In situ detoxification and continuous cultivation of dilute-acid hydrolyzate to ethanol by encapsulated S. cerevisiae.

Abstract:

:Dilute-acid lignocellulosic hydrolyzate was successfully fermented to ethanol by encapsulated Saccharomyces cerevisiae at dilution rates up to 0.5h(-1). The hydrolyzate was so toxic that freely suspended yeast cells could ferment it continuously just up to dilution rate 0.1h(-1), where the cells lost 75% of their viability measured by colony forming unit (CFU). However, encapsulation increased their capacity for in situ detoxification of the hydrolyzate and protected the cells against the inhibitors present in the hydrolyzate. While the cells were encapsulated, they could successfully ferment the hydrolyzate at tested dilution rates 0.1-0.5h(-1), and keep more than 75% cell viability in the worst conditions. They produced ethanol with yield 0.44+/-0.01 g/g and specific productivity 0.14-0.17 g/(gh) at all dilution rates. Glycerol was the main by-product of the cultivations, which yielded 0.039-0.052 g/g. HMF present in the hydrolyzate was converted 48-71% by the encapsulated yeast, while furfural was totally converted at dilution rates 0.1 and 0.2h(-1) and partly at the higher rates. Continuous cultivation of encapsulated yeast was also investigated on glucose in synthetic medium up to dilution rate 1.0 h(-1). At this highest rate, ethanol and glycerol were also the major products with yields 0.43 and 0.076 g/g, respectively. The experiments lasted for 18-21 days, and no damage in the capsules was detected.

journal_name

J Biotechnol

journal_title

Journal of biotechnology

authors

Talebnia F,Taherzadeh MJ

doi

10.1016/j.jbiotec.2006.03.013

subject

Has Abstract

pub_date

2006-09-18 00:00:00

pages

377-84

issue

3

eissn

0168-1656

issn

1873-4863

pii

S0168-1656(06)00210-0

journal_volume

125

pub_type

杂志文章
  • Genome improvement of the acarbose producer Actinoplanes sp. SE50/110 and annotation refinement based on RNA-seq analysis.

    abstract::Actinoplanes sp. SE50/110 is the natural producer of acarbose, which is used in the treatment of diabetes mellitus type II. However, until now the transcriptional organization and regulation of the acarbose biosynthesis are only understood rudimentarily. The genome sequence of Actinoplanes sp. SE50/110 was known befor...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2017.04.013

    authors: Wolf T,Schneiker-Bekel S,Neshat A,Ortseifen V,Wibberg D,Zemke T,Pühler A,Kalinowski J

    更新日期:2017-06-10 00:00:00

  • Vitamin D fortification of foods and prospective health outcomes.

    abstract::Vitamin D is essential for bone health and has significant roles in non-skeletal health and organ function. Dermal synthesis through exposure to ultraviolet B light is the major natural source of vitamin D, while only a small portion of the necessary amount can be acquired by a diet without fortified foods. In recent ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/j.jbiotec.2018.08.010

    authors: Moulas AN,Vaiou M

    更新日期:2018-11-10 00:00:00

  • Complete genome sequence of novel carbon monoxide oxidizing bacteria Citrobacter amalonaticus Y19, assembled de novo.

    abstract::We report here the complete genome sequence of Citrobacter amalonaticus Y19 isolated from an anaerobic digester. PacBio single-molecule real-time (SMRT) sequencing was employed, resulting in a single scaffold of 5.58Mb. The sequence of a mega plasmid of 291Kb size is also presented. ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2015.07.012

    authors: Ainala SK,Seol E,Park S

    更新日期:2015-10-10 00:00:00

  • An alpha-L-arabinofuranosidase from Penicillium purpurogenum: production, purification and properties.

