Continuous 2-keto-L-gulonic acid fermentation from L-sorbose by Ketogulonigenium vulgare DSM 4025.

Abstract:

:A single-stage continuous fermentation process for the production of 2-keto-L-gulonic acid (2KGA) from L-sorbose using Ketogulonigenium vulgare DSM 4025 was developed. The chemostat culture with the dilution rate that was calculated based on the relationship between the 2KGA production rate and the 2KGA concentration was feasible for production with high concentration of 2KGA. In this system, 112.2 g/L of 2KGA on the average was continuously produced from 114 g/L of L-sorbose. A steady state of the fermentation was maintained for the duration of more than 110 h. The dilution rate was kept in the range of 0.035 and 0.043 h(-1), and the 2KGA productivity was 3.90 to 4.80 g/L/h. The average molar conversion yield of 2KGA from L-sorbose was 91.3%. Under the optimal conditions, L-sorbose concentration was kept at 0 g/L. Meanwhile, the dissolved oxygen level was changing in response to the dilution rate and 2KGA concentration. In the dissolved oxygen (DO) range of 16% to 58%, it was revealed that the relationship between DO and D possessed high degree of positive correlation under the L-sorbose limiting condition (complete consumption of L-sorbose). Increasing D closer to the critical value for washing out point of the continuous fermentation, DO value tended to be gradually increased up to 58%. In conclusion, an efficient and reproducible continuous fermentation process for 2KGA production by K. vulgare DSM 4025 could be developed using a medium containing baker's yeast without using a second helper microorganism.

authors

Takagi Y,Sugisawa T,Hoshino T

doi

10.1007/s00253-008-1822-6

subject

Has Abstract

pub_date

2009-04-01 00:00:00

pages

1049-56

issue

6

eissn

0175-7598

issn

1432-0614

journal_volume

82

pub_type

杂志文章
  • An impaired ubiquitin ligase complex favors initial growth of auxotrophic yeast strains in synthetic grape must.

    abstract::We used experimental evolution in order to identify genes involved in the adaptation of Saccharomyces cerevisiae to the early stages of alcoholic fermentation. Evolution experiments were run for about 200 generations, in continuous culture conditions emulating the initial stages of wine fermentation. We performed whol...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-014-6126-4

    authors: Mangado A,Tronchoni J,Morales P,Novo M,Quirós M,Gonzalez R

    更新日期:2015-02-01 00:00:00

  • Improved sandwich-hybridization assay for an electrical DNA-chip-based monitoring of bioprocess-relevant marker genes.

    abstract::Recently, it was shown that electrical DNA-chips in connection with a magnetic bead-based sandwich-hybridization assay can be a suitable alternative for the analysis of gene expression by monitoring the respective mRNA levels. In this study, we established an improved assay which allowed for a significantly shortened ...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-008-1347-z

    authors: Pioch D,Jürgen B,Evers S,Maurer KH,Hecker M,Schweder T

    更新日期:2008-03-01 00:00:00

  • Bioflavoring and beer refermentation.

    abstract::Various techniques are used to adjust the flavors of foods and beverages to new market demands. Although synthetic flavoring chemicals are still widely used, flavors produced by biological methods (bioflavors) are now more and more requested by consumers, increasingly concerned with health and environmental problems c...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章,评审

    doi:10.1007/s00253-003-1340-5

    authors: Vanderhaegen B,Neven H,Coghe S,Verstrepen KJ,Derdelinckx G,Verachtert H

    更新日期:2003-08-01 00:00:00

  • Diversity and distribution of autotrophic microbial community along environmental gradients in grassland soils on the Tibetan Plateau.

    abstract::Soil microbial autotrophs play a significant role in CO2 fixation in terrestrial ecosystem, particularly in vegetation-constrained ecosystems with environmental stresses, such as the Tibetan Plateau characterized by low temperature and high UV. However, soil microbial autotrophic communities and their driving factors ...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-015-6723-x

    authors: Guo G,Kong W,Liu J,Zhao J,Du H,Zhang X,Xia P

    更新日期:2015-10-01 00:00:00

  • Current state and perspectives of penicillin G acylase-based biocatalyses.

    abstract::In the course of more than 60-year history, penicillin G acylase (PGA) gained a unique position among enzymes used by pharmaceutical industry for production of β-lactam antibiotics. Kinetically controlled enzymatic syntheses of cephalosporins of novel generations in which PGA catalyzes coupling of activated acyl donor...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章,评审

    doi:10.1007/s00253-013-5492-7

    authors: Marešová H,Plačková M,Grulich M,Kyslík P

    更新日期:2014-04-01 00:00:00

  • Biotransformation of citronellol by the basidiomycete Cystoderma carcharias in an aerated-membrane bioreactor.

