Can heat-pressed feldspathic ceramic be submitted to multiple heat-pressing?

Abstract:

:The aim of this study was to determine if multiple processing (heat-pressing) of a dental ceramic influences flexural strength, hardness, and microstructure. Ninety bar-shaped specimens (15 mm × 4 mm × 2 mm) of a pressed ceramic (Vita PM9) were fabricated and randomly divided into 6 groups (n = 15) according to the factors "number of pressings" (C1, C2, and C3, fired 1, 2, and 3 times, respectively) and "mechanical cycling" (M). Half of the specimens were mechanically cycled (106 cycles, 45 N, 3.4 Hz, in water) and all specimens were tested for 3-point bending (0.5 mm/min, load 1000 kgf) and Vickers hardness (19.6 N for 20 s). X-ray diffraction was used to characterize the phases and scanning electron microscopy to characterize the microstructure. The flexural strength data was statistically analyzed with Weibull analysis, ANOVA, and Tukey test. Hardness data was evaluated by 2-way ANOVA and Fisher test. All tests were performed with a significance level of 0.05. Two-way ANOVA revealed that neither "number of pressings" (p=0.085) or "mechanical cycling" (0.055) significantly affected flexural strength. But Weibull analysis showed significant difference for Weibull moduli and characteristic strength between groups. For hardness, a statistical difference was seen for the interaction "Number of pressings * Mechanical cycling", (p = 0.016). Hardness decreased in the following order: C1 (775±17.2), CM3 (751±101), CM2 (735±45), C3 (701±82), CM1 (671±82), and C2 (663±92). Fewer defects were observed with an increased number of firings. Therefore, the possibility of recycling PM9 ceramic does not interfere in the evaluated mechanical properties and improves microstructure.

journal_name

Braz Oral Res

journal_title

Brazilian oral research

authors

Dal Piva AMO,Barcellos ASP,Bottino MA,Souza ROAE,Melo RM

doi

10.1590/1807-3107bor-2018.vol32.0106

subject

Has Abstract

pub_date

2018-10-25 00:00:00

pages

e106

eissn

1806-8324

issn

1807-3107

pii

S1806-83242018000100284

journal_volume

32

pub_type

杂志文章
  • Host response and peri-implantitis.

    abstract::Considering the absence of predictable and effective therapeutic interventions for the treatment of peri-implantitis, scientific evidence concerning the host response profile around dental implants could be important for providing in the future a wider preventive and/or therapeutic window for this peri-implant lesion,...

    journal_title:Brazilian oral research

    pub_type: 杂志文章,评审

    doi:10.1590/1807-3107bor-2019.vol33.0066

    authors: Corrêa MG,Pimentel SP,Ribeiro FV,Cirano FR,Casati MZ

    更新日期:2019-09-30 00:00:00

  • Epidemiologic survey of traumatic dental injuries in children seen at the Federal University of Rio de Janeiro, Brazil.

    abstract::This epidemiologic survey aimed at assessing the prevalence of traumatic dental injuries in children seen at the Federal University of Rio de Janeiro, Brazil. The records of a total of 111 children (aged 0 to 6 years) seen from 2004 to 2006 in the dental trauma clinic were surveyed, comprising a total of 201 traumatiz...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242010000100015

    authors: Jesus MA,Antunes LA,Risso Pde A,Freire MV,Maia LC

    更新日期:2010-01-01 00:00:00

  • Diagnosing non-cavitated lesions in epidemiological studies: practical and scientific considerations.

    abstract::Over the last decade, there has been growing interest in diagnosing non-cavitated lesions in epidemiological studies involving large numbers of preschool children, schoolchildren and young adults. In this context, assessment of lesions characteristics indicating whether or not there is ongoing mineral loss is also con...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/S1806-83242013005000036

    authors: Carvalho JC,Mestrinho HD

    更新日期:2014-01-01 00:00:00

  • The 100 most-cited papers in oral medicine and pathology.