    abstract::Penicillium purpurogenum secretes arabinofuranosidase to the growth medium. Highest levels of enzyme (1.0 U ml(-1)) are obtained when L-arabitol is used as carbon source, while 0.85 and 0.7 U ml(-1) are produced with sugar beet pulp and oat spelts xylan, respectively. By means of a zymogram, three bands with arabinofu...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(99)00190-x

    authors: De Ioannes P,Peirano A,Steiner J,Eyzaguirre J

    更新日期:2000-01-21 00:00:00

  • Solid-phase genetic engineering with DNA immobilized on a gold surface.

    abstract::A novel method for immobilizing large DNA fragments on a solid surface was developed. A mixed self-assembled monolayer of thiolated single-stranded DNA with inert alkanethiol was generated on a gold (Au) surface through the Au-S reaction. Surface-tethered DNA generated by this method was compatible with various geneti...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(02)00051-2

    authors: Kim JH,Hong JA,Yoon M,Yoon MY,Jeong HS,Hwang HJ

    更新日期:2002-07-03 00:00:00

  • A simple statistical test of taxonomic or functional homogeneity using replicated microbiome sequencing samples.

    abstract::One important question in microbiome analysis is how to assess the homogeneity of the microbial composition in a given environment, with respect to a given analysis method. Do different microbial samples taken from the same environment follow the same taxonomic distribution of organisms, or the same distribution of fu...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2016.10.020

    authors: Huson DH,Steel M,El-Hadidi M,Mitra S,Peter S,Willmann M

    更新日期:2017-05-20 00:00:00

  • Effect of lhcsr gene dosage on oxidative stress and light use efficiency by Chlamydomonas reinhardtii cultures.

    abstract::Unicellular green algae, a promising source for renewable biofuels, produce lipid-rich biomass from light and CO2. Productivity in photo-bioreactors is affected by inhomogeneous light distribution from high cell pigment causing heat dissipation of light energy absorbed in excess and shading of the deep layers. Contras...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2020.12.023

    authors: Barera S,Dall'Osto L,Bassi R

    更新日期:2021-01-09 00:00:00

  • Analysis and optimization of triacylglycerol synthesis in novel oleaginous Rhodococcus and Streptomyces strains isolated from desert soil.

    abstract::As oleaginous microorganisms represent an upcoming novel feedstock for the biotechnological production of lipids or lipid-derived biofuels, we searched for novel, lipid-producing strains in desert soil. This was encouraged by the hypothesis that neutral lipids represent an ideal storage compound, especially under arid...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2016.03.040

    authors: Röttig A,Hauschild P,Madkour MH,Al-Ansari AM,Almakishah NH,Steinbüchel A

    更新日期:2016-05-10 00:00:00

  • Synergistic effects of chromosomal ispB deletion and dxs overexpression on coenzyme Q(10) production in recombinant Escherichia coli expressing Agrobacterium tumefaciens dps gene.

    abstract::For biotechnological production of coenzyme Q(10) (CoQ(10)) in recombinant Escherichia coli, three genetic manipulations were performed: heterologous expression of decaprenyl diphosphate synthase (Dps) from Agrobacterium tumefaciens, deletion of endogenous octaprenyl diphosphate synthase (IspB), and overexpression of ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2009.04.010

    authors: Choi JH,Ryu YW,Park YC,Seo JH

    更新日期:2009-10-12 00:00:00

  • Enhanced expression of human prostaglandin H synthase-2 in the yeast Pichia pastoris and removal of the C-terminal tag with bovine carboxypeptidase A.

    abstract::Vertebrate prostaglandin H synthases (PGHSs) are membrane-bound disulphide-containing hemoglycoproteins. Therefore, eukaryotic expression systems are required for the production of recombinant PGHSs. Recently we announced the expression of human PGHS-2 (hPGHS-2) in the yeast Pichia pastoris. Here we report improved pr...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2016.06.015

    authors: Kukk K,Samel N

    更新日期:2016-08-10 00:00:00

  • Mammalian cell culture scale-up and fed-batch control using automated flow cytometry.