    abstract::The basidiomycete Cystoderma carcharias transformed citronellol into 3,7-dimethyl-1,6,7-octanetriol as the main product. 3,7-Dimethyl-6,7-epoxy-1-octanol was identified as important intermediary product of the biotransformation, and the allylic diols 2,6-dimethyl-2-octene-1,8-diol, 3,7-dimethyl-5-octene-1,7-diol and 3...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s002530051376

    authors: Onken J,Berger RG

    更新日期:1999-02-01 00:00:00

  • Production of Lactobacillus kefir cells for asymmetric synthesis of a 3,5-dihydroxycarboxylate.

    abstract::An efficient fedbatch process for the production of Lactobacillus kefir DSM 20587 cells was developed. An improvement in space time yield of 270% (3.7 g(DCW) l(-1)-day(-1)) and in final enzyme activity of 440% (9.1 U/ml) was achieved on a 150 l scale by controlling the oxygen transfer rate to 7--9 mmol l(-1) h(-1). Th...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-004-1837-6

    authors: Pfruender H,Amidjojo M,Hang F,Weuster-Botz D

    更新日期:2005-06-01 00:00:00

  • Growth and differentiation of permanent and secondary mouse myogenic cell lines on microcarriers.

    abstract::Myogenesis involves the determination of progenitor cells to myoblasts, their fusion to yield multinuclear myotubes, and the maturation of myotubes to muscle fibres. This development is reflected in a time pattern of gene expression, e.g. of genes coding for desmin, the myogenic factors myogenin and myoD, the acetylch...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s002530100595

    authors: Bardouille C,Lehmann J,Heimann P,Jockusch H

    更新日期:2001-05-01 00:00:00

  • Kinetic analysis of growth and xanthan gum production with Xanthomonas campestris on sucrose, using sequentially consumed nitrogen sources.

    abstract::A batch fermentation strategy using Xanthomonas campestris ATCC 13951 for xanthan gum production has been established in which all essential medium components are supplied at the onset. This has been achieved using sucrose as sole sugar feedstock. Sequential consumption of nitrogen sources (soybean hydrolysates, ammon...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s002530000580

    authors: Letisse F,Chevallereau P,Simon JL,Lindley ND

    更新日期:2001-05-01 00:00:00

  • The NT11, a novel fusion tag for enhancing protein expression in Escherichia coli.

    abstract::The Escherichia coli (E. coli) expression system has been widely used to produce recombinant proteins. However, in some heterologous expressions, there are still difficulties in large-scale production. The use of fusion partners is one of the strategies for improving the expression levels of proteins in E. coli host. ...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-018-09595-w

    authors: Nguyen TKM,Ki MR,Son RG,Pack SP

    更新日期:2019-03-01 00:00:00

  • Optimization of erythritol and glycerol accumulation in conidia of Beauveria bassiana by solid-state fermentation, using response surface methodology.

    abstract::Entomopathogenic fungi are widely produced for use as mycoinsecticides. Therefore, improvement of the shelf life of fungal propagules under good and adverse conditions should be a pre-requisite of their production. In order to improve conidial physiology as well as mycoinsecticide efficiency, culture conditions may be...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-005-1901-x

    authors: Tarocco F,Lecuona RE,Couto AS,Arcas JA

    更新日期:2005-09-01 00:00:00

  • Design of a core-shell type immuno-magnetic separation system and multiplex PCR for rapid detection of pathogens from food samples.

    abstract::We report an immuno-magnetic separation system developed by the immobilization of pathogen-specific antibodies on the core-shell magnetic beads. The magnetic beads were grafted with glycidylmethacrylate (GMA) using surface-initiated atom transfer radical polymerization (SI-ATRP). For immuno-magnetic separation (IMS) o...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-013-5231-0

    authors: Ozalp VC,Bayramoglu G,Arica MY,Oktem HA

    更新日期:2013-11-01 00:00:00

  • A mutant trypsin-like enzyme from Streptomyces fradiae, created by site-directed mutagenesis, improves affinity chromatography for protein trypsin inhibitors.

    abstract::The Ser-170 residue of a trypsin-like enzyme from Streptomyces fradiae (SFT), which is considered to be the active-site serine, was replaced with alanine by site-directed mutagenesis to improve the affinity chromatography step for a Kazal-type trypsin inhibitor pancreatic secretory trypsin inhibitor (PSTI). The result...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s002530050777

    authors: Katoh T,Kikuchi N,Nagata K,Yoshida N

    更新日期:1996-08-01 00:00:00

  • Microbial population dynamics and proteomics in membrane bioreactors with enzymatic quorum quenching.