    abstract::This study aimed to analyze the 100 most-cited papers in the field of oral medicine and pathology over time, identifying the areas of more intense research. Papers in journals of oral medicine and pathology were identified using the Web of Science database. The specified research period was between 1900 and 2019. Desc...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2021.vol35.0020

    authors: Martelli AJ,Machado RA,Martelli DRB,Neves LTD,Martelli Junior H

    更新日期:2020-12-18 00:00:00

  • Surface roughness and wear of resin cements after toothbrush abrasion.

    abstract::Increased surface roughness and wear of resin cements may cause failure of indirect restorations. The aim of this study was to evaluate quantitatively the surface roughness change and the vertical wear of four resin cements subjected to mechanical toothbrushing abrasion. Ten rectangular specimens (15 × 5 × 4 mm) were ...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2015.vol29.0011

    authors: Ishikiriama SK,Ordoñéz-Aguilera JF,Maenosono RM,Volú FL,Mondelli RF

    更新日期:2015-01-01 00:00:00

  • Surface agents' influence on the flexural strength of bilaminated ceramics.

    abstract::The objective of this study was to evaluate the influence of different surface agents on the flexural strength of a ceramic system. Eighty bar-shaped specimens of zirconia were divided into four groups according to the agent to be used: group Control--to be cleaned with alcohol; group VM9--application of a fluid layer...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242013000400004

    authors: Lima JM,Anami LC,Rippe MP,de Melo RM,Bottino MA,Valera MC,Araújo MA

    更新日期:2013-07-01 00:00:00

  • Impact of malocclusion on oral health-related quality of life among schoolchildren.

    abstract::The aim of the present study was to evaluate the prevalence and impact of malocclusion on oral health-related quality of life (OHRQoL) among schoolchildren aged 8 to 10 years and their parents in Diamantina, a town in the southeast of Brazil. A cross-sectional study was conducted with a sample of 390 randomly selected...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2018.vol32.0095

    authors: Guimarães SPA,Jorge KO,Fontes MJF,Ramos-Jorge ML,Araújo CTP,Ferreira EF,Melgaço CA,Zarzar PM

    更新日期:2018-01-01 00:00:00

  • Influence of photobiomodulation therapy on root development of rat molars with open apex and pulp necrosis.

    abstract::This study aimed to evaluate the role of photobiomodulation (PBM) in apexification and apexogenesis of necrotic rat molars with an open apex. Rat molars were exposed to the oral environment for 3 weeks. Canals were rinsed with 2.5% NaOCl and 17% EDTA, filled with antibiotic paste and sealed. After 7 days, canals were ...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2019.vol33.0084

    authors: Zaccara IM,Jardine AP,Mestieri LB,Quintana RM,Jesus L,Moreira MS,Grecca FS,Martins MD,Kopper PMP

    更新日期:2019-08-26 00:00:00

  • Anti-dentine Salivary SIgA in young adults with a history of dental trauma in deciduous teeth.

    abstract::Anti-dentin autoantibodies are associated with inflammatory root resorption in permanent teeth and are modulated by dental trauma and orthodontic force. However, it is not known whether deciduous tooth trauma can stimulate the development of a humoral immune response against dentin. The aim of this study was to evalua...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107BOR-2015.vol29.0102

    authors: Seixas GF,Garbelini CC,Aida KL,Cheirubim AP,Venâncio EJ,Ramos Sde P

    更新日期:2015-01-01 00:00:00

  • Effect of cleanser solutions on the color of acrylic resins associated with titanium and nickel-chromium alloys.

    abstract::This study evaluated the effect of cleanser solutions on the color of heat-polymerized acrylic resin (HPAR) and on the brightness of dental alloys with 180 immersion trials. Disk-shaped specimens were made with I) commercially pure titanium, II) nickel-chromium-molybdenum-titanium, III) nickel-chromium molybdenum, and...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2014.vol28.0017

    authors: Freitas Oliveira Paranhos Hd,Bezzon OL,Davi LR,Felipucci DN,Silva CH,Pagnano VO

