mg/kg (in dry soil) of polychlorinated biphenyls was studied in the laboratory in this work. The soil, which contained indigenous aerobic bacteria capable of growing on biphenyl or on monochlorobenzoic acids...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(sici)1097-0290(19990720)64:2<240::aid-bit

    authors: Fava F,Bertin L

    更新日期:1999-07-20 00:00:00

  • Annotation of additional evolutionary conserved microRNAs in CHO cells from updated genomic data.

    abstract::MicroRNAs are small non-coding RNAs that play a critical role in post-transcriptional control of gene expression. Recent publications of genomic sequencing data from the Chinese Hamster (CGR) and Chinese hamster ovary (CHO) cells provide new tools for the discovery of novel miRNAs in this important production system. ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.25539

    authors: Diendorfer AB,Hackl M,Klanert G,Jadhav V,Reithofer M,Stiefel F,Hesse F,Grillari J,Borth N

    更新日期:2015-07-01 00:00:00

  • Effects of substratum morphology on cell physiology.

    abstract::Among the host of substratum properties that affect animal cell behavior, surface morphology has received relatively little attention. The earliest effect of surface morphology on animal cells was discovered almost a century ago when it was found that cells became oriented in response to the underlying topography. Thi...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260430811

    authors: Singhvi R,Stephanopoulos G,Wang DI

    更新日期:1994-04-05 00:00:00

  • On-line estimation of dissolved methane concentration during methanotrophic fermentations.

    abstract::Knowledge of the aqueous phase methane concentration is critical to understanding and controlling process kinetics in methanotrophic bioreactors. Unfortunately since no dissolved methane probe is commercially available, this data must be obtained off-line by the time-consuming gas-liquid partition method. In this stud...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.21050

    authors: Yu Y,Ramsay JA,Ramsay BA

    更新日期:2006-12-05 00:00:00

  • Production of indole alkaloids by selected hairy root lines of Catharanthus roseus.

    abstract::Hairy root cultures of Catharanthus roseus were established by infection of seedlings with Agrobacterium rhizogenes 15834. Approximately 150 transformants from four different. C. roseus cultivars were screened for desirable traits in growth and indole alkaloid production. Five hairy root clones grew well in liquid cul...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260410511

    authors: Bhadra R,Vani S,Shanks JV

    更新日期:1993-03-05 00:00:00

  • Adsorptive control of water in esterification with immobilized enzymes: II. fixed-bed reactor behavior.

    abstract::Experimental and theoretical studies are conducted to understand the dynamic behavior of a continuous-flow fixed-bed reactor in which an esterification is catalyzed by an immobilized enzyme in an organic solvent medium. The experimental system consists of a commercial immobilized lipase preparation known as Lipozyme a...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(sici)1097-0290(19981120)60:4<445::aid-bit

    authors: Mensah P,Gainer JL,Carta G

    更新日期:1998-11-20 00:00:00

  • Rapid in vivo evolution of a beta-lactamase using phagemids.

    abstract::RNA viruses are capable of undergoing extremely rapid evolution due to their high rates of reproduction, small genome size, and a high frequency of spontaneous mutagenesis. Here we demonstrate that a virus-like, evolutionary state can be created by propagating a phagemid population in a hypermutator strain of Escheric...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/(sici)1097-0290(20000405)68:1<121::aid-bit

    authors: Long-McGie J,Liu AD,Schellenberger V

    更新日期:2000-04-05 00:00:00

  • Numerical simulation of a fully baffled biological reactor: the differential circumferential averaging mixing plane approach.

    abstract::A modified mixing plane approach for steady state simulation of flow field in fully baffled biological reactor is presented and discussed. Without requiring any experimental input, this approach of dividing the vessel into suitable number of connected and disconnected zones; solving steady state equation separately in...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.21030

    authors: Dubey H,Das SK,Panda T

    更新日期:2006-11-05 00:00:00

  • Thermostability of soluble and immobilized alpha-amylase from Bacillus licheniformis.

    abstract::In view of a possible application of the alpha-amylase from Bacillus licheniformis as a time-temperature integrator for evaluation of heat processes,(11) thermal inactivation kinetics of the dissolved and covalently immobilized enzyme were studied in the temperature range 90-108 degrees C. The D-values (95 degrees C) ...

    journal_title:Biotechnology and bioengineering

    pub_type: 杂志文章

    doi:10.1002/bit.260400309

    authors: De Cordt S,Vanhoof K,Hu J,Maesmans G,Hendrickx M,Tobback P

    更新日期:1992-07-01 00:00:00