    abstract::Detailed knowledge of mammalian cell culture proliferation kinetics is important to determine fed-batch strategies for industrial bioreactor operations. In particular, predicting the end of exponential proliferation in batch culture is a critical process parameter during culture scale-up. Using automated flow cytometr...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2008.03.019

    authors: Sitton G,Srienc F

    更新日期:2008-06-01 00:00:00

  • Studies on the properties of Celluclast/Eudragit L-100 conjugate.

    abstract::A cellulase from Trichoderma reesei was immobilized on Eudragit L-100, a reversibly soluble polymer depending on the pH of the medium. The solubility of the modified cellulase was studied at different pH values. By changing the pH, the adsorption equilibrium of the derivatized proteins is switched towards the liquid p...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(02)00178-5

    authors: Dourado F,Bastos M,Mota M,Gama FM

    更新日期:2002-10-23 00:00:00

  • Production of flavor esters catalyzed by CALB-displaying Pichia pastoris whole-cells in a batch reactor.

    abstract::Candida antarctica lipase B (CALB) has been employed as an efficient catalyst in the preparation of many flavor esters. A CALB-displaying yeast whole-cell biocatalyst could be an attractive alternative to commercial immobilized CALB because of its low-cost preparation and high enzymatic activity. We investigated the p...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2012.02.013

    authors: Jin Z,Ntwali J,Han SY,Zheng SP,Lin Y

    更新日期:2012-05-31 00:00:00

  • Very high expression of an anti-carcinoembryonic antigen single chain Fv antibody fragment in the yeast Pichia pastoris.

    abstract::In this paper we report the development of a recombinant strain of the yeast Pichia pastoris, which secretes an anti-carcinoembryonic antigen single chain Fv (scFv) antibody fragment to the culture supernatant as a biologically active protein, at levels of 1.2 g l(-1). The yeast scFv was purified by IMAC, with a final...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(99)00183-2

    authors: Freyre FM,Vázquez JE,Ayala M,Canaán-Haden L,Bell H,Rodríguez I,González A,Cintado A,Gavilondo JV

    更新日期:2000-01-21 00:00:00

  • Purification and characterization of recombinant human interleukin-29 expressed in Escherichia coli.

    abstract::Human interleukin (IL)-29 is the latest member of the class II cytokine family. However, as a result of lacking efficient method to generate relatively large quantity of IL-29, little is known of its functions in man. In the present study, an Escherichia coli expression system for the rapid expression of the human IL-...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.11.019

    authors: Li M,He S

    更新日期:2006-04-10 00:00:00

  • Simultaneous biosynthesis of (+)-geodin by a lovastatin-producing fungus Aspergillus terreus.

    abstract::The simultaneous biosynthesis of lovastatin (mevinolinic acid) and (+)-geodin by Aspergillus terreus ATCC 20542 with regard to the medium composition, i.e. the concentrations of carbon and nitrogen source, was described in this paper. A. terreus is a lovastatin producer but the formation of lovastatin was accompanied ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2007.07.493

    authors: Bizukojc M,Ledakowicz S

    更新日期:2007-12-01 00:00:00

  • Glucose oxidase immobilization on a novel cellulose acetate-polymethylmethacrylate membrane.

    abstract::Glucose oxidase (GOD) was immobilized on cellulose acetate-polymethylmethacrylate (CA-PMMA) membrane. The immobilized GOD showed better performance as compared to the free enzyme in terms of thermal stability retaining 46% of the original activity at 70 degrees C where the original activity corresponded to that obtain...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.08.019

    authors: Rauf S,Ihsan A,Akhtar K,Ghauri MA,Rahman M,Anwar MA,Khalid AM

    更新日期:2006-02-10 00:00:00

  • Structures of almond hydroxynitrile lyase isoenzyme 5 provide a rationale for the lack of oxidoreductase activity in flavin dependent HNLs.

    abstract::Hydroxynitrile lyases (HNLs) catalyze the asymmetric addition of HCN to aldehydes producing enantiomerically pure cyanohydrins. These enzymes can be heterologously expressed in large quantities making them interesting candidates for industrial applications. The HNLs from Rosaceae evolved from flavin dependent dehydrog...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/j.jbiotec.2016.04.013

    authors: Pavkov-Keller T,Bakhuis J,Steinkellner G,Jolink F,Keijmel E,Birner-Gruenberger R,Gruber K