    更新日期:2014-01-01 00:00:00

  • Over-the-counter whitening agents: a concise review.

    abstract::Tooth discoloration is commonly found in the dental clinic and tooth bleaching has been considered the preferred esthetic alternative, being more conservative, safe and with predictable results. Supervised home-use of 10% Carbamide Peroxide (CP) bleaching with custom-trays is the most common bleaching procedure dispen...

    journal_title:Brazilian oral research

    pub_type: 杂志文章,评审

    doi:10.1590/s1806-83242009000500010

    authors: Demarco FF,Meireles SS,Masotti AS

    更新日期:2009-01-01 00:00:00

  • Evaluation of the impact of orthognathic surgery on quality of life.

    abstract::Dental treatment and surgery is a well-established method of correcting dentofacial deformities, and such treatment has an impact on the quality of life of individuals. The objective of this study was to evaluate the effect of orthognathic surgery on the quality of life of patients receiving treatment at the Universid...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107BOR-2016.vol30.0004

    authors: Corso PF,Oliveira FA,Costa DJ,Kluppel LE,Rebellato NL,Scariot R

    更新日期:2016-01-01 00:00:00

  • Flexural strength and modulus of elasticity of different types of resin-based composites.

    abstract::The aim of the study was to test whether the filler composition of resin composites influences their flexural strength and modulus of elasticity. Flexural strength and modulus of elasticity were obtained through a three-point bending test. Twelve bar shaped specimens of 5 commercially available composites--Supreme (3M...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242007000100003

    authors: Rodrigues Junior SA,Zanchi CH,Carvalho RV,Demarco FF

    更新日期:2007-01-01 00:00:00

  • Randomized clinical trials of dental bleaching - Compliance with the CONSORT Statement: a systematic review.

    abstract::We reviewed the literature to evaluate: a) The compliance of randomized clinical trials (RCTs) on bleaching with the CONSORT; and b) the risk of bias of these studies using the Cochrane Collaboration risk of bias tool (CCRT). We searched the Cochrane Library, PubMed and other electronic databases, to find RCTs focused...

    journal_title:Brazilian oral research

    pub_type: 杂志文章,评审

    doi:10.1590/1807-3107BOR-2017.vol31.0060

    authors: Loguercio AD,Maran BM,Hanzen TA,Paula AM,Perdigão J,Reis A

    更新日期:2017-08-28 00:00:00

  • Orofacial manifestations of COVID-19: a brief review of the published literature.

    abstract::Coronavirus disease 2019 (COVID-19) has spread exponentially across the world. The typical manifestations of COVID-19 include fever, dry cough, headache and fatigue. However, atypical presentations of COVID-19 are being increasingly reported. Recently, a number of studies have recognized various mucocutaneous manifest...

    journal_title:Brazilian oral research

    pub_type: 杂志文章,评审

    doi:10.1590/1807-3107bor-2020.vol34.0124

    authors: Halboub E,Al-Maweri SA,Alanazi RH,Qaid NM,Abdulrab S

    更新日期:2020-10-30 00:00:00

  • Effect of enamel matrix proteins on the treatment of intrabony defects: a split-mouth randomized controlled trial study.

    abstract::The objective of this split-mouth, double-blind, randomized controlled trial was to compare the clinical effect of treatment of 2- or 3-wall intrabony defects with open flap debridement (OFD) combined or not with enamel matrix proteins (EMP). Thirteen volunteers were selected with one pair of or more intrabony defects...

    journal_title:Brazilian oral research

    pub_type: 杂志文章,随机对照试验

    doi:10.1590/s1806-83242007000300009

    authors: Chambrone D,Pasin IM,Conde MC,Panutti C,Carneiro S,Lima LA

    更新日期:2007-07-01 00:00:00

  • Educative practices and attitudes within the pre-school environment: evaluating the education professionals.