    abstract::Quorum sensing gives rise to biofilm formation on the membrane surface, which in turn causes a loss of water permeability in membrane bioreactors (MBRs) for wastewater treatment. Enzymatic quorum quenching was reported to successfully inhibit the formation of biofilm in MBRs through the decomposition of signal molecul...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-012-4272-0

    authors: Kim HW,Oh HS,Kim SR,Lee KB,Yeon KM,Lee CH,Kim S,Lee JK

    更新日期:2013-05-01 00:00:00

  • Characterization and cross-protection evaluation of M949_1603 gene deletion Riemerella anatipestifer mutant RA-M1.

    abstract::Riemerella anatipestifer infection causes high mortality for ducks which results in major economic losses in the duck industry. In this study, we identified a mutant strain RA-M1 by Tn4351 transposon mutagenesis, in which the M949_1603 gene encoding glycosyl transferase was inactivated. PCR analysis revealed that M949...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-015-6848-y

    authors: Zou J,Wang X,Ding C,Tian M,Han X,Wang S,Yu S

    更新日期:2015-12-01 00:00:00

  • Acetate treatment in 70 degrees C upflow anaerobic sludge-blanket (UASB) reactors: start-up with thermophilic inocula and the kinetics of the UASB sludges.

    abstract::This study focused on the use the thermophilic anaerobic granulae in the start-up of 70 degrees C acetate-fed upflow anaerobic sludge-blanket (UASB) reactors and the kinetics of granulae grown at 70 degrees C. In the UASB reactors, chemical oxygen demand removal commenced within 48 h of the start-up. The maximum reduc...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/BF00166916

    authors: Lepistö R,Rintala JA

    更新日期:1995-11-01 00:00:00

  • Pyranose 2-oxidase from Phanerochaete chrysosporium--further biochemical characterisation.

    abstract::Pyranose 2-oxidase (P2O) was purified 43-fold to apparent homogeneity from the basidiomycete Phanerochaete chrysosporium using liquid chromatography on phenyl Sepharose, Mono Q (twice) and phenyl Superose. The native enzyme has a molecular mass of about 250 kDa (based on native PAGE) and is composed of four identical ...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s002530050964

    authors: Artolozaga MJ,Kubátová E,Volc J,Kalisz HM

    更新日期:1997-05-01 00:00:00

  • Improvement of levan production in Bacillus amyloliquefaciens through metabolic optimization of regulatory elements.

    abstract::Levan is a functional homopolymer of fructose with considerable applications in food, pharmaceutical and cosmetic industries. To improve the levan production in Bacillus amyloliquefaciens, the regulatory elements of sacB (encoding levansucrase) expression and levansucrase secretion were optimized. Four heterologous pr...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-017-8171-2

    authors: Gu Y,Zheng J,Feng J,Cao M,Gao W,Quan Y,Dang Y,Wang Y,Wang S,Song C

    更新日期:2017-05-01 00:00:00

  • Identification of tomato miRNAs responsive to root colonization by endophytic Pochonia chlamydosporia.

    abstract::The molecular mechanisms active during the endophytic phase of the fungus Pochonia chlamydosporia are still poorly understood. In particular, few data are available on the links between the endophyte and the root response, as modulated by noncoding small RNAs. In this study, we describe the microRNAs (miRNAs) that are...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-017-8608-7

    authors: Pentimone I,Lebrón R,Hackenberg M,Rosso LC,Colagiero M,Nigro F,Ciancio A

    更新日期:2018-01-01 00:00:00

  • Caecal environment of rats fed far East Asian-modelled diets.

    abstract::To clarify the effect of type of foods on the intestinal environment, Far East Asian- (FEA; rich in rice starch, soy protein and soy oil) and Far East Asian marine- (FEAM; rich in rice starch, fish meal, fish oil and brown alga) modelled diets and sucrose, casein and beef tallow-rich (SCB) diet were prepared. After th...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-014-5535-8

    authors: An C,Kuda T,Yazaki T,Takahashi H,Kimura B

    更新日期:2014-05-01 00:00:00

  • Aroma compounds production by solid state fermentation, importance of in situ gas-phase recovery systems.

    abstract::Flavour and fragrance compounds are extremely important for food, feed, cosmetic and pharmaceutical industries. In the last decades, due to the consumer's increased trend towards natural products, a great interest in natural aroma compounds has arisen to the detriment of chemically synthesised ones. Recently, solid st...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章,评审

    doi:10.1007/s00253-018-9157-4

    authors: Try S,Voilley A,Chunhieng T,De-Coninck J,Waché Y

    更新日期:2018-09-01 00:00:00

  • Effects of addition of elicitors on rimocidin biosynthesis in Streptomyces rimosus M527.