    更新日期:2016-10-10 00:00:00

  • Use of immobilized cytochrome c as a ligand for affinity chromatography of thiosulfate dehydrogenase from Acidithiobacillus ferrooxidans.

    abstract::Three matrices were used for immobilizing the cytochrome c: Sepharose CL-4B, Silasorb SPH amine and a laboratory-prepared new matrix based on crosslinked triazine (2,4,6-tris(aminoethylamine)-1,3,5-triazine) (TAT). Cytochrome c was immobilized on the matrices by several procedures and the amount of incorporated cytoch...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2005.01.014

    authors: Janiczek O,Pokorna B,Zemanova J,Mandl M

    更新日期:2005-05-25 00:00:00

  • Oligonucleotide array for detection of common severe determinants of alpha thalassemia.

    abstract::A simple and an efficient oligonucleotide array was developed to identify common severe determinants of alpha (alpha) thalassemia. A total of 14 probes were designed to detect the most frequently three deletions (-alpha(3.7), -alpha(4.2), -(SEA)) and two non-deletions (alpha(Quong Sze), alpha(Constant Spring)). PCR pr...

    journal_title:Journal of biotechnology

    pub_type: 临床试验,杂志文章

    doi:10.1016/j.jbiotec.2004.07.016

    authors: Ye BC,Zhang Z,Lei Z

    更新日期:2005-01-12 00:00:00

  • Enrichment of Plasticicumulans acidivorans at pilot-scale for PHA production on industrial wastewater.

    abstract::A PHA producing microbial culture dominated by Plasticicumulans acidivorans was enriched in a pilot plant using fermented wastewater from the Mars candy bar factory. The pilot plant comprised (1) anaerobic fermentation, (2) enrichment of a PHA-producing microbial community and (3) accumulation for maximization of the ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2014.10.022

    authors: Tamisa J,Lužkov K,Jiang Y,van Loosdrecht MC,Kleerebezem R

    更新日期:2014-12-20 00:00:00

  • Complete genome of biodegradable plastics-decomposing Roseateles depolymerans KCTC 42856(T) (=61A(T)).

    abstract::Roseateles depolymerans is a Gram-negative, rod-shaped, flagellated, obligately aerobic, photosynthetic bacterium that was isolated from the Hanamuro River, Ibaraki Prefecture, Japan. Here, we report the complete genome of R. depolymerans KCTC 42856(T) (=61A(T)=DSM 11813(T)=CCUG 48747(T)=NCIMB 13588(T)), which consist...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2016.01.012

    authors: Lee SH,Choe H,Kim SG,Park DS,Nasir A,Kim BK,Kim KM

    更新日期:2016-02-20 00:00:00

  • Rapid degradation of ferulic acid via 4-vinylguaiacol and vanillin by a newly isolated strain of bacillus coagulans.

    abstract::A new strain Bacillus coagulans BK07 was isolated from decomposed wood-bark, based on its ability to grow on ferulic acid as a sole carbon source. This strain rapidly decarboxylated ferulic acid to 4-vinylguaiacol, which was immediately converted to vanillin and then oxidized to vanillic acid. Vanillic acid was furthe...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(00)00248-0

    authors: Karmakar B,Vohra RM,Nandanwar H,Sharma P,Gupta KG,Sobti RC

    更新日期:2000-07-14 00:00:00

  • The metagenome of a biogas-producing microbial community of a production-scale biogas plant fermenter analysed by the 454-pyrosequencing technology.