    abstract::School and family together play an important role in the individual development of children. Therefore, this study aimed at evaluating the practices and attitudes towards oral health care of 245 education professionals working in 24 public municipal pre-schools in Niterói, State of Rio de Janeiro, Brazil. The data wer...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242008000400010

    authors: Antunes Ldos S,Antunes LA,Corvino MP

    更新日期:2008-10-01 00:00:00

  • Drugs or disease: evaluating salivary function in RA patients.

    abstract::Oral complications of RA may include temporomandibular joint disorders, mucosa alterations and symptoms of dry mouth. The aim of this study was to evaluate the salivary gland function of subjects with rheumatoid arthritis (RA) comparing it to healthy controls. Subjects with other systemic conditions known to affect sa...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107BOR-2016.vol30.0106

    authors: Torres SR,Pedrazas CH,Correia MP,Azevedo MN,Zamprogno T,Silva A Junior,Gonçalves LS,Papi JA

    更新日期:2016-10-10 00:00:00

  • Bone healing of mandibular critical-size defects in spontaneously hypertensive rats.

    abstract::Few articles have shown changes in bone metabolism caused by hypertension. The objective of this study was to investigate the relationship between hypertension and bone healing. Circular critical-size defects 5 mm and 2 mm in diameter were created, respectively, on the left and right side of the mandible in 40 spontan...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/S1806-83242013000500006

    authors: Chin VK,Shinagawa A,Naclério-Homem Mda G

    更新日期:2013-09-01 00:00:00

  • Ex vivo evaluation of three instrumentation techniques on E. faecalis biofilm within oval shaped root canals.

    abstract::The objective of the present study was to assess the effectiveness of reciprocating instrumentation in disinfecting oval-shaped root canals infected with Enterococcus faecalis. Forty-five human lower premolars were infected with a culture of E. faecalis (ATCC 29212) for 28 days. Five other teeth that were neither cont...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107BOR-2015.vol29.0027

    authors: Nakamura VC,Candeiro GT,Cai S,Gavini G

    更新日期:2015-01-01 00:00:00

  • Evaluation of the risk of a stripping perforation with Gates-Glidden drills: serial versus crown-down sequences.

    abstract::The aim of this study was to evaluate the remaining dentine/cementum thickness using Gates-Glidden burs in serial and crown-down sequences and to observe which of the two sequences is the safest for preparing mesial roots of molars. Thirty-six left and right human mandibular first molars were selected. Standard access...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242008000100004

    authors: Coutinho-Filho T,De-Deus G,Gurgel-Filho ED,Rocha-Lima AC,Dias KR,Barbosa CA

    更新日期:2008-01-01 00:00:00

  • Low prevalence of gingival overgrowth associated to new imunossupressive protocols with cyclosporin.

    abstract::Gingival overgrowth (GO) is a frequent finding in patients treated with cyclosporine (CsA). This study investigated the prevalence and severity of GO in patients who received kidney transplant and CsA therapy, as well as associations with pharmacological and clinical factors. This cross-sectional study included 63 kid...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242011005000016

    authors: Wentz LA,Oliveira SC,Moreira CH,Rösing CK

    更新日期:2012-01-01 00:00:00

  • Signs and symptoms of temporomandibular disorders in adolescents.

    abstract::The aim of this study was to verify the prevalence of signs and symptoms of temporomandibular disorders (TMD) in adolescents and its relationship to gender. The sample comprised 217 subjects, aged 12 to 18. The subjective symptoms and clinical signs of TMD were evaluated, using, respectively, a self-report questionnai...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242005000200004

    authors: Bonjardim LR,Gavião MB,Pereira LJ,Castelo PM,Garcia RC

    更新日期:2005-04-01 00:00:00

  • PAR-2 expression in the gingival crevicular fluid reflects chronic periodontitis severity.