    abstract::The polyene macrolide rimocidin, produced by Streptomyces rimosus M527, is highly effective against a broad range of fungal plant pathogens, but at low yields. Elicitation is an effective method of stimulating the yield of bioactive secondary metabolites. In this study, the biomass and filtrate of a culture broth of E...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-020-10565-4

    authors: Song Z,Ma Z,Bechthold A,Yu X

    更新日期:2020-05-01 00:00:00

  • Fluorescence-based high-throughput screening system for R-ω-transaminase engineering and its substrate scope extension.

    abstract::ω-Transaminase (ω-TA) is an attractive alternative to metal catalysts for the stereoselective amination of prochiral ketones. The narrow substrate scope of an R-ω-transaminase from Mycobacterium vanbaalenii (MvTA) limits its application in R-amine synthesis. A fluorescence-based TA activity screening system was develo...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-020-10444-y

    authors: Cheng F,Chen XL,Xiang C,Liu ZQ,Wang YJ,Zheng YG

    更新日期:2020-04-01 00:00:00

  • Control of the heparosan N-deacetylation leads to an improved bioengineered heparin.

    abstract::The production of the anticoagulant drug heparin from non-animal sources has a number of advantages over the current commercial production of heparin. These advantages include better source material availability, improved quality control, and reduced concerns about animal virus or prion impurities. A bioengineered hep...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-011-3231-5

    authors: Wang Z,Yang B,Zhang Z,Ly M,Takieddin M,Mousa S,Liu J,Dordick JS,Linhardt RJ

    更新日期:2011-07-01 00:00:00

  • Metabolic engineering of flavonoids in plants and microorganisms.

    abstract::Over 9,000 flavonoid compounds have been found in various plants, comprising one of the largest families of natural products. Flavonoids are an essential factor in plant interactions with the environment, often serving as the first line of defense against UV irradiation and pathogen attacks. Flavonoids are also major ...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章,评审

    doi:10.1007/s00253-011-3449-2

    authors: Wang Y,Chen S,Yu O

    更新日期:2011-08-01 00:00:00

  • Lipases: sources, immobilization methods, and industrial applications.

    abstract::Enzymes are natural catalysts highly specific to the substrate type and operate under mild conditions of temperature, pressure, and pH with high conversion rates, which makes them more efficient than conventional chemical catalysts. The enzymes can be obtained from various sources, animal, vegetable, and microbiologic...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章,评审

    doi:10.1007/s00253-019-10027-6

    authors: Filho DG,Silva AG,Guidini CZ

    更新日期:2019-09-01 00:00:00

  • The utilization of sugar cane molasses with/without the presence of lignosulfonate for the production of bacterial cellulose.

    abstract::Production of bacterial cellulose (BC) using sugar cane molasses (MO) with/without the presence of lignosulfonate (MOL) as a sole carbon source in a Hestrin-Schramm medium (HS) was investigated. Six strains of Acetobacter xylinum [American Type Culture Collection 10245 and Institute of Fermentation in Osaka (IFO) 1369...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-005-0265-6

    authors: Keshk S,Sameshima K

    更新日期:2006-09-01 00:00:00

  • Application of 16S rRNA metagenomics to analyze bacterial communities at a respiratory care centre in Taiwan.

    abstract::In this study, we applied a 16S ribosomal RNA (rRNA) metagenomics approach to survey inanimate hospital environments (IHEs) in a respiratory care center (RCC). A total of 16 samples, including 9 from medical devices and 7 from workstations, were analyzed. Besides, clinical isolates were retrospectively analyzed during...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-014-6176-7

    authors: Tang CY,Yiu SM,Kuo HY,Tan TS,Liao KH,Liu CC,Hon WK,Liou ML

    更新日期:2015-03-01 00:00:00

  • Aerobic biodegradation of selected monoterpenes.

    abstract::Batch experiments were conducted to assess the biotransformation potential of four hydrocarbon monoterpenes (d-limonene, alpha-pinene, gamma-terpinene, and terpinolene) and four alcohols (arbanol, linalool, plinol, and alpha-terpineol) under aerobic conditions at 23 degrees C. Both forest-soil extract and enriched cul...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s002530050770

    authors: Misra G,Pavlostathis SG,Perdue EM,Araujo R

    更新日期:1996-07-01 00:00:00

  • Production of extracellular heterologous proteins in Streptomyces rimosus, producer of the antibiotic oxytetracycline.

    abstract::Among the Streptomyces species, Streptomyces lividans has often been used for the production of heterologous proteins as it can secrete target proteins directly into the culture medium. Streptomyces rimosus, on the other hand, has for long been used at an industrial scale for oxytetracycline production, and it holds '...

    journal_title:Applied microbiology and biotechnology

    pub_type: 杂志文章

    doi:10.1007/s00253-018-8793-z

    authors: Carrillo Rincón AF,Magdevska V,Kranjc L,Fujs Š,Müller R,Petković H

    更新日期:2018-03-01 00:00:00