    abstract::Composition and gene content of a biogas-producing microbial community from a production-scale biogas plant fed with renewable primary products was analysed by means of a metagenomic approach applying the ultrafast 454-pyrosequencing technology. Sequencing of isolated total community DNA on a Genome Sequencer FLX Syst...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2008.05.008

    authors: Schlüter A,Bekel T,Diaz NN,Dondrup M,Eichenlaub R,Gartemann KH,Krahn I,Krause L,Krömeke H,Kruse O,Mussgnug JH,Neuweger H,Niehaus K,Pühler A,Runte KJ,Szczepanowski R,Tauch A,Tilker A,Viehöver P,Goesmann A

    更新日期:2008-08-31 00:00:00

  • Isolation of mesophilic solvent-producing clostridia from Colombian sources: physiological characterization, solvent production and polysaccharide hydrolysis.

    abstract::One hundred and seventy-eight new butanol-acetone producing bacteria related to saccharolytic clostridia were isolated from agricultural sources in Colombia and their fermentation potential was evaluated. Thirteen isolates produced more total solvents from glucose than Clostridium acetobutylicum ATCC 824. The isolates...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(00)00218-2

    authors: Montoya D,Spitia S,Silva E,Schwarz WH

    更新日期:2000-04-28 00:00:00

  • Purification of the glycoprotein allergen Ag7 from mugwort pollen by concanavalin A affinity chromatography.

    abstract::Two affinity columns comprising immobilized concanavalin A (Con A), Con A-Sepharose and Con A-XP3507, were evaluated for their purifying ability for the glycoprotein allergen Ag7 from a partially purified extract of mugwort pollen. The most pronounced difference between the two columns was the nature of their nonspeci...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/0168-1656(90)90044-c

    authors: Nilsen BM,Smestad Paulsen B,Clonis Y,Mellbye KS

    更新日期:1990-11-01 00:00:00

  • Hydrolysis of softwood by Aspergillus mannanase: role of a carbohydrate-binding module.

    abstract::Endo beta-1,4-mannanases (beta-mannanases, EC 3.2.1.78), belonging to CAZy GH5 and GH26 families, catalyze the hydrolysis of structurally different mannans. In this study, the mannanase encoding gene of Aspergillus aculeatus VN was expressed in Aspergillus niger D15#26 using pAN 52-4 vector, under the control of PgpdA...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2010.05.012

    authors: Pham TA,Berrin JG,Record E,To KA,Sigoillot JC

    更新日期:2010-08-02 00:00:00

  • Combinatorial biosynthesis--potential and problems.

    abstract::Because of their ecological functions, natural products have been optimized in evolution for interaction with biological systems and receptors. However, they have not necessarily been optimized for other desirable drug properties and thus can often be improved by structural modification. Using examples from the litera...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章,评审

    doi:10.1016/j.jbiotec.2005.12.001

    authors: Floss HG

    更新日期:2006-06-25 00:00:00

  • Circadian rhythms in the cell cycle and biomass composition of Neochloris oleoabundans under nitrogen limitation.

    abstract::The circadian clock schedules processes in microalgae cells at suitable times in the day/night cycle. To gain knowledge about these biological time schedules, Neochloris oleoabundans was grown under constant light conditions and nitrogen limitation. Under these constant conditions, the only variable was the circadian ...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/j.jbiotec.2014.07.016

    authors: de Winter L,Schepers LW,Cuaresma M,Barbosa MJ,Martens DE,Wijffels RH

    更新日期:2014-10-10 00:00:00

  • Development of a serum-free medium for the production of erythropoietin by suspension culture of recombinant Chinese hamster ovary cells using a statistical design.

    abstract::In order to develop a serum-free (SF) medium for the production of erythropoietin (EPO) by suspension culture of recombinant Chinese hamster ovary (rCHO) cells, a statistical optimization approach based on a Plackett-Burman design was adopted. A basal medium was prepared by supplementing Iscove's modified Dulbecco's m...

    journal_title:Journal of biotechnology

    pub_type: 杂志文章

    doi:10.1016/s0168-1656(99)00004-8

    authors: Lee GM,Kim EJ,Kim NS,Yoon SK,Ahn YH,Song JY

    更新日期:1999-04-15 00:00:00