    abstract::Recent studies investigating protease-activated receptor type 2 (PAR-2) suggest an association between the receptor and periodontal inflammation. It is known that gingipain, a bacterial protease secreted by the important periodontopathogen Porphyromonas gingivalis can activate PAR-2. Previous studies by our group foun...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107BOR-2017.vol31.0016

    authors: Fukushima H,Alves VT,Carvalho VF,Ambrósio LM,Eichler RA,Carvalho MH,Saraiva L,Holzhausen M

    更新日期:2017-01-26 00:00:00

  • Mouthwashes for the control of supragingival biofilm and gingivitis in orthodontic patients: evidence-based recommendations for clinicians.

    abstract::Properly performed daily mechanical biofilm control is the most important prevention strategy for periodontal diseases. However, proper mechanical biofilm control is not performed effectively by the majority of the population, mainly due to lack of motivation and of manual dexterity. Local biofilm retention factors ma...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2014.vol28.0021

    authors: Haas AN,Pannuti CM,Andrade AK,Escobar EC,Almeida ER,Costa FO,Cortelli JR,Cortelli SC,Rode SD,Pedrazzi V,Oppermann RV

    更新日期:2014-07-11 00:00:00

  • In vitro evaluation of the root canal cleaning ability of plant extracts and their antimicrobial action.

    abstract::This in vitro study evaluated both the antimicrobial activity and the root canal cleaning ability of plant extracts used in irrigation solutions. The antimicrobial activities of the aroeira-da-praia (Schinus terebintifolius Raddi) and the quixabeira (Syderoxylum obtusifolium Roem & Schult) hydroalcoholic extracts, of ...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242012000300006

    authors: Costa EM,Evangelista AP,Medeiros AC,Dametto FR,Carvalho RA

    更新日期:2012-05-01 00:00:00

  • Relationship between dental fluorosis and quality of life: a population based study.

    abstract::The aim of this study was to verify the prevalence of dental fluorosis in schoolchildren aged 6 to 15 and its possible association with the impacts on their daily activities. This study is observational, cross-sectional and analytical. A total of 513 schoolchildren from the city of Pinheiro Preto, SC, took part in thi...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242005000200014

    authors: Michel-Crosato E,Biazevic MG,Crosato E

    更新日期:2005-04-01 00:00:00

  • Influence of implantoplasty on stress distribution of exposed implants at different bone insertion levels.

    abstract::This study evaluated the effect of implantoplasty on different bone insertion levels of exposed implants. A model of the Bone Level Tapered implant (Straumann Institute, Waldenburg, Switzerland) was created through the Rhinoceros software (version 5.0 SR8, McNeel North America, Seattle, WA, USA). The abutment was fixe...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2017.vol31.0096

    authors: Tribst JPM,Dal Piva AMO,Shibli JA,Borges ALS,Tango RN

    更新日期:2017-12-07 00:00:00

  • Analysis of enamel and material wear by digital microscope: an in-vitro study.

    abstract::The objective of the study was to analyze the surface area (SA) of the wear caused by simulated chewing on human enamel and opposing restorative material, namely: composite resin (CR), porcelain fused to metal (PFM), lithium disilicate (LD), or monolithic zirconia (MZr). Forty-eight premolars were selected as enamel s...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/1807-3107bor-2019.vol33.0121

    authors: Habib SR,Ansari AS,Alqahtani M,Alshiddi IF,Alqahtani AS,Hassan SH

    更新日期:2020-01-10 00:00:00

  • Evaluation of surface characteristics of Ti-6Al-4V and Tilite alloys used for implant abutments.

    abstract::The aim of this study was to evaluate surface free energy (SFE), surface roughness (SR) and surface hardness (SH) of two commercially available materials for fabricating dental implant abutments. In addition, the specimens were investigated by scanning electron microscopy (SEM) to determine the surface morphology. Twe...

    journal_title:Brazilian oral research

    pub_type: 杂志文章

    doi:10.1590/s1806-83242006000400005

    authors: Lima EM,Silva WJ,Moura JS,Faot F,Del Bel Cury AA

    更新日期:2006-10-01 00:00:00